2003 FORD F-250 SD Complaints

I UNDERSTAND THAT THERE IS A TECHNICAL SERVICE BULLETIN ON THE 2003 FORD F 250 2W/4W DRIVE V-10 MOTOR. WAS THIS MOTOR [V10-6.8L VIN S] RECALLED ? WAS FORD TO REPAIR / OR REPLACE THESE DEFECTIVE MOTORS? THE VIN # ON THE TRUCK IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DURING THE PERIOD OF JUNE THROUGH JULY 2010 3 OF THE SET OF 4 KUMHO ROAD VENTURE 285/75R16 8 PLY TIRES HAD TREAD SEPARATIONS. THE MILEAGE SPAN WAS LESS THAN 300 MILES. THE TIRES HAD 28,000 MILES ON THEM. THY WERE MANUFACTURED 2006 DOT CODES H2HA YC4A. 2 OF THE TREAD SEPARATIONS HAPPENED WHILE DRIVING ON THE INTERSTATE. THE FIRST BLEW OUT WITHIN 100 YARDS OF FEELING THE BOUNCE OF THE TREAD SEPARATING. THIS TIRE DAMAGED THE REAR FENDER OF THE 2003 F 250 FORD PICK UP. THE LAST 2 TREAD SEPARATIONS HAPPENED WITHIN 100 MILES OF EACH OTHER. *TR

FORD 2003 F250 SPARK PLUG EJECTED CYLINDER #7 TRITON 5.4L OCCURRED TWICE. FIRST REPAIR (HELI-COIL INSERT) FAILED. *TR

2003 FORD F-250 SUPER DUTY. CONSUMER STATES VEHICLE CAUSED AN ACCIDENT WHEN THE BRAKE PEDAL WENT TO THE FLOOR WHILE APPROACHING STOPPED CARS *TGW THE CONSUMER STATED THE VEHICLE WAS ORDERED WITH ABS AND A DUAL MASTER CYLINDER, SO IF THE FRONT OR REAR BRAKES FAILED, HE WOULD AT LEAST HAVE TWO WHEEL BRAKES TO STOP AND LOCK UP COMPLETELY. AFTER THE TRUCK WAS PICKED UP AND TAKEN TO A GARAGE, THE TOW TRUCK DRIVER FOUND PARTS LYING ON HIS TRUCK BED. THEY WERE FROM A SWITCH ON THE END OF THE MASTER CYLINDER. THE HOUSING FOR THE SWITCH ROTTED AWAY ALLOWING THE SWITCH TO FALL APART. WITHOUT THE SWITCH BLOCKING THE HOLE IN THE END OF THE MASTER CYLINDER, THERE WERE NO BRAKES. THE CONSUMER BELIEVED THERE WAS A FLAW IN THE SYSTEM, BECAUSE IT SHOULD HAVE AT LEAST ALLOWED HIM TO HAVE TWO WHEEL BRAKES. THE CONSUMER STATED WITH ALL THE SAFETY BUILT INTO THE BRAKE SYSTEM, HOW DID ONE SWITCH WIPE OUT THE ENTIRE BRAKE SYSTEM WHEN IT FAILED. *JB

