2010 FREIGHTLINER CASCADIA Complaints

ON 06/26/2018 I WAS DRIVING IN CHICAGO ON SOUTH WESTERN AVE IT WAS RAININIG THAT NIGHT I PULLED OVER BECAUSE MY 2012 CASCADIA WAS ASKING FOR A REGEN OF THE DEF SYSTEM .. I PULLED OVER IN A SAFE AREA AND STARTED THE REGEN PROCESS. ABOUT 10 MIN IN TO THE REGEN PROCESS ON THE LOWER DRIVER SIDE DASH AREA HEAVY SMOKE AND THE SMELL OF BURNING WIRE WAS NOTICED A FIRE BROKE OUT AT THE FUSE BOX LOCATED ON THE LOWER DRIVER SIDE IT WAS DETERMINED BY INSURANCE COMPANY THAT THESE 2012 CASCADIAS ARE KNOWN FOR LEAKS IN THE CAB AREA CAUSING THE MOISTURE OR WATER TO LEAK IN AND INTERACT OR MAKE CONTACT WITH FUSE BOX AREA CAUSING A FIRE ...

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. UPON STARTING THE VEHICLE, THE STEERING WHEEL WAS UNABLE TO BE TURNED TO THE LEFT OR RIGHT AND THERE WAS POWER STEERING FLUID ON THE PAVEMENT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION FAILED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED FOUR TIMES FOR THE SAME FAILURE BY THE SAME INDEPENDENT MECHANIC. A FREIGHTLINER DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 1,000,000.

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT THE INTERIOR AND INSTRUMENTAL PANEL LIGHTING FAILED INTERMITTENTLY. THE DEALER DIAGNOSED THAT WATER PENETRATED THROUGH THE WINDSHIELD AND CAUSED THE SAMCAP MODULE TO FAIL. THE MODULE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 4,081.

DPF SYSTEM FRECUENTY REGENERATION ( EVERY DAY AND TAKE 2 HOURS TO CLEAR)AND OIL PUMP PROBLEMS WHEN STOP AT RED LIGHTS ALSO BAD STEER PLOBLEMS BAD KING PINTS

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, ALL THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE THE VEHICLE WAS TURNED OFF AND RESTARTED. THE CONTACT STATED THAT WHEN THE VEHICLE WAS RESTARTED ALL OF THE WARNING LIGHTS WENT AWAY, BUT AFTER DRIVING FOR SEVERAL MINUTES THE WARNING LIGHTS BECAME ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE SIGNAL DETECTION AND ACTIVATION MODULE HAD MALFUNCTIONED DUE TO WATER GETTING INTO CONTACT WITH THE ELECTRICAL COMPONENTS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V127000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 600,000.

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE IN PARK, THE VEHICLE FAILED TO START. IN ADDITION, THE STABILITY CONTROL, CHECK ENGINE, FUEL AND OIL PRESSURE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 600,000.

TL* THE CONTACT OWNS A 2010 FREIGHLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SHOOK VIOLENTLY AND A LOUD NOISE WAS HEARD. THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE TRANSMISSION HAD DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 438,000.

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CL125. THE CONTACT STATED THAT THE DRIVER WAS DRIVING APPROXIMATELY 45 MPH, WHEN THE TRUCK SUDDENLY ROLLED OVER WITHOUT ANY WARNING. THE DRIVER PASSED AWAY DUE TO THE CRASH. THE POLICE WERE NOTIFIED AND A REPORT WAS AVAILABLE. THE TRUCK WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE CONTACT EXAMINED THE TRUCK AND STATED THAT THE RACK AND PINION WAS FRACTURED. THE CONTACT WAS NOT SURE IF THE FRACTURED RACK AND PINION WAS THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND THEY ADVISED THE CONTACT NOT TO TOUCH THE VEHICLE UNTIL AN INVESTIGATOR WAS SENT. THE FAILURE MILEAGE WAS APPROXMATELY 180,000. ...UPDATE 01/20/12 *BF

TL* THE CONTACT OWNS A 2010 FREIGHTLINER CASCADIA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETECTED THAT THE RACK AND PINION STEERING WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS 170,333. UPDATED 11/16/11*LJ THE CONSUMER REFERENCED RECALL # 09V357000. UPDATED 02/27/12

I HAVE BEEN DRIVING A 2010 FREIGHTLINER CASCADIA TRUCK EQUIPPED WITH A SO-CALLED HARD BRAKING DETECTION SYSTEM. I AM ENGINEER MYSELF AND, AFTER A WHOLE YEAR I CAME TO A CLEAR CONCLUSION THAT THE SYSTEM DOESN'T WORK ON ROAD WITH POOR CONDITIONS LIKE BUMPY OR SLIPPERY. THE REAL PROBLEM IS THAT TRUCK DRIVERS TAKE THE BLAME FROM THEIR COMPANY FOR THIS AND IT IS RISKY. TRUCK DRIVING IS BY ITSELF IS VERY STRESSFUL, AND IT BECOME A REAL HAZARD WHEN THEY DON'T WANT TO HIT THE BRAKE BECAUSE OF A HARD BRAKING SYSTEM THAT PUT THEM INTO TROUBLE WITH THEIR BOSS. AS RESULT WE WILL HAVE CRASHES THAT COULD BE AVOIDED. WHAT I HAVE NOTICED IS THAT WHEN YOU TRY TO SLOW DOWN ON BUMPY OR SLIPPERY ROAD THE ABS SYSTEM GETS ACTUATED, THE IT RECORDS A HARD BRAKING EVENT, WHICH IS WRONG. THE SYSTEM NEEDS BETTER JUDGMENT WITH POOR ROAD CONDITIONS. I PERSONALLY THINK THAT IT WILL NEED MORE SENSORS AND A SOFTWARE TO RESOLVE THE ISSUE HERE. IF THE SYSTEM WAS NOT AIMED AT SCARING DRIVERS I THINK IT SHOULD BE CORRECTED BEFORE IT KILLS MANY AMERICANS. I PERSONALLY KNOW SAFE DRIVERS WITH MILLION MILE ACCIDENT FREE WHO REQUESTED TO HAVE THEIR TRUCK SWITCHED FOR THIS PROBLEM AND I AM SURE A SURVEY AMONG DRIVERS WILL CONFIRM MY CONCLUSIONS. THANK YOU. *TR