2005 HONDA PILOT Complaints

THIS HAS HAPPENED SEVERAL TIMES TO MY WIFE AND DAUGHTER OVER THE PAST MONTH OR SO. THEY ARE DRIVING ALONG AT ANY RATE OF SPEED AND ALL OF A SUDDEN THE CAR LOOSES ALL POWER AND THE VEHICLE ABRUPTLY SLOWS DOWN AND THEN RECOVERS AND BEGINS RUNNING AGAIN. DURING THIS TIME THE LIGHTS ON THE DASHBOARD GO OUT AND FLASH AND THERE IS A POPPING SOUND AT TIMES. THE LAST TIME IT HAPPENED THERE WAS LOSS OF ALL ELECTRICAL TO DASH BOARD SYSTEM INCLUDING THE RADIO. THE RADIO NEEDED THE CODE REENTERED WHICH IS NORMAL FOR WHEN ALL BATTERY POWER IS LOST TO THE VEHICLE. I HAD THIS CHECKED BY A MECHANIC AND THEY WERE UNABLE TO LOCATE ANY PROBLEMS. THEY CHECKED THE ALTERNATOR, BATTERY, CONNECTIONS AND THE SYSTEM FOR ANY ERRORS AND NOTHING CAN BE FOUND. THIS IS CONSISTENT WITH ALL OTHER COMPLAINTS ASSOCIATED WITH THE ESA, VSA/VSC AND ELECTRICAL SYSTEMS AS REPORTED ON THIS FORUM. I BELIEVE THERE IS A MAJOR AND DANGEROUS BUG IN THE SYSTEM CAUSING THE CAR TO LOOSE POWER AND CONTROL AND ANY RATE OF SPEED. I ALSO INFORMED HONDA CUSTOMER SERVICE BUT THEY SAID THAT THEY ARE UNAWARE OF ANY PROBLEMS (OR I SHOULD SAY OWNING UP TO ANY OF THIER PROBLEMS) AND TO ISSUE A COMPLAINT THROUGH THIS FORUM. I'M AFAID IT'S GOING TO TAKE A MAJOR ACCIDENT AND A LOSS OF LIFE, WHICH IS BOUND TO HAPPEN BASED ON THE FACT THAT THE CAR COMES TO AN ABRUPT HALT, IN ORDER FOR HONDA TO OWN UP TO THIER RESPONSIBILITY OF SPENDING THE EFFORT TO IDENTIFY THIS PROBLEM AND ISSUE A RECALL AND GET THIS FIXED. I'VE BEEN A HONDA OWNER (CURRENTLY 3 CARS) FOR OVER 23 YEARS. I'M BEGINNING TO LOOSE LOYALTY AND FAITH IN THE COMPANY AND WILL DEFINATELY STRONGLY CONSIDER MAKING A CHANGE TO ANOTHER MAKE ON MY NEXT PURCHASE. PLEASE HONDA OWN UP TO THE PROBLEM BEFORE SOMEONE IS KILLED! *JS

TL* THE CONTACT OWNS A 2005 HONDA PILOT. WHILE DRIVING APPROXIMATELY 20 MPH, THE ENGINE POWER REDUCED SIGNIFICANTLY AND WITHOUT WARNING. THE CONTACT CONTINUED TO DRIVE AND UPON REACHING THE DESTINATION AN INSPECTION UNDERNEATH THE HOOD WAS PERFORMED. THE CONTACT NOTICED A DARK BROWN MILKY SUBSTANCE LEAKING FROM THE RADIATOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED THE CONTACT THAT THE TRANSMISSION AND ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

TRANSMISSION COOLING PORTION OF RADIATOR FAILED CAUSING TRANSMISSION FLUID TO LEAK INTO THE RADIATOR AND MIX WITH COOLANT. TRANSMISSION DRAINED AND CAUSED CAR TO STOP. INTRODUCTION OF ANTIFREEZE INTO THE TRANSMISSION CAUSED DAMAGE TO THE TRANSMISSION RESULTING IN NEED TO REPLACE TRANSMISSION. *TR

