2005 HONDA PILOT Complaints

SIMULTANEOUS FAILURE OF LEFT AND RIGHT FRONT WHEEL BEARINGS AT 90K MILES. DAMAGE COULD LEAD TO CATASTROPHIC BEARING FAILURE AND LOSS OF VEHICLE CONTROL. VEHICLE IS IN THE SE UNITED STATES WITH EXCELLENT ROADS AND WEATHER. BILATERAL FAILURE IS NOT BASED ON ANY REGIONAL CONDITIONS OR DRIVING CONDITIONS (NO TOWING/NO TRAILS OR OFFROAD) BUT CAN ONLY BE A RESULT OF FAULTY INITIAL PARTS. ALL WORK DONE BY DEALERSHIP IN PAST. AWAITING RESPONSE FROM HONDA CORPORATE CONCERNING THIS ISSUE-NO RESOLUTION TO DATE. *TR

AFTER REAR ENDING ANOTHER VEHICLE, SIGNIFICANT DAMAGE DONE TO THE FRONT END OF THE HONDA PILOT, AND TO AIR BAGS DEPLOYED. *TR

TL*THE CONTACT OWNS A 2005 HONDA PILOT. WHILE DRIVING 40 MPH, THE VEHICLE SLAMMED INTO BRAKE MODE AND CAME TO A COMPLETE AND SUDDEN STOP. THE FAILURE CONTINUED FOR SEVERAL MINUTES, CAUSING ITEMS TO BE THROWN FROM THE SEAT ONTO THE FLOOR. DURING THE FAILURE, THE VEHICLE STABILITY ASSIST WARNING INDICATOR WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING, WHICH PRODUCED A LOW BATTERY VOLTAGE CODE AND A BRAKE SENSOR CODE. THE DEALER TESTED AND REPLACED THE BATTERY. THEY ALSO NOTIFIED THE MANUFACTURER AND OPENED A CASE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 58,000.

I HAD MY FRONT AND SIDE MOTOR MOUNTS REPLACED TWO WEEKS AGO ON MY 2005 WITH 75,000 MILES. I SUSPECT THEY HAD BEEN TORN FOR 5,000 MILES OR SO. LOTS OF LOW LOAD CLUNKING DURING THROTTLE APPLICATION, AND EVER SO SLIGHT STEERING WHEEL VIBRATION. WHICH I HAD NEVER NOTICED, UNTIL DRIVING IT AFTER THE REPAIR AND NOTICED THAT THE STEERING WHEEL DEAD STILL. BUT IT STILL IS DISAPPOINTING TO SPEND $450 FOR (2) MOTOR MOUNTS ON A 3 YEAR OLD TRUCK. SHOULDN'T HONDA TO DO A RECALL ON THIS? *TR

HAPPENED TO ME 3 TIMES YESTERDAY. ONCE WHILE DRIVING ~40MPH THE VEHICLE CAME TO A SUDDEN STOP, THROWING ITEMS FROM THE SEAT INTO THE FLOOR. THE FIRST INSTANCE WAS BRIEF AND I DROVE ~2 MILES BEFORE IT HAPPENED AGAIN WITH THE VSA INDICATOR LIGHTS (CAUTION AND OFF) CAME. MANUAL STATES VSA CAN RESET BY TURNING CAR OFF AND BACK ON (MUST BE A MICROSOFT SYSTEM). DROVE THE CAR TO WORK. LATER LEFT WORK AND WENT ABOUT 5 MILES BEFORE THE VIOLENT SUDDEN STOP EVENT. FOLKS THIS IS SERIOUS PEOPLE COULD HAVE BEEN KILLED DUE TO THE VIOLENT NATURE OF THE CAR STOPPING. CAR IS AT THE DEALER RIGHT NOW, THEY COULD NOT REPEAT THE EVENT , YET AND CLAIMED THE COMPUTER COULD NOT READ ANY CODES. THEY HAVE A CALL INTO THE FACTORY. REFERENCE THREAD AT WWW.HONDAPILOT.ORG HONDA PILOT .ORG > GENERAL > PROBLEMS > VSA APPLIES FULL BRAKE FOR NO REASON. *TR

FRONT MOTOR MOUNT FAILED AT APPROX. 60K MILES. SERVICE DEPARTMENT HAS NO KNOW CAUSE FOR THE FAILURE, BUT SAYS IT IS LIKELY A MATERIAL DEFECT. *TR

