2002 FORD RANGER Complaints

TL* THE CONTACT OWNS A 2002 FORD RANGER. ON SEVERAL OCCASIONS, WHILE MAKING A TURN, THE VEHICLE STALLED. THE CONTACT STATED THAT THE VEHICLE ALSO LOST POWER STEERING FUNCTIONALITY AND BRAKING ABILITY. USING AN OBD DIAGNOSTIC TOOL, THE CONTACT WAS UNABLE TO RETRIEVE A FAULT CODE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO ALLAN VIGIL FORD OF FAYETTEVILLE, INC (LOCATED AT 275 GLYNN ST N, FAYETTEVILLE, GA 30214, (770) 461-1151) WHERE IT WAS DIAGNOSED THAT THE PCM NEEDED TO BE FLASHED. THE VEHICLE WAS SERVICED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.

I BOUGHT MY RANGER NEW, IT CURRENTLY HAS 232,000 MILES. FRAME RUST IS SO BAD IT IS UNSAFE TO DRIVE. REAR SPRING SHACKLE MOUNTS RUSTED AWAY, BED IS RESTING ON SPRINGS. RUST RAINS FROM UNDERNEATH WHEN HOOD IS ALLOWED TO CLOSE. BRAKE LINE MOUNTS ARE NEARLY GONE, AS IS GAS TANK STRAPS. I HAVE NEVER SEEN FRAME ROT THIS BAD, EVEN IN NORTHERN STATES WHERE ROAD SALT IS USED.

TRUCK EXHIBITED A 'CLUNK' NOISE FROM LEFT REAR WHEN TRAVERSING A BUMP IN THE ROAD. I TOOK IT TO THE DEALERSHIP WHERE I BOUGHT IT NEW AND HAVE HAD ALL MAINTENANCE AND REPAIR WORK DONE. SERVICE MANAGER SAID NO REPAIR WAS POSSIBLE'FRAME RUST WAS SO BAD A NEW LEAF SPRING, ETC. COULD NOT BE ATTACHED AND IT WAS UNSAFE TO DRIVE. SEE ATTACHED INVOICE. I HAD THE TRUCK TOWED TO MY HOME AND IT HAS NOT BEEN DRIVEN SINCE. (DATE OF OCCURRENCE IS APPROXIMATE. IT BECAME WORSE AS TIME WENT ON AND OCCURS AT ANY SPEED.)

REAR SPRING HANGERS ROTTED AND FAILED AND BOTH SIDES OF FRAME RUSTED BAD..SPARE TIRE HOLDER RUSTED ROTTED AND BROKE LETTING SPARE TIRE AND REAR BUMPER TO DROP DOWN. I CAUGHT IT BEFORE IT MADE IT TO THE ROAD.WE WERE ON THE ROAD WHEN THE RIGHT HAND SIDE CAME DOWN.LEFT SIDE HAPPENED A YEAR BEFORE THE RIGHT SIDE[ESTIMATE].

FRAME HAS EXTENSIVE ROT RESULTING IN AN UNSTABLE HANDLING FEEL TO THE TRUCK WHILE DRIVING. ALSO THE LEAF SPRING MOUNTS ARE RUSTED THROUGH AND ABOUT TO FALL APART, I FEEL THE TRUCK IS NO LONGER SAFE TO DRIVE.

EXCESSIVE RUST UNDERNEATH. LEAF SPRING HANGERS FAILED AT 11 YEARS/120K MILES. SPARE TIRE WINCH SEPARATED FROM TRUCK AT 14 YEARS/155K MILES. . AN EXHAUST MOUNT HAS RUSTED AWAY LEAVING THE EXHAUST SYSTEM MARGINALLY SUPPORTED - UNCERTAIN OF WHEN THIS HAPPENED. LOGGING THIS COMPLAINT DUE TO THE GAS TANK STRAP FAILURE. ONE GAS TANK STRAP SEPARATED FROM UNDERNEATH THE TRUCK BED APPROXIMATELY ONE MONTH AGO - AGE 14.5 YEARS, ~160K MILES. WITH THE SPARE TIRE, I NOTICED IT HANGING LOW (3 OF 4 FASTENERS HAD PULLED AWAY FROM THEIR MOUNTS), AND WITH LITTLE EFFORT, WAS ABLE TO HAVE IT FALL OFF. HAD THE REMAINING FASTENER FAILED ON THE HIGHWAY, OBVIOUSLY BAD THINGS COULD HAVE HAPPENED. WITH THE GAS TANK STRAP, LUCKILY IT SEPARATED FROM UNDERNEATH THE BED RATHER THAN FROM THE FRAME, AND I COULD HEAR IT RUBBING AGAINST THE DRIVE SHAFT. THE OTHER STRAP WAS ABLE TO CARRY THE ENTIRE WEIGHT UNTIL I WAS ABLE TO SECURE THE GAS TANK.

DOOR AJAR LIGHT STAYS ON AFTER CAR IS STARTED AND INTERIOR LIGHTS STAY ON FOR ABOUT TEN MINUTES AFTER VEHICLE IS STOPPED BEFORE GOING OUT. DOES NOT HAPPEN IF VERY COLD 20 DEGREES F, OR LESS. ALSO DRIVERS DOOR WILL PARTIALLY OPEN OCCASIONALLY WHEN DRIVING TO THE SAFETY CATCH POSITION. DOOR OPENING IS NORMALLY AT LOWER SPEEDS, LESS THAN 30 MPH AND MOSTLY WHEN GOING AROUND TURNS. STARTED ALMOST A YEAR AGO.

MY WIFE AND I WERE DRIVING ON HWY 79FROM PALISTINE TX TO JACKSONVILLE TX THURSDAY 7/11/2016 WHEN WE NOTICED SMOKE COMING OUT FROM UNDER THE TRUCK WE PULLED OVER AND NOTICED FIRE UNDER THE HOOD I TRIED TO POOR WATER ON IT ALL IT DID WAS JUST GET WORSE AND OUR TRUCK ALL MY WORK TOOLS MY LIVELY HOOD BLEW UP.

WAS PULLING INTO FRIENDS DRIVEWAY WHEN I HEARD A CRACKING NOISE WHEN I CHECKED THE LEFT REAR SPRING HANGER PULLED OUT OF THE RUSTED FRAME. I PULLED OFF THE BED OF THE TRUCK AND FOUND SEVERAL AREAS WHICH WERE SEVERELY RUSTED INCLUDING THE SPARE TIRE CARRIER AND THE STRAPS WHICH HOLD UP THE GAS TANK. I AM THE ORIGINAL OWNER OF THE VEHICLE AND HAVE LIVED IN PENNSYLVANIA THE WHOLE TIME.

TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE STATIONARY DURING AN OIL CHANGE, THE VEHICLE'S FRAME BEDDING WAS DISCOVERED TO BE SEVERELY CORRODED. UNDERNEATH THE VEHICLE, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE AND THE FRAME ENCOUNTERED THE BEDDING CAUSING THE FAILURE TO PROGRESS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,546.