WHILE DRIVING IN A RESIDENTIAL AREA, MY 2005 HONDA PILOT SLIPPED OUT OF GEAR MULTIPLE TIMES AND FINALLY WOULD NOT DRIVE AT ALL. I PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND SHIFTED IT INTO PARK. I WAITED A FEW MINUTES AND TRIED TO SHIFT BACK INTO DRIVE. THE VEHICLE SHIFTED INTO DRIVE, BUT WAS UNABLE TO DRIVE MORE THAN APPROXIMATELY 15 MPH. I DROVE THE VEHICLE IN THIS MANNER FOR APPROXIMATE HALF A MILE TO MY DESTINATION. FROM THERE I HAD THE HONDA PILOT TOWED TO AN REPAIR FACILITY. THE MECHANIC INSPECTED THE 2005 HONDA PILOT AND INFORMED ME THAT THE VEHICLE'S RADIATOR HAD FAILED INTERNALLY. THIS ALLOWED THE ENGINE COOLANT AND TRANSMISSION FLUID TO MIX. SUBSEQUENTLY THE COOLANT WAS CIRCULATED THROUGH THE TRANSMISSION AND HAD CAUSED DAMAGE TO IT. THIS IS WHAT HAD CAUSED THE VEHICLE TO SLIP OUT OF GEAR AND ULTIMATELY RENDER IT UNABLE DRIVE. *TR

TL* THE CONTACT OWNS A 2005 HONDA PILOT. THE CONTACT STATED THAT THE LOW BEAM HEADLIGHTS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY ADVISED HER THAT THE HEADLIGHT SWITCH MELTED INTO TWO PIECES AND CAUSED THE FAILURE. THE LOW BEAM SWITCH WAS REPAIRED THREE TIMES PRIOR. THE MANUFACTURER WAS NOTIFIED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.

I HAD TO REPLACE MY RADIATOR AT 37228 MILEAGE AND 85031 ON 2005 HONDA PILOT. THE RADIATORS ARE FAILING AT THE TRANSMISSION FITTINGS ATTACHED TO THE BOTTOM OF THE RADIATORS. THERE ARE SEVERAL THOUSAND COMPLAINTS ABOUT THIS ISSUE AND HONDA IS DENYING THERE IS A PROBLEM. THE PROBLEM IS THE TRANSMISSION COOLER IS BUILT INTO THE BOTTOM OF THE RADIATOR. THE COOLER SITS IN THE BOTTOM OF THE RADIATOR. THERE ARE TWO TRANSMISSION FITTINGS ON THE OUT SIDE OF THE RADIATOR THAT ATTACH TO THE TRANSMISSION. THIS BRINGS TRANSMISSION FLUID IN THE RADIATOR COOLER, COOLS THE FLUID AND RETURNS IT TO THE TRANSMISSION. NOW INSIDE THE BOTTOM RADIATOR SITS THE TRANSMISSION COOLER WHICH IS JUST A SMALL PIPE WITCH IS ATTACHED TO THE TRANSMISSION FITTINGS. WHEN THE FLUID ENTERS THE RADIATOR COOLER IT GETS INSTANTLY COOLED AND RETURNED TO TRANSMISSION BECAUSE THE COOLER IS SUBMERGED IN RADIATOR FLUID. THIS IS BECAUSE THE BOTTOM OF THE RADIATOR IS THE COOLEST AT THE BOTTOM. WHAT'S HAPPENING IS THE TRANSMISSION FITTINGS ARE RUSTING AWAY AND FAILING ALLOWING RADIATOR FLUID TO ENTER THE RETURN LINE TO THE TRANSMISSION. WHEN RADIATOR FLUID ENTERS THE TRANSMISSION THE TRANSMISSION IS DONE. YOU NEED A REPLACEMENT. THESE PROBLEM IS HAPPENING TO SEVERAL HONDAS AND NISSAN. THE TWO CAR COMPANY'S USE THE SAME MANUFACTURING FOR THE RADIATOR. THE COMPANY IS DENSE. THE FAILING ON HONDAS AND NISSAN. IF YOU LOOK INTO THIS MATTER YOU WILL SEE HOW MANY PEOPLE ARE AFFECTED BY THIS. I REPLACED TWO RADIATORS FOR THIS TRUCK SO FAR. PLEASE LOOK INTO THIS PROBLEM FOR $1400 SO FAR. THERE IS A DEFECT WITH THIS RADIATOR AND HONDA REFUSE TO DO ANYTHING ABOUT IT. PEOPLE ARE SPENDING THOUSANDS OF DOLLARS FOR SOMETHING THAT COULD BE FIXED BY HONDA AND NISSAN. PLEASE ISSUE A RECALL WITH THIS ISSUE. THANK YOU *TR

