2002 FORD RANGER Complaints

Steel rim came apart while adding air to tire causing severe injuries to hands leg and foot only 20 psi in tire pressure when rim blew apart !

The contact owns a 2002 Ford Ranger. The contact stated while driving approximately 40 MPH and attempting to switch lanes, the accelerator pedal was depressed but the vehicle failed to accelerate as needed. The contact received notification of NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The local dealer was not contacted. The vehicle was taken to three separate independent mechanics to be diagnosed. After each diagnostic test, the contact was informed that the rear differential needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 180,000.

Extreme rusting of the entire frame and underside steel components. Attachments are rusting to the point of failure and falling off the vehicle.

The contact owns a 2002 Ford Ranger. The contact stated while driving 30 MPH, the air bag warning light was illuminated. Neither the dealer nor the independent mechanic was not made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA. The failure mileage was approximately 50,000.

2002 FORD RANGER. CONSUMER WRITES IN REGARDS TO FRAME ON RANGER VEHICLE. *LD *JS

WHILE PULLING UP TO A SECURITY GATE WHEN I APPLIED THE BRAKES THE VEHICLE ACCELERATED. AND I RAN INTO THE GATE. I COULD NOT STOP. DON'T KNOW WHY THIS HAPPENED

RECENTLY MY TRUCK UNINTENTIONALLY ACCELERATED AS I WAS BACKING UP IN DRIVEWAY CAUSING AN ACCIDENT. WHEN I PICKED UP TRUCK AFTER COLLISION REPAIR, IT SUDDENLY ACCELERATED ON HIGHWAY CAUSING IT TO FISH-TAIL OUR OF CONTROL AND NEARLY CAUSING ANOTHER ACCIDENT.

THE REAR STRAP THAT HOLDS THE FUEL TANK IS HANGING DOWN. ON CLOSER INSPECTION, THE MOUNT THAT IS CONNECTED/PART OF THE FRAME HAS COMPLETELY CORRODED AND IS NOW MISSING. I ONLY NOTICED THE PROBLEM WHEN THE "CHECK FUEL CAP" AND I STARTED TO TRY AND LOCATE THE PROBLEM.

THE FRAME HAS COMPLETELY RUSTED OUT. THE SPARE TIRE RUSTED OFF WHILE DRIVING. *TR

WE ARE ORIGINAL OWNERS OF A 2002 FORD RANGER XLT NOW WITH 57,000 HIGHWAY MILES, ALWAYS GARAGED/WASHED/MAINTAINED, LITTLE DRIVING IN WINTER (MOSTLY IN SUMMER), ALWAYS FORD MAINTAINED/SERVICED AT SAME DEALERSHIP, BODY/ENGINE/TRANSMISSION IN GREAT SHAPE, WILL LIKELY FAIL INSPECTION THIS SPING BECAUSE FRAME AND FRAME COMPONENTS ARE SEVERELY RUSTED OUT. - SEVERE RUST ON THE ENTIRE FRAME INCLUDING BOTH CROSS MEMBERS (ENGINE AND TRANSMISSION), ARM BOLT POINTS AND CONTROL ARMS. - FRAME ALSO HAS SEVERE RUST DOWN BOTH SIDES TO REAR BUMPER, REAR AXLE AND DIFFERENTAL, LEAF SPRINGS AND ALL MOUNTS. - THE PASSENGER SIDE STEARING KNUCKLE IS DELAMINATING. - ALL BRAKE LINES HAVE FAILED WHILE DRIVING: FIRST THE REAR BRAKES INCLUDING ALL AXLE COUPLINGS AND DRUM COUPLINGS; SECOND THE FRONT BRAKE LINES FAILED AT THE DISK BRAKES AND RUBBER COUPLINGS. ALL BRAKE TUBES HAD TO BE REPLACED FROM THE MASTER CYLINDER TO THE WHEELS. - SERVICE MANAGER IS WORRIED ABOUT FRONT CROSS MEMBER FAILING UNDER THE ENGINE, MIDDLE CROSS MEMBER FAILING UNDER THE TRANSMISSION AND THE GAS TANK BRACKETS/STRAPS. - THE FRAME AND MEMBERS AND MOUNTS MUST BE REPLACED; THE REST OF THE VEHICLE IS MECHANICALLY SOUND. SERVICE MANAGER SAID NO REPAIR WAS POSSIBLE TO FRAME RUST IS SO BAD PICTURES CAN BE PROVIDED AND/OR VEHICAL INSPECTED BY NHTSA IF DESIRED. ALL BRAKE LINES AND COUPLINGS PERFORMED AROUND AUGUST 29, 2019.