2005 HONDA PILOT EX HAVE APPLIED SUDDEN BRAKE WHICH COMPLETELY STOPPED THE CAR. IT HAPPENED THREE TIME IN THIS WEEK (2/2 - 2/4). THE WEATHER IS COLD AFTER A MINOR SNOW, THE ROAD IS WET OR DRY. BUT EACH TIME THERE WERE SNOW AND SALT RESIDUE ON THE ROAD, WHEN THE CAR ROLL OVER IT, THEN IT HAPPENED. MOVING SPEED WAS BETWEEN 20 - 30 MPH. SINCE IT WAS SLOW SO NOT ACCIDENT OCCURRED, OTHERWISE MIGHT CAUSE AN ACCIDENT FROM BEHIND. *TR

YESTERDAY, MY DAUGHTER'S 2005 HONDA PILOT WITH 71K MILES SINCE NEW, WAS ROLLING ALONG AT 60 MPH ON INTERSTATE 66 WHEN BRAKES ENGAGED BRINGING CAR TO SUDDEN STOP. SEVERAL CARS BEHIND HER HAD TO TAKE DEFENSIVE ACTION TO PREVENT PILING UP. VSA LIGHT AND ABS LIGHTS WERE ON. THIS HAPPENED SEVERAL MORE TIMES TO A POINT WHERE CAR WAS UNDRIVEABLE AND HAD TO BE PULLED TO SIDE OF THE ROAD. CAR WAS TOWED TO HONDA BY AAA. SAME THING HAPPENED IN OCT 2008 (ABOUT FOUR MONTHS AGO) BUT OCCURRED ONLY INTERMITTENTLY AND CAR COULD BE DRIVEN TO DEALERSHIP. DIAGNOSIS FROM DEALER WAS NEED FOR NEW BATTERY. ORIGINAL BATTERY WAS REPLACED AND CAR WORKED FINE UNTIL YESTERDAY. IT APPEARS THAT THE HONDA DIAGNOSTIC SYSTEM AT THE DEALERS CANNOT PROPERLY IDENTIFY THIS PROBLEM ALTHOUGH IT IS SURELY SERIOUS ENOUGH TO WARRANT A RECALL. ACCORDING TO MEMBERS POSTING AT HONDAPILOT.ORG FORUM, THIS HAS HAPPENED TO OTHERS AND WITH THE SAME POTENTIALLY HAZARDOUS RESULTS. MORE TROUBLING IS THE FACT THAT HONDA DEALERS ARE UNABLE TO DIAGNOSE THE PROBLEM WITH CURRENT TECHNOLOGY. SOME HAVE REPLACED TIRE PRESSURE SENSORS, SOME HAVE REPLACED STEERING WHEEL SENSORS AND OTHERS HAVE REPLACED SIDE CRASH SENSORS AND BRAKE SYSTEMS. IN MY CASE, THE DEALER REPLACED THE BATTERY. THE FACT REMAINS, HOWEVER, THAT THE PROBLEM COULD NOT BE THE RESULT OF MALFUNCTIONS OF ALL THESE SYSTEMS AND THE CURRENT DIAGNOSTIC CODES APPARENTLY ARE INSUFFICIENT TO PINPOINT THE EXACT COMPONENT THAT FAILED. THIS LEVEL OF UNCERTAINTY ONLY COMPOUNDS THE ORIGINAL PROBLEM AND INCREASES THE LIKELIHOOD OF A MULTI-CAR PILEUP WHEN THE VSA SYSTEM ENGAGES FOR NO GOOD REASON. *TR

I HAD MY 2005 HONDA PILOT IN THE SHOP FOR 60,000 MILE CHECK-UP. I WAS TOLD THAT THE MOTOR MOUNTS ON THE RIGHT FRONT AND THE REAR LEFT. I THINK THIS IS ENTIRELY TOO FEW MILES FOR THE MOTOR MOUNTS TO BEGIN TO FAIL. *TR

I HAVE A 2005 HONDA PILOT. WHEN I HAD IT SERVICED LAST WEEK THE DEALERSHIP PUT IN A THIRD RIGHT REAR SHOCK THAT WAS LEAKING. THE LAST SHOCK ONLY LASTED 3000 MILES. I THINK THAT SOMETHING MUST BE WRONG WITH THE CAR THAT CONTINUES TO RUIN THE SAME RIGHT REAR SHOCK. *TR