2004 HONDA PILOT Complaints

DRIVERS REAR STRUT METAL FATIGUE FAILURE AT KNUCKLE CAUSED SHOCK ABSORBER TO DROP AND SLICE WHEEL.

WENT TO GO TRADE MY CAR IN AND I WAS TOLD THAT THE CAR-FAX IS SHOWING A POTENTIAL ODOMETER ROLLBACK INDICATED, I HAVE MADE A FEW CALLS AND I AM NOT GETTING ANY HELP. I AM VERY CONCERNED AND WOULD LIKE SOME HELP WITH THIS PLEASE THANK YOU.

WHEN GETTING WORK DONE BY LICENSED MECHANIC, I WAS TOLD THAT THERE WAS A PROBLEM WITH THE REAR FRAME BEING SOO RUSTED THAT THE SHOCK ABSORBER WAS NOT ATTACHED BECAUSE THERE WAS NOTHING LEFT TO ATTACH IT TO. I WAS TOLD THEY COULDN'T FIX IT AND I SHOULD CONSIDER GETTING RID OF IT. *TR

IGNITION LOCK-CYLINDER/ASSEMBLY WAS DEFECTIVE AND A RECALL WAS ISSUED WHICH THE DEALER DID NOT HONOR. IGNITION KEY COULD NOT BE EXTRACTED. THE VEHICLE WAS PARK IN DRIVEWAY AND TURNED OFF TO OPEN GATE. THE KEY COULD NOT TURN NOR BE EXTRACTED. *TR

PASSENGER SIDE AIRBAG DEPLOYED WHILE VEHICLE IN OPERATION. MY HUSBAND WAS DRIVING ON THE FREEWAY, 65 MPH, NO IMPACT, NOTHING HIT OUR CAR, NO REASON. I WAS SITTING IN PASSENGER SEAT. THE AIRBAG BLEW, SOME BURNING AND BRUISING TO MY ARM, EAR IS RINGING. NO REASON FOR THE AIRBAG TO DEPLOY! VERY DANGEROUS. CALLED HONDA, CAR [XXX]. WE'VE HAD OUR FRONT AIRBAGS RECALLED. DO THE SIDES HAVE PROBLEMS TOO? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2004 HONDA PILOT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED TO THE CENTER MEDIAN. THE VEHICLE WAS TURNED OFF. THE CONTACT STATED THAT BLACK SMOKE WAS EMERGING FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THERE WAS AN ODOR OF BURNING OIL PRESENT. THE VEHICLE WAS RE-STARTED BUT LACKED FORWARD MOMENTUM. THE VEHICLE WAS DRIVEN HOME. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC. THE CONTACT ALSO MENTIONED THAT THE ENGINE WAS REPLACED BY AN INDEPENDENT MECHANIC PREVIOUSLY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,300.

TL* THE CONTACT OWNS A 2004 HONDA PILOT. THE CONTACT STATED THAT WHILE DRIVING 45MPH THE VEHICLE MADE A GRINDING SOUND AND THE RPM'S FELL WITHOUT WARNING. THE CONTACT HAD NOT TAKEN THE VEHICLE TO A DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. UPON INVESTIGATION THE CONTACT HAD ASSOCIATED RECALL NHTSA CAMPAIGN NUMBER: 04V176000(POWER TRAIN) WITH THE VEHICLE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 203,300.

2004 HONDA PILOT DRIVER SIDE REAR SUBFRAME CROSSMEMBER RUSTED AND FALLING APART. STARTED TO RUST AROUND 2010 THEN WORST AT 2019. ONLY THE DRIVER SIDE IS RUSTED AND BAD. THE PASSENGER SIDE HAS NO ISSUES.

WENT TO GET A OIL CHANGE FOR MY CAR AT AN AUTO REPAIR SHOP AND THE TECH SHOWED ME THE RUST ON THE SUB FRAME, ESPECIALLY AROUND THE REAR MOUNT. THE RUST WENT THROUGH THE FRAME AND THERE IS A BIG HOLE AROUND THE DRIVER SIDE REAR MOUNT. I WAS TOLD THIS HAPPENED TO SOME OTHER HONDA PILOT.

WHILE ON THE 605N FREEWAY CLOSE TO THE 10 FREEWAYSPLIT OUR ENTIRE SUNROOF WHICH THE GLASS AND COVER DITACHED FROM OUR VEHICLE AND FLEW OFF. LUCKILY THE CAR BEHIND WAS NOT HIT FROM WHAT I SEE IN THE RECORDING BUT WE CAN'T SEE IF IT FLEW ON THE OTHER SIDE OF THE FREEWAY. MY CHILDREN WERE SEATING IN THE MIDDLE ROW AND SMALL DEBRI HIT THEIR FACE. WE PULLED OVER TO THE EMERGENCY SIDE OF THE FREEWAY TO CHECK DAMAGE. ALL THAT'S LEFT FROM THE SUNROOF IS THE GLUE.