2016 FORD F-250 SD Complaints

The contact owns a 2016 Ford F-250. The contact stated while driving approximately 5 MPH and hauling a trailer, the vehicle suddenly lost motive power and stalled. There was no warning light illuminated. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the fuel pump had failed due to metal shavings in the fuel system. The contact was informed that the fuel system kit needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 237,778.

The contact owns a 2016 Ford F-250. The contact stated that while driving at approximately 50 MPH, the check engine light illuminated, and the message “Reduced Power Mode” was displayed. The vehicle was taken to a dealer where it was diagnosed that the fuel pump, manifold assembly, fuel injectors, injector terminal seal, gaskets, vacuum pump, and left side fuel rail pressure pump needed to be replaced. The manufacturer was notified of the failure. The failure mileage was approximately 76,880.

It has been labeled as the death wobble. When driving down the highway at 65-70 mph and I hit a bump, pothole or a washboard effect in the road with the left front wheel. The whole truck will shake violently. So much that I can barely hold on to the steering wheel. The only way to stop the shaking is to slow the truck down to 30-40 mph. In the middle of the highway. I can watch the other vehicles around me scatter and put on their brakes as they try and avoid me. Sometimes it’s to hard to control and I will waver into another lane or on coming traffic. This happens sporadically and without warning. I have taken the truck to the Ford dealership for $3000 in steering component repairs . I have 60,000 miles on it and it is only used for personal use and never abused. This is a design defect that is going to get someone killed. A heavy duty truck should not have the parts wearing out to such a degree that threatens the lives of everyone on the road around me.

The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the steering wheel was shaking uncontrollably. The contact stated that the steering wheel was shaking, and it was difficult to hold onto the steering wheel. The contact decelerated and the vehicle was taken to an independent mechanic. The vehicle was not diagnosed or repaired. The contact stated that the failure had previously occurred, and the vehicle was repaired; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.

Driving out of state and twice in a three hour period have experienced the death wobble on the interstate , now trying to continue under 50 mph because it is a very scary shaking .

After we drove over a bumpy section of road the truck experienced uncontrollable shaking. The road conditions were not severe, but were the cause of the shaking. During the immediate aftermath no input was possible apart from taking my foot off the accelerator. The shaking was severe and uncontrolled causing other vehicles in the vicinity to react. It felt like the truck was going to flip over. This has now happened several times since we purchased the truck. We recently had new brakes installed, but that is not the reason for the shaking.

The contact owns a 2016 Ford F-250. The contact stated that while driving 20 MPH, the vehicle lost motive power and stalled. The check engine warning light was illuminated, with a message stating to check the engine. The vehicle was towed to an independent mechanic where a diagnostic test was performed. The mechanic stated that the high-pressure pump created metal debris that traveled through the fuel system and the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 110,000.

The contact owns a 2016 Ford F-250. The contact received notification of NHTSA Campaign Number: 22V337000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the parts were not yet available. The manufacturer was contacted and referred the contact back to the dealer for assistance. The contact had not experienced a failure. Parts distribution disconnect.

-I was driving 65 mph in morning rush traffic when I drove over an overpass. Near the end of the there are some small wrinkles in the concrete. Once I drove over these wrinkles in the pavement, my steering wheel and front end started violently shaking. I removed my foot from the accelerator and once my speed decreased to I'd say 20-30 mph the shaking stopped. My research show that this if referred to as the Ford Death Wobble. -The system that failed were likely the track bar bushing, damper bracket, ball joints, control arms, shocks, and struts. Yes, the truck is available for inspection upon request. -When the front end of the truck started violently shacking I was going 65 mph in lunch rush hour traffic. I'd say that my life and the life of the drivers of the vehicles to my left, right, and rear were at risk. -No, the problem has not been reproduced or confirmed by a dealer or anyone else. -No, the vehicle or components have not been inspected by anyone. -No, there were not any warning lamps, messages or other symptoms of the problem prior to the failure, nor did any warning appear during or after the shaking. -My best assessment of the cause

Vehicle has 44,000 miles, has never been wrecked in any way. Recently the advance trac system began displaying a fault at random. The light would come and go. At the time the fault light was active the turn signals did not operate normally. A message noted to service advance trac system. ( which is related to the abs) I noticed, once, the abs activate momentarily for no apparent reason. I narrowed the fault down to the steering wheel angle sensor. I had a Ford service center confirm the issue was the steering angle sensor. The sensor was on a backorder. I called around and other dealers confirmed. A week later while entering a cloverleaf and slowing down the system faulted, illuminated the error, and the abs activated. The brake system applied brakes unevenly pulling the vehicle to the left then right and aggressively slowing down without driver brake input. I had to fight to control the vehicle to prevent losing control or get rear ended. The roads were clean, dry, and it was daylight. Upon that i could see the complete loss of steering wheel angle sensor input. The dash can show this readout. Without the steering wheel angle input the system, which is to prevent accidents, nearly caused one. I tried turning off the advance trac via the traction control button, this was ineffective. I had to remove the abs pump fuse to get home safely. This system should not in any way be able to cause this severe loss of vehicle control simply due to the loss of one sensor. This is absolute unsafe software protocall. Attatched are images of the sensor reading then no place holder for it when it does not read.