2004 FORD F-250 Complaints

THIS IS THE 8TH SEPARATION OUT OF 11 TIRES THEY HAVE ALL HAPPENED AFTER ABOUT 2 HOURS OF HIGHWAY DRIVING THIS ONE BLOW AND CAUSED ABOUT 2300 DOLLARS OF DAMAGE TO MY TRUCK NOT INCLUDING THE TIRE 3 MILES SOUTH OF IOLA KANSAS COMING FROM INDEPENDENCE MISSOURI IT GAVE ABOUT 3 TO 5 SECONDS OF BOBBLE AND AS I APPLIED THE BRAKES TO PULL OVER IT BLEW. THIS CAUSED THE TRUCK TO GO INTO THE ON COMING TRAFFIC AND I WAS JUST ABLE TO GET CONTROL OF THE TRUCK AND GET IT OFF THE ROAD.BF GOODICH CLAIM THERE IS NOT A PROBLEM WITH THIS TIRE BUT I HAVE DISCOVERED WHY THEY SAY THAT. THIS SIZE OF TIRE USUALLY IS PURCHASED FOR JEEPS AND SMALL PICKUP WEIGHING 3000 TO 4000 POUNDS BUT IS RATED FOR E LOAD WHEN YOU USED THE TIRE ON A LIGHTER VEHICLE IT DOES NOT HEAT UP BUT MY PICKUP IS 9000 LBS. BEFORE THIS LAST TRIP I HAD COSTCO CHECK THE TIRES AND AIR PRESSURE THE DAY BEFORE THE TRIP AND I CHECKED THEM ON THE DAY OF THE TRIP. SO I KNOW THEY WERE AIR TO THE REQUIRED PRESSURE. I BELIEVE THE TIRE MUST BE RECALLED AND LOAD RATED NO HIGH THAN C

TL* THE CONTACT OWNS A 2004 FORD F-250. WHILE DRIVING 50 MPH WITHOUT WARNING, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNDER RECALL. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 225,000. UPDATED 1/21/2016 *SS *TR

TL* THE CONTACT OWNS A 2004 FORD F-250. THE CONTACT STATED THAT THE FUEL LINES WERE SEVERELY CORRODED AND WERE LEAKING. AS A RESULT, THE TRANSMISSION FAILED WHILE DRIVING AT 40 MPH, CAUSING THE CONTACT TO USE EXCESSIVE FORCE IN ORDER TO DRIVE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REPLACED THE POWER STEERING FUEL LINE, ONE BRAKE LINE, AND ONE TRANSMISSION FUEL LINE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. UPDATE 01/13/16 MA

DRIVING ON THE HIGHWAY , COMPLETE LOSS OF THROTTLE BUT THE ENGINE WAS STILL RUNNING AT A LOW AMPERAGE. WAS ABLE TO PULL OFF THE ROAD AND TURNED IT OFF. IT WOULDN'T START BACK UP RIGHT AWAY. HAD TO WAIT A WHILE IT WOULD START AND LIMPED IT HOME. NO PROBLEMS FOR A FEW DAYS, THEN IT STARTED ACTING UP AGAIN. A COUPLE TIMES IT WOULD START, BUT AT A LOW IDLE WITH NO RESPONSE OF THE GAS PEDDLE. THE FINAL STRAW WAS LAST WEEK. I WAS DRIVING ON THE HIGHWAY TO WORK. EACH TIME I CAME TO A STOP, IT WOULD LOSE THROTTLE. I WAS ABLE TO TURN IT OFF AND BACK ON TO GET GOING. THEN AT A MAJOR INTERSECTION OF HWY 41 AND 145, IT WOULDN'T TURN BACK ON AND I WAS IN THE MIDDLE OF THE HWY. I HAD TO PUSH IT TO THE SIDE OF THE ROAD AND IT WOULD TURN BUT NOT START. I HAD IT TOWED TO MY MECHANIC ON SATURDAY AND MONDAY WHEN THEY GOT TO IT, AFTER CHARGING THE BATTERIES, IT STARTED RIGHT UP AND THEY HAVEN'T BEEN ABLE TO GET IT TO FAIL...WHEN THIS HAPPENS, THERE IS NO OIL PRESSURE ON THE GAUGE. THIS IS DANGEROUS AND POTENTIALLY HAZARDOUS OR DEADLY. I COULD HAVE EASILY BEEN INJURED OR KILLED IF I HAD BEEN HIT.

