2022 FORD F-250 SD Complaints

The contact owns a 2022 Ford F-250. The contact’s spouse stated that while attempting to reverse, the back-over prevention system became inoperable. The spouse reported that the rearview camera image was blank, and none of the rear sensors provided any notification or warning, resulting in the vehicle reversing into a tree. The contact received notifications of NHTSA Campaign Number 25V455000 (Fuel System, Gasoline) and 25V686000 (Back Over Prevention); however, the parts to complete the recall repairs were not yet available. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 49,700.

The failed component is a lifter/camshaft. Luckily I was attentive to my vehicle and noticed a ticking noise within the engine and took it to a dealer for diagnosis. An engine failure while traveling at highway speeds could be a disastrous to occupants and others around them. This appears to be a common problem with the 7.3l engine. The check engine light illuminated after i noticed the ticking noise.

Intermittent delay in throttle response. Sometimes the delay is nonexistent or nearly imperceptible, other times the delay can be 2 seconds or more. Is very dangerous when trying to merge with flowing traffic. Occurs most often with the steering wheels turned and accelerating from stop, but has happened while driving straight at freeway speeds. Turning off traction control seems to mitigate but not entirely eliminate the issue.

The contact owns a 2022 Ford F-250. The contact stated that while depressing the accelerator pedal, the vehicle hesitated and then lunged forward. The contact stated there was no warning light illuminated. The contact stated that the failure had occurred while driving at various speeds. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the vehicle was functioning normally. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact reported that in December 2024, the engine had failed and needed to be replaced. The contact recently received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) and related the failure to the recall. The failure mileage was approximately 30,000.

Roof trim on passenger side broke and blew off while driving. Vehicles behind could be overreacting and cause accident. I contacted Ford and they were not concerened or take a report.

The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.

The contact owns a 2022 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving approximately 55-60 MPH and hauling a Fifth Wheel Trailer, the low-pressure fuel pump suddenly failed and the vehicle lost power, causing the vehicle to stall. The contact activated the hazard lights and waited for a tow truck that was in the far-left lane on the freeway. The check engine warning light illuminated immediately when the vehicle lost power. The vehicle was towed to the dealer, who determined that the vehicle had experienced the failure listed in NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) but could not yet be repaired because parts to do the recall repair were not yet available. The dealer referred the contact to the NHTSA Hotline to report the failure. The manufacturer was informed of the failure and opened a case. The failure mileage was 21,646.

I just picked up my Ford F-250 (2022) from Allstar Ford in Prairieville, La. It will have been 3 weeks since I had my truck towed to this dealer! On Tuesday [XXX] my truck stalled in heavy traffic and was able to glide off [XXX] in Baton Rouge and same to a dead stop at the end intersection. I blocked traffic for 30 minutes until truck started and was able to get out of traffic! My Ford pass App text a message to me that my fuel pump module had failed. Dealer could not diagnose a failure and after 3 weeks I finally went and picked it up. They did offer to replace the fuel pump for $1700.00 as my 100,000 warranty could not be applied because dealer diagnostics could not recognize the fault??? Truck has 72,000 mile on it!! So now I am driving around in a vehicle that could stall at any time, without any notice. Now what do I do?? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

Bumps in the road caused steering wheel to shake violently (Death Wobble) until truck was stopped in the middle of a 4-lane expressway. Truck is now at the dealer for inspection of frontend steering components. If there was heavier traffic, there would have been an accident. no warning signs present, only bumps in the road which the truck was not able to dampen or control.

Death Wobble. Steering wheel shook violently twice in one 25 mile trip. Once at 73 MPH and once at 65 MPH. Almost caused a crash due to being on a curve in the road when it occurred.