2020 FORD F-250 SD Complaints

The contact owns a 2020 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that the check engine warning light was intermittently illuminated. The contact stated that while driving at various speeds, the vehicle unintendedly decelerated and lost power. The vehicle was coasted to the side of the road, turned off, restarted, and the vehicle regained power and drove as intended. The message "Power Reduced” was displayed. The failure occurred approximately every 5 miles driven. The vehicle was taken to the dealer and was diagnosed with low fuel pressure, and it was determined that the fuel pump had failed and needed to be replaced. The vehicle had not been repaired because parts were not available. The manufacturer was not made aware of the issue. The failure mileage was approximately 95,000.

Good Morning, Ms. Edds My name is [XXX] . I spoke to you a few years back in regards, to a vehicle I had. Well, today I am writing about another situation . I have a 2020 Ford F250 vin [XXX] . Since purchasing this vehicle, I have had recall after recall on it and getting nowhere with Ford Motor Company Customer Service Division. I have a local dealership that I have taken it to Spalding Ford who does not take the time to look at the vehicle when I tell them there is an issue and what it is doing all they do is make 1 excuse after another and then about a week or so goes by and I get a recall letter about the issue I just complained about. The last time it was at this dealership they cracked my windshield and said they get back with me about getting it fixed so far nothing and I have called a number of times and now being told they had no idea about it. It has been several months but guess that is going to have to fall on me because no one wants to take accountability of their own actions. I have 3 outstanding recalls in which I complained about before the recall came into effect. I contacted a dealership located in the next county over who willingly sent a tech to my house for a recall when the tech got here he was unable to fix the recall do to the Ford Motor Company Customer Service Division running errors in their system and was unable to do the update. I have also complained about having steering issues and was told no there is nothing wrong but then all of a sudden, I received a recall letter. I am an average John Doe trying to take care of my [XXX] grandson and my [XXX} husband this is supposed to be my dependable vehicle for us I cannot just go out and trade it in and lose all the money I have placed into it already I don't have the funds or means to do that. I called and talked with the recall department and the gentleman i spoke with was really concerned and tansfered me to someone who didnt want to fix it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The fuel tank is leaking fuel from the top where hose connects, it is cracked where the hose barb is connected to the tank

I was driving down the FM 112 in Lexington TX. The rear glass exploded. The center glass was not damaged just the glass on both sides

My cp4 fuel pump failed on my 2020 ford f250 and died while towing my 7000lb trailer for my business and had to get towed to shop to find out the entire fuel system needs replaced and ford dealer has it and says because recall 24s78 for my vehicle is on pause that there is nothing they can do about it and I’m stuck without my truck which I need for my business and believe ford is responsible to replace the fuel system with no charge to me when the cp4 pump is such a common failure in my trucks!

NHTSA Complaint Text (Copy/Paste) Vehicle: 2020 Ford F-250 Super Duty 6.7L Power Stroke Recall: 24S78 – Powertrain Control Module (PCM) Software Update Complaint: Ford has issued Recall 24S78 for the high-pressure fuel pump defect on my 2020 F-250, but the company has not provided an actual remedy. The recall shows as open on my VIN, and Ford’s documentation says a PCM software update is the fix, but Ford released the software and then pulled it back within a week. My dealership confirmed Ford removed the remedy from their system, so they cannot perform the recall at all. This leaves my truck exposed to a known safety defect with no available repair. The high-pressure fuel pump failure this recall addresses can cause sudden loss of power, engine stall, or complete shutdown while driving. Until a working remedy is released, I’m driving a truck that Ford has admitted has a serious safety defect, but they have not provided any fix or timeline. I am requesting NHTSA investigate why the remedy was withdrawn, why no replacement remedy has been provided, and why Ford is leaving owners with a known safety risk for an extended period. This is an expensive vehicle, and the defect can cause catastrophic engine damage and create a hazardous situation on the road. Owners deserve an effective recall remedy that is actually available. Not exactly sure when the recall was first brought to light but I do know it has been months now.

The contact owns a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine and loss of power warning lights were illuminated. In addition, the vehicle sputtered. The vehicle was driven to the shoulder of the road. The vehicle was then towed to an independent mechanic, where it was diagnosed with fuel systems failure. The contact was informed that the fuel system needed to be replaced. In addition, the contact was informed that a complete fuel system and maintenance needed to be performed to fix the vehicle. The vehicle was repaired. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part was not yet available. The dealer was made aware of the failure. The contact was informed that the recall was not associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,050.

While driving cross country, my dash warning light came on and said " In 50 miles your vehicle will lose power and you won't be able to drive more than 5 mph. DEF problem". I spent $70,000 on this vehicle used with 50K miles on it. Recall from 2024, this is unacceptable. Now another recall for steering. The steering column disengagement. I am afraid to drive it. The dealer keeps telling me no fix yet. FORD has no email to complain. I am not sure what can be done. This is my first FORD, never again.

Transmission had multiple internal failures with c,d,f clutch and intermediate clutch transmission pumping failing. Truck has 85,167 miles

Bosch high pressure fuel pump failure at 76K miles. Resulted in being stranded out of state. Dealer could not repair the fuel pump after having the vehicle for over 1 month. Dealer stated fuel pump under warranty. Dealer claimed contaminated fuel was the cause but could not prove it. Warranty denied.