2001 FORD RANGER Complaints

REAR FRAME ON RANGER IS RUSTING. THE SLOT WHERE THE GAS TANK STRAP HOOKS ON TO THE FRAME HAS RUSTED AWAY THIS CAUSED THE GAS TANK TO DROP THE WHOLE BACK FRAME LOOKS BAD. *TR

TRUCK VEHICLE WAS SHIFTING INTO REVERSE AND A BRAKE FAILURE PROMPT THE DRIVER TO SWITCH INTO DRIVE AND SUDDENLY THE VEHICLE SPUN OFF OUT OF CONTROL(BURNING TIRE) AND IT TOOK OFF VERY FAST WITHOUT EVEN TOUCHING THE GAS PEDAL. DRIVER TRIED TO STOP IT BUT NOTHING WORKED. *KB

DOOR AJAR LIGHT STAYS ON DUE TO FAULTY DOOR LATCHES AND SWITCHES. PREVENTS DOOR FROM CLOSING ALL THE WAY AND ALSO PREVENTS THE INTERIOR LIGHT TO SHUT OFF. DOORS SHUT BUT DON'T LATCH FULLY WHICH CAN CAUSE THE DOOR TO POP OPEN. THIS SHOULD OF BEEN A RECALL A WHILE AGO. WHEN TALKING TO MY MECHANIC AND A FEW OTHER PEOPLE WITH A 99-01 RANGER EXTENDED CAB 4 DOOR THEY HAVE HAD THE SAME PROBLEM. MY MECHANIC SAYS THIS IS A KNOWN FORD PROBLEM. I FEAR THAT SOMEONE IN THE BACK JUMP SEAT WILL BE LEANING UP AGAINST THE DOOR AND IT WILL POP OPEN WHEN GOING DOWN THE ROAD. I AM IN THE PROCESS OF GETTING THIS ISSUE CORRECTED BUT IT IS GOING TO BE A COSTLY FIX THAT I SHOULD NOT BE RESPONSIBLE FOR SINCE THIS IS A FORD RANGER PROBLEM AND I AM NOT THE ONLY ONE HAVING IT!!! *KB

TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT SEVERAL PORTIONS OF THE FRAME, FUEL SYSTEM, AND BRAKE DRUMS WERE RUSTED. BOTH THE REAR AND FRONT ENDS OF THE FRAME WERE SUFFERING FROM SEVERE RUSTING AND THE FUEL FILLER PIPE WAS ALSO RUSTED. IN ADDITION, THE CROSS MEMBER WAS ALSO RUSTED. THE CONTACT ALSO STATED THAT THE RUSTING BEGAN APPROXIMATELY THREE YEARS AGO. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 137,000. UPDATED 12/20/11*LJ UPDATED 01/03/12

RUSTED FRAME ON 01 4X4 RANGER . RUSTED REAR SPRING HANGERS& BRACKETS. RUSTED TAIL END OF LEFT & RIGHT FRAME . RUSTED TOP SECTION OF FUEL FILLER TUBE. RUSTED CROSS MEMBER BEHIND CAB. HAD TO REPLACE REAR BRAKE DRUM THAT RUSTED INTO (2) TWO PIECES. BOTTOM OF TRUCK BOX HAS BAD RUST HOLES. ONE AUTO TRANSMISSION FLUID LINE RUSTED IN 2 INCH AREA JUST BEFORE RADIATOR INLET. LEFT SIDE OF FRAME IS ALMOST RUSTED TO MUCH TO SAFELY USE TK. *TR

