2003 FORD F-250 SD Complaints

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THE STEERING WHEEL WAS LOOSE WHILE DRIVING. THE FAILURE MADE IT VERY DIFFICULT TO CONTROL THE VEHICLE, ESPECIALLY WHEN MAKING A LEFT OR RIGHT TURN. THE DEALER ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY THE PITMAN ARM. THE DEALER ALSO STATED THERE WAS A TECHNICAL SERVICE BULLETIN (16515) FOR THE PITMAN ARM AND THERE WAS NO RECALL. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 87,000.

VEHICLE HAS 7.3 LITER DIESEL ENGINE AND THE FORD 4R100 AUTOMATIC TRANSMISSION AND 4 WHEEL DRIVE. TRANSMISSION FAILED AT ABOUT 88,000 MILES DESPITE PROPER SERVICING SINCE NEW. IT WOULD INTERMITTENTLY STOP SHIFTING IN NORMAL USE AND BEGAN TO SLIP BADLY. ONLY SECOND GEAR WAS STILL WORKING WHEN I GOT IT TO THE DEALER THE NEXT DAY. THE TRANSMISSION WAS REPLACED AT MY EXPENSE ($3500+). THE REPLACEMENT TRANSMISSION FAILED IN A SIMILAR WAY AT ABOUT 135,000 MILES DESPITE BEING SERVICED AS REQUIRED BY THE DEALER. THEY ARE UNABLE TO OBTAIN A VALVE BODY FOR THIS TROUBLESOME ASSEMBLY AND IT HAS BEEN AT THE DEALER FOR NEARLY TWO WEEKS. THIS MODEL OF TRANSMISSION IS DEFECTIVE AND DANGEROUS ESPECIALLY IF YOU ARE TOWING AND LOSE ENGINE BRAKING DUE TO THE TRANSMISSION FAILING. FORD NO LONGER USES THIS TRANSMISSION AS IT HAS A HIGH FAILURE RATE. THE BODY HAS RUSTED THROUGH AT ONE OF THE CAB CORNERS AND OVER BOTH REAR WHEEL WELLS. FORD REPAIRED THE RUST THROUGH ONCE UNDER WARRANTY BUT THE RUST THROUGHS CONTINUE AND HAVE A NEGATIVE EFFECT ON THE INTEGRITY OF THE VEHICLE STRUCTURE AND PROTECTION OF IT'S OCCUPANTS IN THE EVENT OF A CRASH. A RUSTED BODY WOULD NOT PROTECT OCCUPANTS AS WELL AS AN AN UNRUSTED ONE. *KB

TL* THE CONTACT OWNS A 2003 FORD F250 SD WITH BIG O BIG FOOT HT TIRES, SIZE LT265/75R16, DOT NUMBER: UPW8T264005. THE CONTACT WAS DRIVING 65 MPH WHEN THE VEHICLE STARTED SHAKING ABNORMALLY. THE DEALER ADVISED THAT THREE OF THE TIRES EXHIBITED TREAD SEPARATION AND NEEDED TO BE REPLACED. THE TIRES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE OF THE TIRE WAS 948. THE VEHICLE FAILURE MILEAGE WAS 50,988. UPDATED 10/04/11*BF

TRUCK BEGAN BLOWING FUSE #45, RESULTING IN A LOSS OF INSTRUMENTS AND NO THROTTLE ACTIVATION AVAILABLE. SEEMS TO OCCUR MOST OFTEN WHEN TURNING LEFT, AND/OR WHEN SHIFTING FROM PARK OR REVERSE INTO DRIVE, OR DRIVE INTO REVERSE OR PARK. HAS RESULTED IN A LOSS OF POWER IN ALL OF THE ABOVE SITUATIONS, WITH THE ENGINE ONLY IDLING. IF THIS OCCURS WHILE HEADING UPHILL, VEHICLE WILL NOT MOVE. INTERNET SEARCH REVEALS THIS SEEMS TO BE A FAIRLY COMMON PROBLEM, AND IS DUE TO INSULATION BEING RUBBED OFF PART OF THE WIRING HARNESS THAT RUNS THROUGH THE STEERING COLUMN. SAME RESEARCH INDICATES FORD CHANGED THE ROUTING OF THE WIRING HARNESS IN LATE 2003. I BELIEVE THIS SITUATION SHOULD BE REPAIRED FREE OF CHARGE BY FORD. *TR

TL* THE CONTACT OWNS A 2003 FORD F-250 SUPERDUTY. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 108,000.

TL* THE CONTACT OWNS A 2003 FORD F-250. THE CONTACT STATED THAT WHILE CLOSING THE CAMPER SHELL, THE SHELL SLAMMED DOWN AND SHATTERED THE REAR WINDOW. THE CONTACT ALSO SUSTAINED A CUT ON THE HAND DURING THE FAILURE. THE CONTACT WAS UNCLEAR AS TO WHY THE CAMPER SHELL SLAMMED DOWN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERE NO ASSISTANCE. THE CONTACT EXPRESSED CONCERNS OVER THE CAMPER SHELL BEING UNSAFE. THE FAILURE MILEAGE WAS 30,000.

2003 FORD F250 SUPER DUTY 4 DOOR 4X4 WITH 6.0 TURBO DIESEL WE HAVE HAD PROBLEMS WITH THE INJECTION SYSTEM CONSISTING OF OUR HAVING TO REPLACE SOME INJECTORS, GLOW PLUGS, AND FINALLY NOW THE FICM (FUEL INJECTION CONTROL MODULE) AND THE #8 FUEL INJECTOR . THE VEHICLE RUNS SLUGGISH, HESITANT, MISS FIRING, SEVERE VIBRATION. WE HAD A DIAGNOSTIC TEST DONE AND RECEIVED AN ESTIMATE FOR $1878.00 TO FIX THE ISSUE. I HAVE SEEN A LOT OF TALK ON THE INTERNET ABOUT THIS ISSUE HAVINGA RECALL BUT WHEN I CONTACTED MY DEALER THEY SAID THERE WERE NO CURRENT OPEN RECALLS FOR THIS VEHICLE. PLEASE INVESTIGATE. *TR

TL*THE CONTACT OWNS A 2003 FORD F250 SUPERDUTY. WHILE ATTEMPTING TO DECELERATE WITH THE BRAKES ENGAGED, THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. HE WAS ABLE TO SHIFT THE VEHICLE INTO NEUTRAL WHEN HE NOTICED THAT THE ENGINE MADE A ROARING NOISE. HE TURNED THE VEHICLE OFF, RESTARTED IT AND IT PERFORMED NORMALLY. THE CONTACT DID NOT INFORM THE DEALER OR MANUFACTURER NOR WAS THE FAILURE DIAGNOSED OR THE VEHICLE REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.

TL* THE CONTACT OWNS A 2003 FORD F250 SUPER DUTY. THE CONTACT STATED WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER ADVISED THAT THE RIGHT REAR SPARK PLUG HAD BLOWN OUT OF THE ENGINE, CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 77,000.

MY SPARK PLUG WAS EJECTED OUT OF THE CYLINDER HEAD WHILE DRIVING. THE THREADS WERE RIPPED OUT AND DAMAGED THE COIL PACK ATTACHED TO THE SPARK PLUG. MY VEHICLE IS A 2003 FORD F-250, V-8 5.4 LITER TRITON ENGINE. *TR