2004 HONDA ELEMENT Complaints

On 722 2024 dealer try to replace a defective seatbelt buckle could not do the repair could not get a replacement from Honda SRS light stays on so that if the vehicle is in an accident, the airbags will not deploy. Have been waiting on this partfor a very long time. Have no information from Honda when this will be available.

my control arm mount and frame of my element is rusted out, it is an ongoing problem with the honda element as i am seeing a lot of people online with similar issues. if this fails, it could put people at risk, i also see other elements on the road with a camber'd out back tire on the driver side. i believe these wheels would fall into the car causing an accident. there are no warning lights that pop on, this is hard to get a look at until you get under the vehicle. they have done recalls on this exact problem in canada already, we need it here as well in the usa. the crv has also had the same issues and was given a recall in usa. i am very concerned with the amount of these cars on the road that many do not know the danger they are in.

Just like the same era's Honda CR-V (the Honda Element's sibling car with many of the same components), the undercarriage rust on my vehicle is excessive: as described in the same era Honda CR-V's NHTSA Recall (23V-228). Large sections of my car’s rear frame are completely missing, and as shown in the photographs even the rear bumper fell off because of all of the rust. Just like with the CR-V, a recall for the rear frame corrosion first occurred in Canada and then in the US: see NHTSA Recall 23V-228’s chronology. The Honda Element's Canadian recall is as follows: "Transport Canada Recall - 2021024 – HONDA". As of today, there is no NHTSA recall for rear frame corrosion for Honda Elements. I am submitting this complaint for this car now, and also contemporaneously am submitting complaints under different VINs for my other Elements with rust problems: every Honda Element that I have ever owned, even one that had spent its entire 14 year life as a New Mexico, Arizona, and Texas car has had rust problems. In other words, no matter what environment these Elements (which were made for the model years 2003-2011) are in, they corrode right away (within any factory warranties), and eventually become dangerous.

The contact owns a 2004 Honda Element. The contact stated that the vehicle was repaired under an unknown recall related to the seat belts; however, the seat belt retractor was repaired incorrectly and was installed backward. The local dealer was not contacted due to new ownership. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 166,000.

The trailer arm rusted at the mount. I was told it was not safe to drive. I have learned that this is a common problem with this vehicle and Honda has issued a recall in Canada, but not the USA. I also learned that there is a similar issue with I believe the Honda CRV and that has been in recall from Honda in I believe both Canada and the US. I found a place to do the repair and he said he has seen a lot worse than mine and has done many of these repairs.. The total repair cost is $1500. I also learned that due to its design water gets trapped in the mount and causes the rust, which sounds definitely like a design flaw. The repair entails fabrication a whole new mount for the trailer arm. I discovered it on June 7th when I was doing some under body clean up.

The rear left trailing arm mounting point is completely corroded through, making the car unsafe to drive. If it were to fall off during driving the chances of it creating an accident are high. There are many other Elements with this specific spot rusting through.

? The area of the body that serves as the forward mounting point for the rear driver-side trailing arm has completely rusted though. At this mounting point, the trailing arm mounting bracket has become entirely separated from the body leaving only one bolt securing the trailing arm to the body. This is the same issue for which these vehicles have been recalled in Canada. Yes, the vehicle is available for inspection upon request. ? Continuing to operate the vehicle in this condition presents the possibility of catastrophic failure of the trailing arm mount, resulting in loss of control of the vehicle, endangering the lives of those in and outside of the vehicle. ? No, I have not taken the vehicle to a dealer or service center. ? No the vehicle/component has not been inspected by the manufacturer, police, or insurance representative. ? No warning lamps, messages, or other symptoms prior to the appearance of the problem on [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I'm am told the component that failed is the "lower control arm." The vehicle is available for inspection. At the onset of this problem was a loss of control of my steering. At first I felt a play in the steering wheel when I made a small adjustment in my turn and felt the car move more than what it would normally do. I thought it was the waves in the road due to frost heaves. Then within about 3/4s of a mile the left "lower control arm" separated from where it was being held and fell to the ground. I heard a dragging noise in the back left area of my vehicle and was fortunate to be in front of a parking lot and was able to immediately pull in out of traffic. The car was towed to our auto repair shop where I was told it was unfixable. I also called the Honda dealership and explained the issue, and was confirmed that the car is unfixable, and was told that presently the part causing this issue is being recalled in Canada, but not yet in the USA. I wanted you to know that this happened here in the USA as well. I did not receive any warnings that there was an issue until it happened.

There is a corrosion recall on 2003-2014 Honda elements in Canada because, from salted roads, the frame rusts and extremely important safety parts can break and cause death to the driver. Seeing as these elements are made in the same factories and are in the same region (mine is in Detroit Michigan, only 10 minutes from Canada) this recall NEEDS to be extended to the USA or at least the regions where salted roads and snow are prevalent. My Honda element suffers from this exact problem but I can do nothing about it.

Drivers side rear control arm mount is almost none distant from rust. The subframe is almost gone and there is tons of rust on the drivers side frame as well. I have seen this with a lot of people laments. Canada even had a recall on this exact problem.