2022 HYUNDAI IONIQ 5 Complaints

Check Vehicle Electric System warming shows up on dashboard, then vehicles enters turtle mode and then cuts power shortly with violent jerking of the vehicle. Shortly after, all system shuts down, 12V is said to be weak and car cannot move.

Electric Drive System Inoperable, sustained an immediate failure upon engaging in Drive mode. Dashboard lit up with warning lights and messages. Luckily was just pulling out onto road when vehicle completely died. Tow service unable to start vehicle with jumper module. After being towed to dealer, was diagnosed with failed ICCU. The original ICCU was replaced previously in January 2025. Luckily was not underway on the road when it happened. There was no warning, no indication that there was any problem.

The ICCU (Integrated Charge Control Unit) failed. The car was in a Hyundai dealer repair shop on November 18, 2025, for an unrelated regular maintenance procedure when (i) the technician noticed a logged ICCU error code generated sometime prior to the shop visit and (ii) after the technician cleared that prior error a second new ICCU error code was generated. The shop replaced the defective ICCU. This car had been serviced on prior occasions to install updated ICCU software, most recently as part of NHTSA's recall 24V868000 of November 18, 2024 (also known as Hyundai Safety Recall 272), intended to eliminate such ICCU failures. Installation of that software as the remedy for recall 24V868000 clearly did not prevent the very ICCU failure it was intended to guard against. Please note also that it is common knowledge (as disseminated on various Ioniq 5 forums and Reddit groups) that large numbers of later Ioniq 5 vehicles with newer VINs not included in recall 24V868000, i.e., from model year 2025 onward, have also suffered from these failures despite being initially placed into service with the updated ICCU software, as well as many other pre-2025 remedied vehicles. The Hyundai ICCU software currently in operation on both remedied cars from recall 24V868000 as well as newer cars not subject to that recall is clearly entirely ineffective as a solution to this very serious safety issue. I strongly urge NHTSA to (i) declare the existing ICCU software to be an ineffective remedy for recall 24V868000, (ii) include all Hyundai Ioniq 5 cars for all model years, whether running current ICCU software or not, to be part of the group of unremedied and unsafe vehicles, and (iii) extend recall 24V868000 until such time as Hyundai can actually demonstrate that an effective remedy exists and is being made available to all Ioniq 5 vehicles.

The Integrated Charging Control Unit (ICCU) failed - the car is no longer capable of driving due to the lack of ability to charge the battery. I was able to get it to the repair center. The ICCU on this model can fail in multiple ways, which includes the vehicle becoming inoperable at highway speeds. The issue first started 2025/11/13. I tried multiple charging units. It flipped the breaker on my home charger and caused issues for a public charger.

Carr went into limp mode and wouldn’t drive more than approximately 10 mph in traffic. Once I was able to pull over and reset the ignition button, the car seems to be operating normally.

Even after the recall service performed, the ICCU still failed 10 months later. DTC P1E011C is listed and will not charge. This is the same issue for the KIA EV9 and a TSB needs to be issued the same as the TSB 339 KIA did for the EV9.

The car would not charge. The Dealership where the car was bought assessed the problem and found out that the Integrated Charging Control Unit (ICCU) of the car had failed. They already replaced the component, however I am reporting this problem so as to be included in the statistics for this common problem with this Hyundai make.

While charging at home with provided Level 1 Charger, the vehicle will suddenly stop charging. When it stops, it appears to be surging an electrical charge back into the home (black marks on outlets requiring an electrician to replace, black marks on the charger plug, and most recently, threw a breaker on our home electrical panel). This is a fire hazard.

I was coasting into a library parking space with my foot off the accelerator. The car accelerated even with my foot on the brake, jumped a curb and was stopped with above ground tree roots. The dashboard should have been lighted up with collision warning indicators and the automatic braking should have engaged. It did none of that. The car was totaled. Nothing was ever checked to see if it was a mechanical error. My insurer totaled the car.

I am submitting an update to my existing complaint regarding the ICCU safety recall on my 2022 Hyundai Ioniq 5. Since my original submission, my vehicle has been at authorized Hyundai dealerships since July 2025 and remained undiagnosed and unrepaired for over three months. During this time, I received inconsistent and misleading information from both Hyundai corporate and the dealerships regarding the status of the recall repair, as documented via emails, texts, and recorded calls. On 10/31/2025, the dealership informed me that the issue may involve a floor harness/wiring problem and it is out of warranty; however, this appears related to the ICCU safety recall, and Hyundai has not provided a firm timeline for repair. Hyundai’s delay has caused significant inconvenience, as I have been without my vehicle while continuing to make car payments and insurance payments, and arranging temporary transportation. Additionally, Hyundai and the dealerships provided multiple assurances that the vehicle was being diagnosed and repaired, which were later contradicted, reflecting misleading and deceptive practices. I request that NHTSA consider this update as part of my ongoing complaint and investigate Hyundai’s failure to provide timely and adequate recall service, as well as the misinformation surrounding this safety recall.