2004 HONDA ELEMENT Complaints

The contact owns a 2004 Honda Element. The contact stated that while driving at an undisclosed speed, the vehicle experienced intermittent vibrations. The vehicle was taken to an independent mechanic, who diagnosed a failure with the rear control arm mounting joint. The contact was informed that the joint was almost completely rusted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 182,000.

The fuel filler neck has rusted through. If pumping gas into the vehicle, gasoline runs onto the ground by the rear tire. The rear trailing arm of the suspension has significant rust. I am concerned this suspension part could fail and become unattached to the vehicle frame/body. The Canadian transportation board has ordered a recall to repairs these issues. from Transport Canada: Toronto, Ontario — Honda is recalling all 2003-2011 Element SUVs, warning of rusting rear frames that could result in the complete separation of the rear trailing arm.

the left rear trailing arm separated from the body causing the wheel to turn outward and stop moving.

The rear driver’s side trailing arm, which connects to the frame and body of the car, is rusted out to the point where it can no longer be driven safely. If the arm detaches from the body, it will cause an extremely dangerous situation which can even result in death. I can no longer drive this vehicle, even though the engine and transmission are strong. There is no repair for this without spending thousands of dollars to cut and repair the rusted area. This is an extremely common issue with the Honda Elements in areas that get snow. It needs to be addressed because it may cause serious harm to those are are not as familiar with the underside of their vehicle.

While driving down a city street, heard a very loud crack/bang, and lost control of the vehicle. Fortunately I was going slow, 20-30mph and was able to safely stop. Upon exiting the vehicle, the rear driver side wheel was hanging at a weird angle. Looking under the car, the entire trailing arm and wheel assembly has broken off of the frame. If I was going faster, or had been on the highway, this would have caused an accident/rollover and injury for sure. Looking online for more information, I see that this is a known issue, and Honda has already issued a recall, but only for Canada. Vehicle was towed to and inspected by a AAA certified auto shop; they have written it off as a total loss, and suggest to sell the vehicle for parts. I contacted Honda, and they have told me to take it to a dealership for additional inspection by them.

The contact owns a 2004 Honda Element. The contact stated while driving 45 MPH, the rear trailing arm detached from the vehicle. The vehicle was not drivable. The contact towed the vehicle to her residence. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 201,000. The VIN was not available.

My air conditioner went out and I was going to put car in reverse to see if the fans were working. When I put the key in I didn't start the car because my key wouldn't go forward or backwards it was just stuck and the steering column locked up. When I first purchased the vehicle in October 2022 I had to have to front end suspension joints replaced the bar in the middle was cracked. It sounded and felt like the motor was going to fall out. I need to replace the back suspension due to very loud noises when driving like something is going to fall apart.

I drive a 2004 Honda Element and on Friday 2/3/23 I was in a car accident where I t-boned a car going 25 mph and my airbags did NOT deploy.

The contact owns a 2004 Honda Element. The contact stated that after the vehicle was shifted into park(P), the vehicle would roll forward or roll backward. Additionally, the key would remain stuck in the ignition, causing the contact to have to maneuver the key to release the key from the ignition switch. The failure occurred intermittently; however, the key was still stuck in the ignition. The contact took the vehicle to the dealer who confirmed that the VIN was not included in a recall. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 167,000.

Excessive corrosion rear suspension near control arm. Honda has already issued a recall in Canada. I was unaware of this problem until a big piece of rusty metal fell off the bottom of my car when I closed the rear driver’s door. My control arm is ready to fall out which could have led to a fatal accident. There are Honda forums all over the internet with thousands of posts in the USA with the same issue as the Canada recall.