FOREST RIVER Complaints

The contact owns a 2021 Forest River Flagstaff RV. The contact stated that the front driver’s side tire was significantly worn and damaged after driving approximately 200-500 miles. The vehicle was taken to the dealer, where it was diagnosed that a bearing retainer nut had detached and caused the tire damage. The dealer made an unknown adjustment; however, the failure recurred. The vehicle was taken back to the dealer, where it was being diagnosed. The RV was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 6,000.

The contact owns a 2023 Forest River Cedar Creek Trailer. The contact stated that there were electrical failures with the heating and other electrical components in the trailer. The contact stated that a technician inspected the trailer and found exposed wires in the glued-shut control board. The wires were replaced; however, the failure persisted. The vehicle was taken to the dealer where it was diagnosed and determined that the furnace board and control board needed to be replaced twice. The trailer was repaired but the failure persisted. The contact received notification of NHTSA Campaign Number: 24V395000 (Equipment) and believed that the recall repair to reroute the wires was insufficient to fix the trailer because the repair was previously performed. The contact was informed that the trailer should not be used because of the possibility of a fire due to condensation in the control box. The contact stated that a case was opened with Forest River. The manufacturer was notified of the failure. The failure mileage was unknown.

Tire exploded while driving, causing loss of control. Spare tire replaced and also did the same thing. Tires had under 5,000 miles on them, tire pressures checked before trip, and tires have been stored indoors. Many people online are having the same issue with these particular tires.

During my last towing of the RV I found out the RV brakes were not working. Today upon visual inspection I found one hydraulic brake line T junction came apart above the middle axle, and the connection on the driver's side rear wheel outside calibers disconnected. I have taken pictures and it is currently available for inspection but I need to get it repaired soon. My wife and my safety and all other motorists traveling in front of us as the 21,000 pound trailer had no function brakes. It has not yet been confirmed by a dealer or independent service. No one has inspect it. Tow Vehicle brake controller indicated sending a signal to the RV brake system. I noticed some kind of fluid or lubricant on the drivers side rear tire but dismissed it as being excess grease from the bearings.

The contact owns a 2021 Forest River Crusader. The contact stated while seated outside of the RV, the contact became aware that the freshwater tank had detached and was hanging underneath the RV. The RV was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to an unknown recall. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was unknown.

I pulled to the side of the road, with my foot on the brake, i placed the Motorhome in park, and set the emergency brake. When i went to start to turn back on the road, the gear shift lever, would move freely, but not change from park to drive, or any other gear. I limped to my destination by shifting the transmission manually at the transmission linkage lever. Found out that the linkage cable had melted on the exhaust. It was not properly tied up away from the exhaust.

The contact owns a 2004 Forest River Salem RV. The contact received notification of NHTSA Campaign Number: 08E032000 (Equipment); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was an ammonia leak in the cooling system. The trailer was not diagnosed or repaired by an independent mechanic or dealer. The contact attempted to notify the manufacturer of the failure, however; was unable to do so. VIN tool was unable to retrieve recall information.

The pressure coupler that connects the propane line to the pilot light of the refrigerator was not torqued and was not affixed to keep in place and was fingers strength loose letting propane gas leak. Our camper trailer caught fire after parking , the smoke alarms did not go off, we were in the forest , luckily we acted quickly and used the extinguisher to stop the fire from spreading. At the time there was no one in the trailer but could have been different. We are luckily that the fire occurred when all of us were not in the trailer or sleeping. We have called insurance and plan to call the company as well . There is no reason for our lives to have been put at risk.

The contact owns a 2019 Forest River R-Pod Towable. The contact stated that while driving approximately 65 MPH, the driver's side mirror and the fender was slightly tilted upward on the outer edge due to the wheel touching the fender. The contact pulled into the nearest parking lot and became aware that the side marker light self-tapping screws had been shredding the tires. The contact raised the fender and reattached it to continue driving. The contact stated that the failure had occurred on the passenger’s side and temporarily repaired the RV. The contact researched and became aware that the floor was wider than the frame by approximately 6 to 7 inches, causing the wall to place the weight on the fender, causing damage to the tire. The RV had not been taken to the dealer. The manufacturer was not made aware of the failure. The failure mileage was 12,500.

The mounting bracket for the leveling system hydraulic pump dislodged from the frame - the weld broke. The hydralic reservoir tank falls to the pavement and can cause a serious accident and/or fire. I see Jayco issued a recall for the exact same issue (Bulletin #(s): 20V-780 US Units 2021-009 CN Units). Forest River has not. There are other discussions of this problem on the Forest River forums - [XXX] [XXX] There were no warnings of any kind. I am working with the manufacturer but they are saying it is our of warrany. This is a dangerous defect and should be addressed as a major saftey concern. There are 14,000+ miles on the motorhome. 2019 Forest River Sunseeker 3050s. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)