2004 HONDA ELEMENT Complaints

HONDA ELEMENT - DRIVER SEAT STARTED ROCKING 7 MONTHS OLD. UNSAFE. CLEARLY SOME IS LOOSE AND THERE ARE THE COMPLAINT IS OUT THERE AND REAL. THIS IS TRULY UNSAFE AND SHOULD BE EMBRACED ASAP. *JB

215/70 16 WRANGLER HP VERY NOISY LAST 10,000 MILES. SUSPECT SAFETY OF TIRES. *JB

DT*: THE CONTACT STATED A SCREECHING NOISE WAS HEARD FROM THE REAR BRAKES WHILE DEPRESSING THE BRAKE PEDAL AT SPEEDS OF 2 MPH AND ABOVE. THE VEHICLE WAS TAKEN FOR AN INSPECTION DUE TO THE NOISE. THE INSPECTOR DETERMINED THE BRAKE PADS WERE WORN AND THE ROTORS WERE SCORED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER FOR INSPECTION. THE REAR BRAKE PAD AND ROTORS WERE REPLACED. HOWEVER, THE DEALER STATED THE TIRES WERE WORN AROUND THE TREAD ALTHOUGH, NO INCIDENTS OR PROBLEMS WERE REPORTED ABOUT THE TIRES PREVIOUSLY. THE MANUFACTURER DETERMINED, THIS WAS NORMAL WEAR AND TEAR ON THE VEHICLE AND THE TIRES NEEDED TO BE REPLACED AS A PART OF REGULAR MAINTENANCE. THE REAR ABS ROTOR WAS BADLY WORN. THE CONSUMER REPLACED THE TIRE BECAUSE IT WAS LOOSING AIR DUE TO A SCREW. UPDATED 03/09/06

HONDA NEEDS TO ADMIT FAULT ON THEIR WINDSHIELDS AND RECALL THEIR ELEMENTS. MY WINDSHIELD CRACKED AND DEALER WILL NOT MAKE GOOD ON THEIR DEFECTS. *JB

BOUGHT A NEW 2004 HONDA ELEMENT IN MAY 2004 AND HAVE HAD TO REPLACE WINDSHIELD DUE TO CRACK ONCE PLUS REPAIRED TWO STONE CHIPS. PAID FOR THE REPLACEMENT WINDSHIELD OUT OF OWN POCKET AS DEALER WOULD NOT REPLACE AFTER EXAMINING WITH PEN. ONCE AGAIN RECEIVED ANOTHER CRACKED WINDSHIELD YESTERDAY AFTER BEING HIT BY A ROCK ON THE HIGHWAY ON THE WAY HOME. *JB

I HAVE A 2004 HONDA ELEMENT, I HAD TO REPLACE THE WINDSHIELD WITHIN THE FIRST 6 MONTHS OF OWNERSHIP...FORTUNATELY THE DEALER CONSIDERED IT A "STRESS CRACK" & REPLACED THE WINDSHIELD AT NO COST TO ME. WITHIN A FEW MONTHS, I NOTICED ANOTHER CRACK, I HAVE CHOSEN NOT TO REPAIR IT AS IT WAS IN A NON-CRITICAL AREA. IT HAS NOW BEEN ABOUT 1 YEAR & THERE ARE NOW 3 CRACKS IN THE "NEW" WINDSHIELD...CLEARLY THIS IS A DESIGN FLAW. I HAVE OWNED SEVERAL OTHER VEHICLES & HAVE NEVER HAD TO REPLACE WINDSHIELDS LIKE THIS?. *JB

HONDA ELEMENT WINDSHIELD CRACKED SPONTANEOUSLY WITHIN A FEW MONTHS OF PURCHASE FROM THE BOTTOM EDGE OF THE WINDSHIELD UP. CAME OUT ONE MORNING AND THERE WAS THE CRACK. NO ROCK IMPACT AS THE DEALER ALLEGED! THEY JAMMED A SHARP PEN INTO THE CRACK, AND SAID, LOOK, THIS WAS CAUSED BY A ROCK, & REFUSED TO REPAIR IT. CRIMINAL, IF YOU ASK ME! MANY OTHER ELEMENT OWNERS HAVE REPORTED THIS SAME PROBLEM TO ME. ALSO, THE WINDSHIELD WAS PRONE TO ATTRACTING ROCK & PEBBLE OFF THE ROADS, A SEPARATE ISSUE FROM THAT COMMON CRACKING PROBLEM. IT'S A DANGEROUS FLAW THAT HONDA NEEDS TO ADDRESS AND REPAIR. A RECALL IS IN ORDER!*AK