NOTICED MY TRUCK WAS SITTING CROOKED. TOOK IT TO REPAIR SHOP TO HAVE REPAIRED. ABOUT 2 HOURS AFTER I DROPPED IT OFF THE REPAIR SHOP CALLED MY PHONE AND ASKED ME TO COME TO THEIR SHOP. THE MECHANIC SHOWED ME THE RUSTED SPRING SHACKLES AND RUSTED SPRING HANGERS AND THE RUSTED FRAME. THIS SHOP WOULD NOT PUT MY TRAILER HITCH BACK ON BECAUSE HE SAID MY RUSTY FRAME WOULD NOT HOLD IT UP. I TOOK MY TRUCK BACK TO A FORD DEALER FOR THEM TO LOOK AT. THEY TOLD ME THAT THE TRUCK WAS PAID FOR, WARRANTY WAS OUT AND AS FAR AS THEY WERE CONCERNED THE PROBLEM WAS MINE. I TRIED TO TELL THE DEALER THAT THIS DIDN,T HAPPEN OVERNIGHT. HE DIDN,T CARE. I HAVE HAD PARTS OF THE FRAME PLATED SO IT WOULDN,T BREAK INTO. GAS TANK BRACKETS HAVE RUSTED OFF. MAIN FRONT CROSSMEMBER HAS RUST HOLES IN IT. THIS TRUCK WAS ONLY 7 YEARS OLD AND ITS JUNK. TRIED TO TRADE IT OFF AT A DEALER FIRST THING THEY LOOK AT IS THE FRAME. THE DEALERS KNOW THERE IS A PROBLEM WITH THE FRAMES RUSTING. AND MINE IS NOT THE ONLY ONE IN THE AREA WITH RUSTED FRAME PROBLEMS. MY SON HAS A 2004 FORD THATS ALMOST AS BAD AS MINE. I HAVE A 1955 FORD TRUCK THAT HAS A BETTER FRAME UNDER IT THAN MY 2001. SAD BUT TRUE. I TOOK EXCELLENT CARE OF MY TRUCK FOR THOSE FIRST 7 YEARS BUT WHO CRAWLS UNDER THEIR CAR OR TRUCK TO CHECK FOR RUST. YOU EXPECT SOME BUT NOT TO THIS EXTENT. *TR

REAR LEAF SPRING HANGERS FAILED & SEPARATED FROM THE FRAME DUE TO CORROSION CAUSING THE LEAF SPRING TO DAMAGE THE BED OF THE TRUCK AS THE LEAF SPRING DROVE THROUGH THE SKIN OF THE TRUCK BED. *TR

I WAS DRIVING 20 MPH WHEN I PRESS THE BRAKE AND THE PEDAL WENT TO THE FLOOR, A FIRE STARTED UNDER THE HOOD, I NOTICED ONE OF THE BRAKE LINES WAS BURNING. PUT FIRE OUT AND TOWED THE PICK UP TO THE SHOP WHERE IT REMAINS. *TR

WHILE DRIVING AT 45 MPH I SLOWED TO MAKE A RIGHT TURN AND ALMOST WENT THROUGH THE INTERSECTION INTO THE WOODS. I THOUGHT THAT THE TRUCK MIGHT ROLL. UPON INSPECTION, MY LEFT FRONT TIRE WAS NEARLY FLAT. WHEN I BROUGHT THE WHEEL/TIRE TO GET IT REPAIRED I WAS TOLD THAT THE WHEEL HAD RUSTED THROUGH AND THE TIRE WAS OKAY. THE FOLKS AT THE WHEEL & TIRE PLACE SHOWED ME HOW THE WHEEL WAS DESIGNED TO TRAP WATER AND WERE VERY FAMILIAR WITH THE PROBLEM. I NOTIFIED FORD, WHO IGNORED THE DESIGN-FLAW ASPECT, AND TOLD ME I WAS OUT OF LUCK SINCE THERE WAS NO SAFETY RECALL. I HOPE THAT CHANGES. *TR

2001 FORD RANGER WITH 86866K. IN AROUND SEPT 2010 I HEARD A THUMP AND BANGING FROM THE BACK. UPON HOME I LOOKED UNDER I SAW THAT THE SHACKLE MOUNT ROTTED AND BROKE ON THE DRIVER SIDE. THE PASSENGER SIDE DID NOT BREAK BUT NOT ANY BETTER THEN THE ONE THAT BROKE. I BOUGHT THE SHACKLE AND THE SHACKLE MOUNTS. AFTER I REMOVED THE SHACKLE MOUNT ON THE PASSENGER SIDE I SAW ROT THROUGH THE FRAME AS WELL HEAVY FLAKING RUST THRO-OUT THE ENTIRE FRAME. I CALLED FORD AND THEY SAID IN A NUT SHELL TOO BAD. *KB