2002 FORD RANGER Complaints

THE TRUCK FRAME HAS MULTIPLE SPOTS OF SEVERE RUST THAT CAUSED IT TO SNAP IN 2 MAKING THE TRUCK UNSAFE TO DRIVE. ONE OF THE AREAS IS NEXT TO THE GAS TANK (WHERE IT SNAPPED) AND THE RUST DOES NOT AFFECT ANY OTHER SPOT AROUND THE FRAME IN THIS AREA. I WAS MAKING A WIDE RIGHT HAND TURN ON A HIGHWAY ON RAMP AND IT SNAPPED.

CANT COTROL CAR WANT TO LUNGE FORWARD OR STALL HARD TO DRIVE LIKE THIS I AM TOLD IT IS THE (ETB) ALSO DOOR WILL NOT STOP CHIMING

2002 FORD RANGER, CONSUMER STATED HIS ISSUE DEALS WITH THE CRUISE CONTROL, WHICH WORKED SPORADICALLY. *BF THE CONSUMER STATED WHEN HE PRESSED THE BUTTON FOR THE CRUISE CONTROL, THE GREEN LIGHT WOULD FLASH, BUT IT WOULD NOT ENGAGE. TWO MONTHS AGO, THE BRAKE LIGHTS STOPPED WORKING. *JB..UPDATED 03/16/16 *BF THE CONSUMER STATED THE CRUISE CONTROL WOULD ACTIVATE AND DEACTIVATE ON ITS OWN. IN FEB 2015, ALL THE BRAKE LIGHTS FAILED. HOWEVER, ALL THE BULB WERE STILL GOOD. THE DEALER INFORMED THE CONSUMER THE BRAKE LIGHT SWITCH NEEDED TO BE REPLACED. UPDATED 03/22/16.*JB

ENGINE ERROR CODE P303 DISPLAYED AND ENGINE MISSING ON THAT CYLINDER. FORD TSB 05-26-3 STATES HEAD REPLACEMENT NECESSARY TO CORRECT. THIS APPEARS TO BE A GENERIC ISSUE WITH THE 3.0 LITER VULCAN ENGINES,. CAR WILL NOT PASS EMISSIONS INSPECTION UNTIL THIS IS REPAIRED.

TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE CRUISE CONTROL SWITCH FAILED TO FUNCTION AND THE LIGHT ON THE FUNCTION BUTTON FAILED TO ILLUMINATE. THE VEHICLE WAS TO BE TAKEN TO A DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE HAD NOT PASSED INSPECTION DUE TO RUSTING ON THE AXLE AND THE SUBFRAME ON THE FRONT DRIVER SIDE. THE CONTACT STATED THAT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT FRAME WAS UNABLE TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,000. THE VIN WAS NOT AVAILABLE.

WHILE SLOWLY BACKING UP THE THROTTLE UNEXPECTEDLY WENT TO WIDE OPEN THROWING GRAVEL, DIGGING HOLES AND LEAVING RUBBER BURN PATCHES. I WAS ABLE TO PUT IN NEUTRAL BEFORE HITTING A PARKED CAMPING TRAILER. LATER THE SAME DAY WHILE BACKING OUT OF A PARKING PLACE AT A BANK THE SAME THING OCCURRED BUT MY FOOT WAS ALREADY ON THE BRAKE AND I WAS ABLE TO STOP IT. WHEN I GOT HOME AND WAS PARKING IT HAPPENED AGAIN, IN REVERSE, ALMOST RAMMING THE GARAGE. I HAVE NOT DRIVEN IT SINCE THIS HAPPENED . FORD 2002 RANGER 4X4 AUTOMATIC TRANS.W

2002 FORD RANGER XLT, FAILED INSPECTION BECAUSE OF SEVERE RUST THAT DEVELOPED ON THE FRONT LEFT SUB FRAME, A ARM BOLT POINTS AND CONTROL ARM POINTS. THE EXTENT OF RUST IS SO SEVERE THAT THE MECHANIC DOESN'T BELIEVE THE VEHICLE CAN BE SALVAGED, BECAUSE THERE IS A NOTHING SOLID ENOUGH LEFT TO WELD A PATCH OR REPLACEMENT PIECE TO. THE TRUCK BODY IS IN PERFECT SHAPE NO OTHER RUST EXCEPT THE FRAME. THE DAMAGE WAS ONLY VISIBLE WHEN THE FACTORY FRONT SKID PLATE WAS REMOVED BY THE INSPECTING MECHANIC. THE TRUCKS FACTORY WARRANTY AT THE TIME OF DISCOVERY EXCEEDED THE TEN YEAR TIME LIMIT, BUT WAS STILL UNDER THE MILEAGE PORTION.

I BOUGHT THIS TRUCK FROM A DEALERSHIP IN JAN 2010. TRUCK WAS IN GOOD SHAPE, HAD FRAME CHECK OUT BEFORE I BOUGHT IT AND LOOKED VERY GOOD. TRUCK HAD ONLY 48000 MILES ON IT. IN JAN OF 2015 THE TRUCK BED SAT A LITTLE CROOKED CHECK FRAME AND SEEN A CRACK ON FRAME 3' LONG BY FRONT SHACKLE. AT THAT TIME TRUCK ONLY HAS 94000 MILES ON IT. TOOK BED OFF AND FOUND MORE AREAS THAT WOULD NEED ADRESSING SOON. I TRIED TO KEEP TRUCK UNDER SIDE CLEAN DURING THE WINTER, I GUESS THE STUFF THE STATE USES ON THE ROAD WAS TO MUCH FOR THE TRUCK.

REAR LEAF SHACKLES REPLACED, ROTTED FROM FRAME, LAST AUG 2014 TO PASS INSPECTION. THIS WINTER 2014-2015, THE SPARE TIRE CARRIER FRAME ROTTED AND FELL FROM THE VEHICLE, INCLUDING THE SPARE TIRE. NOW, UPON INSPECTION OF THE BED APPEARING CROOKED, THE DRIVERS SIDE FRAME IN FRONT OF THE DRIVERS SIDE FRONT LEAF SPRING MOUNT IS TOTALLY ROTTED. THIS HAS CAUSED THE GAS TANK MOUNTS TO THE FRAME TO BREAK. IT HAS ALSO CAUSED THE BED TO TWIST AND THE ENTIRE REAR END OF THIS VEHICLE IS NOW ONLY SUPPORTED BY THE PASSENGER SIDE FRAME.