2022 FORD F-350 SD Complaints

I was driving on [XXX] in St Louis County Missouri during rush hours traffic. I experienced a blow out on my drivers front tire. I was surrounded by lots of heavy traffic from passenger cars to tractor trailer going more than 60 mph. I slowly got to the right shoulder. Modot and the state highway patrol blocked the traffic away from us while AAA changed my tire. After I was ready to leave I noticed my traffic early collision warning, and other safety warning systems were not working now. I also noticed my rear view camera was not operating either. This was the first time I noticed any issue with my safety systems. I got. Ew tires and changed them all 6 out. Still my rear view camera is not operating. I did notice Ford was getting ready to put in a recall for rear view camera for F350’s from 2015 to 2025. I do have a 2022 so I feel I am in the recall. Please let me know if I should go to my dealer for repairs under the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving with the cruise set I wanted to reduce speed and hit the minus speed button on the cruise control which caused the vehicle to speed up which made me hit it quickly a couple more times to slow it down and it responded by speeding up more and led me to slam on the brakes. Luckily no one was in front of me so I didn’t rear end them when it sped up and no one was behind me that could have rear ended me when I slammed on the brakes.

The contact owns a 2022 Ford F-350 SD. The contact stated while driving 15 MPH, the vehicle lost motive power and vehicle stalled. The contact stated there was an abnormal sound coming from the engine. An unknown message was displayed on the instrument panel. The vehicle failed to restart and was pulled into a gas station by another driver. The vehicle was then towed to the residence. A mobile mechanic diagnosed that the CP4 pump had failed. The contact was informed that the CP4 pump needed to be replaced. The vehicle had not been repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.

The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Minor issue started during heavy rain last week, went out in morning and power steps would not function. After starting, the rear sliding window opened and would not shut. Researched solution and reset the steps in the computer. Let truck sit for 5 hours at work (not raining) and apparently circuit dried out and window was able to close. Fast forward to Thursday night (4/1), flood rains had started. On the way home from work, the rear sliding window started opening again by itself, but was able to close it with the switch. It did this several times. Went out to start the truck Friday evening and all i got was flickering lights that dimmed when the start button was pushed. No controls worked. By Saturrday morning, there was no lights or any control. all electronics are non-functional. I checked and the batteries are fully charged, so it is not a battery/alternator problem - I expect water has infiltrated into the electronics/computer. Luckily, this short out did not happen on the whole system while I was driving.

The contact owns a 2022 Ford F-350. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the transmission before the vehicle jerked while shifting from park(P) to drive(D). No warning lights were illuminated. The contact stated that while attempting to accelerate, the transmission hesitated to shift briefly before accelerating and then functioned normally. The failure became regular. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was repaired, but the failure reoccurred 3 times. The vehicle was taken to the dealer and remained at the dealer unrepaired. The manufacturer was notified of the failure, and contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.

After the truck had been sitting in the driveway for a couple days I noticed a wet spot underneath the truck, I looked under the truck and noticed there was diesel on the fuel line and the top of the fuel tank was wet with diesel fuel.

The contact owns a 2022 Ford F-350 SD. The contact stated that there was a sulfur odor coming from the front end of the vehicle. After inspecting the vehicle, the contact noticed white smoke coming from the batteries. There were no warning lights illuminated. The contact replaced both batteries. The dealer was informed of the failures and confirmed that the batteries were not covered under warranty. The vehicle had not been taken to the dealer. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,000.

The contact owns a 2022 Ford F-350. The contact stated while the vehicle was parked, the contact became aware that there was fluid leaking from the front axle. The vehicle was taken to the dealer where it was diagnosed and determined that the axle seal and barrier failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 174,739.

The contact owns a 2022 Ford F-350 SD. The contact stated while pulling into the driveway approximately 5-10 MPH, the steering wheel separated and fell into the contact's lap. The vehicle was towed to the dealer, where it was diagnosed and determined that the steering column needed to be replaced; however, the part was on a national backorder. The vehicle was not repaired. The manufacturer was notified of the failure and offered to partially pay for the replacement parts and for a rental. The failure mileage was approximately 60,000.