2020 FORD F-250 SD Complaints

The contact owns a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and stalled. The check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed; however, the contact was unsure of the diagnostic results. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in an unknown recall. The failure mileage was approximately 80,000.

The transmission shifts hard both up and down. There was a Ford Customer Satisfaction Program 21B03, for which I never received. I contacted Ford and was told that since the program had expired there was nothing they could do. However, this is a known issue that Ford has admitted. This is a safety hazard because the transmission jumps around to various gears. If a vehicle is following and the transmission chooses a gear that is lower than appropriate, the tires will lock until the appropriate speed is reached for that gear.

The contact owns a 2020 Ford F-250. The contact stated while driving at undisclosed speeds, the transmission was shifting hard, and the vehicle was jerking. The failure recurred intermittently while the contact waited for the recall repair. The contact was notified of NHTSA Campaign Number: 22V256000 (Power Train) and the recall was repaired; however, the dealer notified the contact that the valve body in the transmission was failing. The failure recurred after the contact came to a stop, and the vehicle shifted hard from tenth gear to first gear. The maintenance required message was displayed. The vehicle was restarted, and the vehicle was taken to the dealer where the valve body was replaced; however, the vehicle was diagnosed with a clutch pack failure. The vehicle was not repaired. The failure mileage was approximately 105,000.

malfunctioning component is transmission safety has been affected by hesitation in shifting during normal driving, no catastrophic failure yet though vehicle has been inspected by dealership no warning lamps or DTCs issues are ongoing and stated this is "normal" for this transmission (was not an issue the first 65000 miles)

Truck turned off while driving on freeway and would not turn on was told it was battery replaced it did not fix it turn off while pulling trailer took it back to dealer after further search thwy foumd a bulletin and its a fuse box that gets corroded not properly sealed moister gets in and causes problem a safety problem people can wreck you from behined or catch on fire for electrical short in fuse box.

The contact owned a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the vehicle entered LIMP Mode, and inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the CP4 fuel pump and informed the contact that there was rust on the fuel pump because of water damage, even though the water sensor failed to detect the presence of water within the fuel system. The vehicle was repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 89,000.

The transmission went out at 115000 miles. There is metal all in the pan and damaged the valve body. After valve body replaced the transmission still would not go into gear correctly and its an internal failure known to occur in the 10-speed 2020 10r140. This needs to be a recall.

Delayed shifting are not shifting at all they reset the transmission numerous times but still having the same issue. It’s all part of the adaptive learning transmission system that Ford has.

The contact's fiancé owns a 2020 Ford F-250. The contact stated while the driver was driving 70 MPH, the vehicle shut off inadvertently. The contact's fiancé was able to pull to the side of the road. The battery warning light was illuminated. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed that the Bosch CP4 high pressure fuel injector pump had failed and there were metal shavings in the fuel filter, which caused the vehicle to stall. The vehicle was being repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.

Component: Battery Junction box then affecting other parts. water intrusion into battery junction box affecting and shorting out other components. Items shorted out due to water in battery junction box include: Battery Junction Box itself, Left rear Blind Spot Monitor, Left rear Brake Light, Drivers seat control (shorted all seat heated components, All lumbar and massaging components fully inflated and would not deflate) , Windshield wiper motor shorted and stopped working, Rain sensor stopped working. Both Tow Mirrors would Randomly deploy to the furthest out position. Main Safety Concerns were Windshield Wiper Motor Stopped Working and Seat Randomly adjusting, Inflating, Deflating. Vehicle is currently at for dealership ( Sam Packs 5 star Ford Lewisville TX) who has diagnosed the issues. The only warning lamp was for the Driver Side BLIS when the incident would occur.