BF GOODRICH TA KM2 TIRES I HAVE THREE SEPARATE ON A TRIP THAT STARTED AUGUST 14,2015 THE TIRES HAVE 19000 MILES ON THEM. THE FIRST TIRE SEPARATED ON THE 14TH AND I PUT A SPARE ON IT. THE OTHER TWO TIRES SEPARATED ON THE 16TH AND NOW THE 4TH TIRE IS SHOWING SIGNS OF SEPARATION. THE TIRES WERE PURCHASED FROM COSTCO ON 6/6/2012 MILEAGE ON THE PICHUP WAS 151101 AND IS NOW170852.2

TL* THE CONTACT OWNS A 2004 FORD F-250. WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD STALL WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 184,000.

TL* THE CONTACT OWNS A 2004 FORD F-250. WHILE DRIVING 45 MPH IN RAINY CONDITIONS, THE WINDOW WIPERS WERE ACTIVATED AND A STRONG BURNING ODOR AND SMOKE EMITTED INSIDE THE CABIN. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT INSPECTED UNDERNEATH THE HOOD AND NOTICED THE WIPER MOTOR WAS COMPLETELY BURNED. THERE WERE NO FLAMES PRESENT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO CONFIRMED THAT THE WIPER MOTOR WOULD NEED TO BE REPLACED. THERE WAS A RECALL FOR NHTSA CAMPAIGN NUMBER: 01V258000 (VISIBILITY); HOWEVER, THE REMEDY CONSISTED OF REPLACING THE WIPER MOTOR GEAR CASE COVER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.

WHILE DRIVING WEST BOUND ON INTERSTATE HIGHWAY 80 EAST OF IMLAY, NV AT APPROXIMATELY 70 MPH IN LANE #2, THE LEFT REAR TIRE LOST ABOUT 80-85% OF IT'S TREAD IN ABOUT 10 SECONDS, EXTENSIVELY DAMAGING THE UNDERSIDE WHEEL WELL AREA NEAR THE TIRE AND THE BODY OF THE VEHICLE. CONTROL OF THE VEHICLE WAS NEVER LOST, ALTHOUGH THERE WAS VEERING FROM SIDE TO SIDE AND VIOLENT LOUD BANGING AS THE TREAD PIECES WERE HITTING THE VEHICLE. THE REMAINING TIRE CARCASS DID NOT LOSE AIR PRESSURE, AND WE MANAGED TO SAFELY COME TO A STOP ON THE RIGHT HIGHWAY SHOULDER. AFTER STOPPING AND DETERMINING THE EXTENT OF DAMAGE TO THE VEHICLE AND THAT THE TIRE WAS NOT FLAT, WE SLOWLY DROVE ABOUT ONE MILE TO THE NEXT EXIT, LEFT THE HIGHWAY AND CHANGED THE TIRE. THE 4 TIRES HAD ALL BEEN PROPERLY INFLATED AND HAD ABOUT 11,045 MILES ON THEM SINCE ALL FOUR WERE PURCHASED IN 2012. THE TIRES ARE B F GOODRICH, LT265 / 75R16, "RUGGED TERRAIN T/A". THE VEHICLE IS A 2004 FORD F-250 SUPER CAB 4X4 PICKUP TRUCK.

TL* THE CONTACT OWNS A 2004 FORD F-250 SD. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED AS NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CAC TUBE WAS REPLACED, BUT THE FAILURE PERSISTED. IN 2014, THE VEHICLE WAS TAKEN TO AND INDEPENDENT MECHANIC. THE TECHNICIAN REPLACED THE FUEL PRESSURE REGULATOR, THE FUEL INJECTION CONTROL MODULE, AND ONE GLOW PLUG. THE CONTACT INDICATED THAT THE FAILURES CONTINUED TO OCCUR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE CONTACT INDICATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 85,000.

WE HAVE BEEN HAVING ON AND OFF PROBLEMS FOR ABOUT A YEAR WITH OUR VEHICLE STALLING WHILE DRIVING. THE VEHICLE WOULD START UP BUT ONLY GO ABOUT 3 BLOCKS AND THEN STALL AGAIN. WE HAVE REPLACED THE FICM. VEHICLE SEEMED OF FOR A FEW MONTHS AND NOW WE ARE HAVING A PROBLEM WITH IT RUNNING ROUGH AT LOW IDLE SPEEDS AND MISSING WHILE DRIVING AND RUNNING ROUGH. WE HAVE BEEN TOLD ITS THE ICP SENSOR AND THERE MAY BE A RECALL ON THESE PART.I CALLED FORD TODAY AND OUR VEHICLE DOESN NOT FALL UNDER THIS RECALL BUT YET WE HAVE HAD THE SAME PROBLEMS WITH THE FICM AMD ICP (RECALL05S34) CAN YOU PLEASE CHECK AND SEE IF ANY OTHER 2004 FORD F250 SUPER DUTIES ARE HAVING ISSUES ALSO THAT FORD IS NOT FIXING????? *TR