I WAS DRIVING SOUTH ON HIGHWAY 395 IN CALIFRONIA COMING BACK FROM MAMMOTH MOUNTAIN IN MY 04 HONDA ELEMENT WHEN I HEARD A LOUD CRACK FROM MY WINDSHIELD AND DISCOVERED AN L SHAPE CRACK FROM THE PASSENGER SIDE, THERE WAS NOT A CAR IN FRONT OF ME. AFTER I GOT HOME THE CRACK GREW 4 INCHES UPWARD. WENT TO TWO DIFFERENT DEALERS BOTH TOLD ME IT IS CAUSE BY A ROCK HIT. I CALLED HONDA CUSTOMER SERVICE, THEY WILL NOT REPAIR IT UNDER WARRANTY SINCE IT WAS CAUSE BY A ROCK, I DID A SEARCH ON GOOGLE, THIS SEEM TO BE A COMMON PROBLEM FOR HONDA ELEMENT. I FINALLY HAVE THE WINDSHIELD REPLACE, OLD WINDSHIELD WAS DESTROYED BY THE REPAIR SHOP. *JB

I OWN A 2004 HONDA ELEMENT EX. IN APPROXIMATELY DECEMBER 2004, THE WINDSHIELD SUFFERED THREE LINEAR CRACKS WITHIN A TWO WEEK PERIOD OF TIME. I DID NOT OBSERVE OR HEAR ANY ROAD DEBRIS STRUCK THE WINDSHIELD OR CAUSE THESE CRACKS. ONE CRACK EMANATED FROM THE LOWER CORNER ON THE PASSENGER SIDE, ONE FROM APPROXIMATELY MID-POINT ON A-PILLAR ON THE PASSENGER SIDE, AND ONE FROM THE LOWER DRIVER'S SIDE CORNER. A SERVICE MANAGER REVIEWED THE CRACKS AND DETERMINED THAT TWO OF THE CRACKS WERE CAUSED BY ROAD DEBRIS BECAUSE OF A MINUTE PIT IN EACH OF THE TWO CRACKS. HE DID NOT OBSERVE A PIT IN THE THIRD CRACK AND REPLACED THE WINDSHIELD UNDER WARRANTY. IN APPROXIMATELY DECEMBER 2005 THE WINDSHIELD SUFFERED FOUR CRACKS WITHIN A THREE WEEK PERIOD OF TIME. THE CRACKS OCCURRED AT SEPARATE TIMES AND AT DIFFERENT LOCATIONS. THREE OF THE FOUR CRACKS WERE STARBURST CRACKS AND HAVE NOT SPREAD. ONE OF THE STARBURST CRACKS OCCURRED ON THE DRIVER'S SIDE AND I OBSERVED WHAT APPEARED TO BE SMALL STONE CAUSE THE CRACK. I HEARD THE SUBSEQUENT TWO STARBURST CRACKS OCCUR ON THE PASSENGER SIDE. THE FOURTH CRACK IS A LINEAR CRACK EMANATING FROM THE UPPER CORNER ON THE DRIVER'S SIDE. IT INCREASES IN SIZE BY APPROXIMATELY 1/4 INCH OVERNIGHT, AS IT IS LONGER EACH MORNING WHEN I GET IN THE CAR. THE CRACK HAS TRAVELED INTO THE DRIVER'S LINE OF VISION. THERE IS A HONDA TSB FOR 2003 HONDA ELEMENTS NOTING POSSIBLE STRESS FRACTURES IN THE WINDSHIELD DUE TO MANUFACTURING DEFECT. I AM NOT AWARE OF A SIMILAR NOTICE FOR 2004 MODEL YEAR, NOR AM I AWARE OF ANY RECALL NOTICE FOR ANY MODEL YEAR. I AM CONCERNED THAT THERE A DEFECT IN THE MOUNTING SURFACE OF THE WINDSHIELD THAT MAY RESULT IN SUCH STRESS FRACTURES. I AM ALSO CONCERNED THAT QUALITY OF GLASS USED FOR THE WINDSHIELD NOT SUFFICIENT FOR ROAD USE. THE INHERENT RISK CAUSED BY THIS APPARENT DEFECT WARRANTS INVESTIGATION AND/OR REMEDY. *JB

CRACKED WINDSHIELD ON LOWER PASSENGER SIDE OF VEHICLE. NOT CAUSED BY FLYING DEBRIS. ACCORDING TO OTHER HONDA ELEMENT OWNERS ONLINE, THIS IS A COMMON OCCURRENCE AND IS HAPPENING IN THE SAME GENERAL LOCATION ON WINDSHIELD. A STRESS FRACTURE SEEMS TO BE THE COMMON CONCLUSION AS TO THE CAUSE. *JB