2015 FORD F-350 SD Complaints

Driving at highway speed going over a bridge and went over a expansion joint an out of no where the entire front end started to violently shake. I had to apply brakes which because it was shaking so bad the abs kicked in and started the wheels to skid. I was sure that the front wheels were coming off the truck. Still continues and ford has the truck now. No Warnings.

We were on our way home from a rodeo with our living quarters attached to our pickup and it did the "death wobble" twice on our way home when we hit the bumps on a bridge...luckily no one was behind us because at the area it started to shake we couldnt get pulled over because there was no shoulder so we had to slow to an extremely slow speed in our lane

1st incident happened in May 2020, traveling down a major highway at about 60 mph, hit a bump in the road and the truck went into what is known as the "death wobble" and I had absolutely no control of the steering. I then had to slow down to under 10 mph while still in the lane of traffic, to get the truck under control. I immediately call a mechanic shop and had the truck inspected. I took it to another shop that does suspension and front end alignments and had it looked at. 2nd incident happened today, Sept 28, 2021. Same thing traveling down a major interstate at approximately 70 mph, hit a bump in the road, and again the truck went into the "death wobble". I had no control over the steering and had to come to a complete stop to get the truck under control. This time I was almost rear-ended by vehicles behind me. This is extremely troubling, scary, and a very serious safety issue. Luckily I was not towing anything when these two incidents happened. If this issue is not addressed and a recall made on these vehicles someone is going to be killed!

We have experienced the “death wobble” 3 times this last weekend during our travels while we were pulling our trailer loaded with horses

Multiple times: Front end violent shake pulling steering wheel from hands and loosing control at 70 mph. Slammed on brakes just before I hit the center concrete barrier on highway. Driving over a manhole cover on road at 30 mph sent front end again into a built shake causing loss of steering and into oncoming traffic till was able to brake and stop vehicle. Drive great till next bump in road. 11 diesel techs cannot figure out what is wrong! This truck is going to kill someone, what is wrong with it???? Replaced tie rods, track bars, ball joints, wheel bearing, steering dampener, shocks, multiple alignments, caster bolts, ... $4800... in parts and labor so far and continues the exact same death wobble trap!

Vehicle wobbles violently above approximately 50mph and when go over slight bump or uneven road surface. Have to slow down rapidly almost to a stop for the violent wobbling to stop. Also wobbles slightly at low speed. This has happened multiple times now. Took it in to the dealer the first time it happened, while it was still under warranty, but the dealer said it was not a big deal and they did not have time to fix it.

At speeds over 50 miles per hour going over bumps the steering wheel shakes violently. Also occurs during hard breaking.

While driving on the freeway, exiting onto the off ramp, the rut in the road caused my whole front end to shake uncontrollably. I could barely keep the vehicle on the road and almost collided with the sound wall adjacent to the off ramp. The severe shaking lasts until my vehicles slows significantly, as in the 15-20 mph range. Which is less than ideal on a major freeway!!!!! This is the fourth time this has happened in the past few weeks. Research on the internet revealed to me that this apparently is a known problem with this particular vehicle model. I finally was wise enough to take it to my local Ford dealership, wherein a mechanic told me that it is a known problem by Ford, which the dealerships cover only when one is brought in with issues. Not shocking to me however, the Ford dealership just told me that the suspension issues was caused by "wear" and it is out of my pocket to repair. It has 35,000 miles on it! Is this indeed a wide spread issue? My wife will no longer drive with me, or allow my kids in the vehicle, because she was in the truck on two of the occasions and she told me she would like to live!!!!!

I was driving about 65 mph and my truck started to vibrate and then the rear tire blew and I was able to pull over and inspect. Upon inspecting half of the tread had separated and came off and damaged my truck bed. This tire is available for inspection. I am very lucky to have been able to control the truck. Myb9 yr old son was in there and worst case scenario we could have hit other cars or rolled the truck and possibly injuries or death could have occurred. I've read other complaints of the samething happening to other drivers. Michelin had recall on tires similar to this one before for tread separation. Is it related somehow? The truck and tire has been inspected by insurance and auto body shop and NTB tire manager. The NTB manager couldn't say what caused it. They have never seen this kind of blowout before. And recommended to keep pursuing something. But Michelin won't do anything except to buy my actions with a 40% off of new tires. I wish somebody would investigate Michelin. There's so many reports out there on these tires separation and sidewall being blown out. It's going to be very unfortunate for somebody to lose their life because of these tires.

I was driving on route 37 at about 65 mph. All of a sudden the truck started vibrating. I pulled over and got out and checked my tires and lugnuts didn't notice anything. Drove some more and it started vibrating again. I was preparing to pull over again but then the rear tire exploded. Tread separated, caused severe damage to my truck bed. I have the tire for inspection. This could have caused a bad accident on the interstate. My son and I was in danger of wrecking the truck. I'm waiting on the insurance to contact me. No warning lights. I feel like Michelin has had several issues with tread separation before. It look like a tractor trailer exploded. Tire size is 275/65 R20 Michelin LTX A/T2