WHILE DRIVING DOWN THE ROAD, A SPARK PLUG BLEW OUT OF THE ENGINE ON MY 2003 V10 TRITON F250 TRUCK. IT HAS 86,000 MI. AND STILL HAS THE FACTORY SPARK PLUGS IN IT AT THE FACTORY TORQUE SETTINGS. THE SPARK PLUG EXPLODED OUT OF THE ENGINE AND COULD HAVE POTENTIALLY CAUGHT THE ENGINE ON FIRE (I READ IN SOME CASES WHERE IT DID CATCH THE ENGINE ON FIRE WITH THE SAME INCIDENT). IT CAUSED SOME INTERNAL DAMAGE WHEN BLOWING OUT OF THE ENGINE, BUT THE PLUG WAS NO WHERE TO BE FOUND. I HAVE NOTICED THAT FORD HAS A PROBLEM, WITH THIS PARTICULAR VEHICLE AND OTHERS, WITH THE SPARK PLUGS EJECTING OUT OF THE HEAD, BUT HAS DONE NOTHING TO FIX THE PROBLEM WITH THEIR ENGINEERING DEFECT. I NOTICED THAT THE HEAD ONLY HAS THREE THREADS HOLDING THE SPARK PLUG IN PLACE AND THAT IS NOT ENOUGH TO HOLD ONE IN PLACE WITH AN ALUMINUM HEAD. THE POTENTIAL SAFETY HAZARD WITH THIS PROBLEM IS HIGH AND VERY SEVERE. I FEEL LIKE I NEED TO REPLACE ALL THREADS AND SPARK PLUGS BEFORE THIS INCIDENT HAPPENS AGAIN AND AGAIN. IF ONE SPARK BLEW OUT THAN IT IS JUST A MATTER OF TIME BEFORE ANOTHER ONE BLOWS OUT POTENTIALLY CATCHING FIRE AND/OR CAUSING INJURY OR DEATH. *TR

I OWN A 2003 F-250 SUPERDUTY EXTENDED CAB TWO WHEEL DRIVE FORD PICK-UP, THE FRONT END WILL SHAKE VIOLENTLY AT AROUND 55 MILES AN HOUR WHEN YOU HIT A BUMP IN THE ROAD OR EVEN MAKING A SLIGHT RIGHT HAND CURVING TURN ON THE HIGHWAY. IT IS SO BAD THAT I HAVE TO PULL OF THE HIGHWAY TO KEEP CONTROL OF THE TRUCK. I REPLACED THE SHOCKS WITH MONROE GAS MAGNUM SHOCKS , NO CHANGE FOR THE BETTER. *TR

THE FRONT END VIBRATES AND OSCILLATES WHEN I HIT A BUMP OR ROUGH ROAD CONDITIONS DRIVING BETWEEN 30 AND 50 MPH. THERE IS MORE SLACK IN THE STEERING, AND I HAVE TO SPEED UP ABOVE 50 MPH OR SLOW DOWN BELOW 30 MPH OR JERK THE WHEEL FROM SIDE TO SIDE IN ORDER TO STOP THE SHAKING. THIS OCCURS EVERY TIME WE DRIVE THE TRUCK. THE TIRES HAVE BEEN CHECKED, AND FROM RESEARCHING, IT APPEARS THAT THERE IS A FAULTY STEERING BOX, BUT FORD REFUSES TO ACKNOWLEDGE THE DEFECT. *TR

MY 2003 FORD F 250 SHOT A SPARK PLUG OUT - MECHANIC LOOKED INSIDE AND SAID ALL THE THREADS HAD BEEN RIPPED OUT AND HAS HAD THIS ISSUE WITH SEVERAL OTHER FORD PICKUPS IN RECENT MONTHS. OBVIOUSLY A PROBLEM AS THIS IS A SMALL TOWN AND NOT THAT MANY FORD PICKUPS AROUND. 2 OPTIONS TO FIX REPLACE THE HEADS OR RETAP. *TR

WE WERE RETURNING HOME AND PULLING OUR RV WHEN THE RIGHT REAR TIRE SHED ALL THE SURFACE COVER BUT DID NOT LOSE IT'S AIR AND ALMOST CAUSED US TO CRASH. THE TIRE IS A UNIROYAL LT 265-75-R16 MADE BY MICHLIN. I NOW HAVE 2500.00 IN TRUCK DAMAGES AND NO RECOURSE. *TR

I WAS DRIVING MY 2003 FORD F-250 WHEN A SPARK PLUG BLEW OUT OF THE CYLINDER HEAD BREAKING THE COIL, AND CAUSING THE TRUCK TO RUN ON 7 CYLINDERS. MY TRUCK HAS ONLY 72340 MILES ON IT AND THOSE ARE THE ORIGINAL SPARK PLUGS FROM THE FACTORY.