AIRBAG FRONT IMPACT SENSORS FAILED ON 2005 HONDA PILOT EX. THERE WAS A RECALL FOR THIS SAME ISSUE ON THE 2005 HONDA ODYSSEY. THERE SHOULD BE A RECALL FOR THIS ISSUE. HOW DOES A FRONT AIRBAG SENSOR GO BAD. THIS SHOULD HAVE BEEN HANDLED BY HONDA. A RECALL SHOULD BE ISSUED FOR THIS REASON. I KNOW SEVERAL PEOPLE WITH DIFFERENT MODEL HONDAS THAT ARE HAVING THE SAME ISSUE AND ARE BEING CHARGED HUNDREDS OF DOLLARS. THERE IS ALSO A TRANSMISSION PROBLEM WITH THE PILOT RADIATORS THAT I WILL FILL OUT ANOTHER COMPLAINT FOR. THANK YOU. *TR

TL* THE CONTACT OWNS A 2005 HONDA PILOT. THE CONTACTED WAS DRIVING 30 MPH WHEN THE VEHICLE STARTED SHAKING AS THE GEARS WERE SHIFTED INTO A HIGHER GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO A LOCAL MECHANIC WHO INSPECTED THE VEHICLE AND ADVISED THAT THE TORQUE CONVERTER WAS DEFECTIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO ADVISED THE CONTACT TO TAKE THE VEHICLE TOA SECOND DEALER FOR FURTHER INSPECTION. THE VEHICLE HAD NOT YET BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 122,000.

MY WIFE CALLED ME ONE MORNING ON HER WAY TO THE SHOP. SHE WAS FRANTIC SAYING "MY STEERING WHEEL IS SMOKING. I DON'T KNOW WHAT TO DO. I'M JUST ABOUT A MINUTE FROM THE SHOP. SHOULD I PULL OVER OR JUST TRY TO MAKE IT TO THE SHOP?" I TOLD HER, IF IT'S NOT TOO BAD AND SHE IS THAT CLOSE JUST KEEP COMING UNLESS IT GETS WORSE. WHEN SHE MADE IT TO THE SHOP, I PULLED OFF THE PLASTIC COVER AROUND THE STEERING COLUMN. AND FOUND THE YELLOW WIRE GOING TO THE HEADLAMP SWITCH BURNT. THE MOLEX PLUG AND HEADLAMP SWITCH WERE ALSO MELTED. I CALLED LOCAL HONDA DEALER AND ASKED THEM IF THEIR WAS A RECALL FOR THIS. THEY SAID NO. ALSO SAYING THIS NEVER HAPPENS. I HAD TO PURCHASE A NEW HEADLAMP SWITCH AND MAKE REPAIRS TO THE WIRING AND PLUG. I OWN AN AUTOMOTIVE SHOP. IF NOT THIS WOULD HAVE BEEN A VERY COSTLY REPAIR..I ALSO HAVE PICTURES OF THE BURNT WIRE AND MOLTEN PLUG AND SWITCH IF NEEDED. ..UPDATED 04/19/12 *BF UPDATED 05/11/12 UPDATED 05/17/2012 *JS

TL* THE CONTACT OWNS A 2005 HONDA PILOT. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH WHEN THE BRAKES ENGAGED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THE CONTACT THAT THE VEHICLE STABILITY ASSIST (VSA) MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. PRIOR TO THE FAILURE, THE BRAKE SWITCH WAS REPLACED. THE MANUFACTURER WAS CONTACTED BUT THEY OFFERED NO ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. THE VIN WAS UNAVAILABLE. *JS