2017 FORD EDGE Complaints

Service order: dated 08/07/23 Engine light on and and off several times Check codes: found p301 and p316 as well as coolant intrusion in cylinder #1 lost psi of pressure on the coolant system in 10 minutes. Needs long block Conclusion by tech: needs a new engine costing over $9000. The cost for computer test $240.00 This was after spending $661.97 for a fuel vapour Sep installed. Don’t know if needed or not.

The contact owns a 2017 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that coolant had leaked into the cylinder and the engine needed to be replaced. The vehicle was not repaired. The contact was informed that the failure was referenced in TSB: 22-2229. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty. The failure mileage was approximately 104,000.

Check Engine light came on and I scheduled an appointment at an independent repair shop. Before the appointment date, the engine gave an overheat warning. The system was low on coolant (filled about 3/4 of a gallon). A day before the appointment it overheated again and this time was able to fill another 1/4 gallon. Independent repair shop diagnosed and could not find any signs of exterior coolant leaks. The check engine light was due to cylinder misfiring, and the shop believes that the coolant is leaking into the cylinder and burning off as they witnessed white smoke from the tailpipe. They referenced Technical Services Bulletin #22-2229 as a known problem with the only fix as replacing the engine long block. Contacted Ford and they said that they wouldn't help me as my car is 9,000 miles over the warranty period. There is no way to tell when this issue will render the car inoperable and possibly strand my family somewhere or worse cause the system to shut down at freeway speeds.

Vehicle was idling rough and not able to accelerate. Vehicle was overheating consuming coolant. After 2 weeks a check engine light came on. Dealer inspected and found coolant intrusion on 2 cylinders. Design flaw known by Ford.

The car overheated due to a known engine defect which allowed the coolant to leak into the engine block. The car now needs a whole new engine. This is what the Ford Dealer gave me. This service bulletin is dated June of 2022 TECHNICAL SERVICE BULLETIN 22-2229 2.0L EcoBoost - Coolant In Cylinders, White Exhaust Smoke And/Or Illuminated MIL This bulletin supersedes 22-2133. Model: Ford 2015-2018 Edge

The contact owns a 2017 Ford Edge. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that an engine cylinder was misfiring. The mechanic replaced the cylinder; however, the failure reoccurred. Additionally, the contact stated while driving 65-70 MPH, the vehicle made abnormal beeping sounds and decelerated unintendedly to 35 MPH. The contact was able to veer to the side of the road. The vehicle was towed to an independent mechanic, where the contact was informed that there was no coolant in the vehicle. The mechanic added coolant in the vehicle to determine whether coolant was leaking. The vehicle was not repaired and was returned to the contact. The contact stated that the failure recurred while driving. The contact veered to the side of the road and turned off the vehicle for 5 minutes. The contact restarted the vehicle and drove to the nearest independent mechanic, where it was diagnosed that coolant was leaking into the head gasket and the engine needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The contact related the failure to TSB Number: 22-2133. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 45,500.

2017 Ford Edge- 60,443 miles.Engine-check engine light came on 3 separate times. Had inspected each time- result was the same- " misfire in cylinder 2" light would go off- car running as usual. Then while driving on the freeway apx 70 mph the warning lights came on that the engine was overheating. This was a very dangerous situation. Immediately took the next exit and pulled into gas station. Five minutes later was able to drive 10 minutes to my home with no incident. The next morning, could not even drive 5 minutes out of my neighborhood before it happened again except this time warnings also included that the car was going into power saving mode. Immediately turned around and took it back home. This problem has been both reproduced and confirmed by both a certified repair shop and a Ford Dealership who both determined that coolant is leaking into cylinder 2 causing the problem. Ford is aware of this and has issued multiple service bulletins regarding this situation but will not put a recall out for this. This is a serious problem.

The contact owns a 2017 Ford Edge. The contact stated while driving 45-55 MPH, the A/C started blowing hot air and the vehicle was jerking. There was no warning light illuminated. The vehicle was taken to the dealer, where the failure could not be duplicated; however, the failure recurred. The contact stated that coolant was added to the vehicle. The contact stated that the failure recurred several times while driving, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic several times, and the oxygen sensors, the purge valve, the ignition coils, and the spark plugs were replaced; however, the failure persisted. The check engine warning light was illuminated. The contact received a notice for Ford Campaign Number: 22N12, and the vehicle was taken to a second dealer, Hodges Ford (13452 GA-251, Darien, GA 31305), for the repair. The dealer determined that the coolant and the washer fluid were leaking into the engine, and that the engine needed to be replaced. The dealer informed the contact that the repair was not covered under warranty. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 58,614.

I bought the car in July 2022 with 62,000 miles for my daughter. The car now has 65,000 miles on it as she only drives back and forth to school. Check engine light came on a month ago then 2 weeks later it overheated with coolant light coming on. It took over a month to get in to the dealership to look at the car. Today they looked at it and told me the coolant had an leaked into the engine due to an engine defect so I would need a new long block engine that will cost about 8,000 to repair. Of course it’s not under warranty and even thigh Ford knows it’s an engine defect and fixed the issue in the replacement they will not cover the charges. They recalled the 1.6 engine but not the 2.0 so now I have to pay for a new engine for a car I just bought for 23,000 a year ago. I was also told even if they do a recall I may not be reimbursed for the cost of the new engine. I am absolutely appalled that a car with 65,000 miles requires a new engine, this is Ford design issue and they are not taking any responsibility. I see there is a class action lawsuit against them for this issue. We are a Ford family owning 3 of them but after this experience I am trading them all in and will never buy a Ford again. All they have to do is the right thing but instead they won’t do it. There is a service bulletin for this exact issue. The dealership is very kind but nothing they can do to help.

So the car has a code p0302 coolant is leaking in cylinder #2 which is causing the car to run rough and overheat because of coolant loss and from what I understand can eventually cause a engine fire I’ve taken it to a shop to find this out but it hasn’t been inspected by the manufacturer police or insurance representatives the check engine light has been intermittently coming on and going back off until one day it just stayed on