2005 HONDA PILOT Complaints

A stuck ignition lock cylinder on a 2005 Honda Pilot. Hello I purchased this car from the second owner and they had the ignition lock replaced less than 2 years ago. This device has now failed again. Its a poor design by honda and was never fixed or recalled. This has lead countless people to be stranded. With repairs upwords of $500.

Power steering high pressure line leaking on exhaust and almost caused fire Dangerous. Lines need to be recall or replace

The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.

The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.

The rear trailing arm, normally attached to the rear suspension is clearly corroded and came detached when driving under 25 mph up a road. The SAME issue Honda had to do a recall on their 2005 CRV model. Researched Honda Pilots, in our (Midwest) area, EVERY SINGLE 2005 Pilot had the corrosion. Also cause the muffler pipe to detach from the catalytic converter (included in the photos attached).

I was leaning back looking backwards while reversing and the front left seat bracket on the driver’s seat cracked and separated resulting in my seat turning into a rocking chair and my feet coming off of the pedals. It could have ended in an accident.

Airbag is deactivated due to failure of both crash sensors on the vehicle. Replacement parts are on national backorder.

The rear suspension got detached from a collapsed/rusted Frame. Item # 11 Sub-Frame, Rear Suspension Part # 50300-S9V-A01 The suspension is rubbing against the rear tires since the Bolt Flange (14x125 item# 14 part # 90160-S0X-A00) can’t be supported by the rusted/ collapsed Frame affecting the rest of suspension parts item # 12 washer E subframe part# 50354-S3V-A00 and item#13 part# 50456-S3V-A00 Washer F subframe Mounting.

The contact owns a 2005 Honda Pilot. The contact stated that while waiting in line at a gas station, she smelled a burning odor, and there was smoke coming from the steering wheel. The contact was turned off and restarted the vehicle. The contact stated that upon activating the low-beam headlights, the failure reoccurred. The contact stated that upon restarting the vehicle without activating the low-beam headlights, the steering wheel stopped smoking. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 12V136000 (Exterior Lighting). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was approximately 220,000.

The rear subframe attaches to the unibody has rotted and almost fell off the car