GEO Complaints

THE PROBLEM WITH THE WINDOW WAS REPORTED YESTERDAY 11/12/1999. I FORGOT TO ADD THAT IT MAY NOT CAUSE SAFETY PROBLEMS NOW BUT MONTHS DOWN THE LINE AND DEPENDING ON THE TEMPERATURES, THE SEEPAGE OF THE SEALANT CAN CAUSE THE SEAL AROUND THE WINDOW TO BE INEFFECTIVE AND ULTIMATELY CAUSE WATER TO ENTER THROUGH THE CABIN AREA. WHEN THAT HAPPENS IT COULD CAUSE SHORTAGE AND RISK TO MAJOR COMPONENTS. THE PROBLEM WITH THE TIRES ARE THAT THEY SHOWED PRE-MATURE UNEVEN WEARING ON THE OUTER TREADS OF ALL TIRES AT APPROXIMATELY 1,500 MILES. THIS WEARING CAN BE HAZARDOUS DURING WET DRIVING CONDITIONS AS THE GRIP OF THE TIRES TO ADHERED TO THE ROAD CAN BE LIMITED. I REPORTED 3 TIRES/FAILURES BECAUSE I HAD TO REPLACE ONE ORIGINAL BECAUSE OF A FLAT THAT WAS UNREPAIRABLE. *AK( DOT NUMBER: 284 TIRE SIZE: P15580R13 )

THE LOCAL DEALER DECLINED TO REPAIR THE SPEEDOMETER. ON RECORD REPORTED "NO PROBLEMS FOUND" OFF THE RECORD THEY TOLD ME NOTHING CAN BE DONE ABOUT IT. I FEEL THAT BY REPORTING INACCURATE SPEEDS BECAUSE THE SPEEDOMETER NEEDLE FLUCTUATES EVEN WHEN GOING AT A CONSTANT (SAME) SPEED, THE DRIVER DOESN'T KNOW THE EXACT SPEED HE/SHE IS GOING. THE PROBLEM WITH THE WINDOW FOR THE REAR HAS BEEN REPAIRED 3 TIMES AND THE SEALANT (URATHANE) CONTINUES TO SEEP OUT BECAUSE OF OUTSIDE TEMPS. THE WINDSHIELD ALSO SHOWS EVIDENCE BUT NOT AS BAD AS THE REAR BACK WINDOW. MORE PROBLEMS ARE PRESENT WITH THE VEHICLE BUT THEY HAVE NOT YET CAUSE ANY SAFETY CONCERNS. *AK

HOOD BLEW COMPLETELY OFF GOING 55 MPH, BREAKING WINDSHIELD, AND DAMAGING TOP OF CAR. *AK

1ST INCIDENT - WIFE EXITED HIGHWAY ONTO RAMP AND WHEN APPLYING BRAKES, VEHICLE SPUN AROUND AND RR WHEEL STRUCK CURB CAUSING $350 IN DAMAGES. AT THIS TIME I THOUGHT IT WAS DRIVER ERROR, BUT A MONTH LATER, THE BRAKE WARNING LIGHT CAME ON. AFTER EXTENSIVE DIAGNOSIS AND REPLACEMENT OF MASTER CYLINDER AND 1 BRAKE CALIPER, IT WAS DETERMINED THAT THE BRAKE PROPORTIONING VALVE WAS FAULTY, SINCE AIR COULD NOT BE BLED FROM THE LF CALIPER. COST OF NEW VALVE FROM DEALER - $250. I THEN RESEARCHED THE INTERNET TO SEE IF OTHERS HAD SIMILAR PROBLEMS AND FOUND AN ARTICLE ON TOYOTA'S SITE (GEO PRIZM'S ARE MADE IN THE SAME PLANT IN FREMONT, CA ALONGSIDE TOYOTA COROLLAS) STATING THAT THE "FACTORY SUPPLYING BRAKE PROPORTIONING VALVES TO TOYOTA'S AUTO PLANTS HAD A MAJOR FIRE ON 2/1/97" THE FIRE AT THIS COMPANY "AISIN" DESTROYED THE MACHINERY THAT FABRICATES PROPORTIONING VALVES. THEY THEN CONTACTED OUTSIDE COMPANIES (BROTHER INDUSTRIES, A SEWING MACHINE MANUFACTURER) TO MAKE THE PROPORTIONING VALVES DESPARATELY NEEDED BY TOYOTA. WHAT A COINCIDENCE THAT MY "AISIN" PROPORTIONING VALVE WAS DEFECTIVE. I HAVE KEPT THE VALVE AND ARTICLE. YOU MAY READ THE ARTICLE AS "HTTP://WWW.TOYOTA.COM/TIMES/MANU/FEATURE/NUMMI.HTML"

BRAKE LIGHTS WENT OUT.CONSUMER TOOK THE VEHICLE TO THE DEALER FOR REPAIRS,AND THE DEALER DIDN'T REPAIR THE VEHICLE. CONSUMER DROVE THE VEHICLE WITHOUT ANY BRAKE LIGHTS. *AK

WE WERE NOT AWARE THAT THIS PROBLEM HAD BEEN SUBJECTED TO RECALL EARLIER AND OUR DEALER REFUSED TO REPAIR THE LATCH OR OFFER TO REPLACE THE WINDSHIELD BROKEN DUE TO THE HOOD FLYING UP AS OF 10/30/1999

WHILE DRIVING WITHOUT VEHICLE COLLISION OCCURRING PASSENGER 'SAIR BAG DEPLOYED CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK

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

DRIVER'S SIDE DOOR IS VERY LOOSE DUE TO MISSING HINGES ON THE DRIVER'S DOOR, ALSO, THERE IS ONE HINGE HOLDING THE DOOR IN PLACE,THE LOWER HINGE, THERE IS A TSB LISTED FOR THE SAME TYPE OF PROBLEM, DEALER REFUSES TO CORRECT PROBLEM. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

APPARENTLY A WIDESPREAD PROBLEM, I LEARNED OF MANY MORE FAILURES OF THE SAME PART FROM BILL'S ISUZU PERFORMANCE PAGE, (WWW.ISUZUPERFORMANCE.COM/ISUPAGE/), AND WAS LINKED FROM THERE TO REQUEST A RECALL. IF THIS IS A LEMON PART, I SHOULD NOT HAVE TO PAY FOR IT TO BE REPLACED, SINCE ITS FAILURE ENDANGERS THE PASSENGERS.