2022 HYUNDAI IONIQ 5 Complaints

Electrical system failure. Available for inspection upon request. While driving, warning appeared on dashboard. Warning said, "Stop Vehicle and Check Power Supply" The safety of vehicle occupants and others on the road was put at risk. I lost control of the vehicle in the middle of traffic due to the loss of electrical power. The problem has been confirmed by San Leandro Hyundai as part of the Safety Recall for the Integrated Charging Control Unit, Recall number 272. NHTSA Recall number 24V-868. The recall repair was completed but the ICCU was not replaced and is still defective. A few minutes prior to the eletrical failure a warning message appeared on the dashboard. The warning message said, "Stop Vehicle and Check Power Supply". First appeared on Saturday January 11th at 4PM (PT).

On December 22, 2024, I went out at 8 AM to have breakfast with my dad. On the way back, I noticed my car starting to slow down, and the "turtle mode" activated. Normally, this mode only occurs when the battery level is under 1%, but my battery was at 75%. As I tried to park in a safe location, the car suddenly lost power and displayed a warning instructing me to stop due to an electrical problem and to contact service. I was able to safely stop at a small shopping center plaza and called Hyundai's towing service. When the towing company arrived, they found they couldn’t turn the car on and had to use a wheel-lift tow method. Unfortunately, I had to wait nine hours for the car to be towed. The car was dropped off at the dealership on December 22, 2024, but it wasn’t checked until December 31. By the end of the first week or early in the second week of January, I was informed that the replacement ICCU (Integrated Charging Control Unit) had arrived. However, due to the dealership's schedule, they said they wouldn’t begin the installation until the following Tuesday, with hopes of completing the work by the end of that week. This incident was especially frustrating because I had already experienced an ICCU failure in January 2023, just nine months after purchasing the vehicle. At that time, no one could explain why the ICCU component had failed, and now I’m facing the same issue again.

The vehicle has no power whatsoever. Upon approaching the vehicle, it did not unlock. I used the physical key to open the drivers door. I then tried starting the vehicle only to have the gauge and center display flashing on and off with a red warning That the 12v was dead, to pull over and top immediately then the displays turned off. There are no lights or power to the vehicle no whatsoever. It cannot turn on any of the interior lights or even power door locks. This means only the front doors can be opened or locked and the vehicle will obviously not move. The 12v battery system has been a continuing issue with the vehicle. It has been repaired and the subject of several recalls during my short ownership and is still a problem. Due to a blizzard, I have been unable to have the vehicle taken to the dealership and have been without transportation for 3 days already with no clear resolution from Hyundai.

The ICCU on my Ioniq 5 failed without any warning from the car or mobile app. All recalls were performed on the vehicle prior to it failing. I was unable to charge the vehicle on level 1 or level 2 charging. The dealership replaced both the ICCU and fuse on the vehicle.

12 V battery died after being plugged in to charge overnight. The 12V battery was replaced in May 2024 due to a similar issue. It seems that the ICCU recalls and software updates have not been fixing the problem.

Driving on the highway the car entered limp mode allowing only 30 mph. Messages "stop vehicle and check power supply" with 12V battery indicator. Classic ICCU failure.

Passenger side rear seat (40% side) is missing all mounting bolts required to secure seat to vehicle. I purchased the vehicle as a preowned unit and noticed squeaking and a rattle coming from the rear seats. Upon inspection, I discovered that the seat is only resting on the floor and with little effort the seat can be dislodged.

Unknowingly my cars ICCU failed. I went to charge my car on December 23. The EVSE then immediately tripped the breaker. The EVSE gave an error code of a stuck relay fault and made the EVSE unusable. This happened to 2 different Juicebox chargers and both are not permanently disabled and need to be replaced.

Drove less than one mile and the car suddenly dropped from 45 mph to 20 and would not accelerate (I was almost rear ended by a bus). I was able to pull off the road and the battery died.

Hyundai has absolutely dropped the ball on this Ioniq 5's ICCU and 12V battery issue. After numerous recalls to fix a hardware problem through a series of software fixes that don't work and refusal to give a loaner for loss of use, I would like to pursue a buyback option for this vehicle. On Tuesday, [XXX], I went to Napleton Valley Hyundai in Aurora, IL to complete RECALL CAMPAIGN #272 NHTSA RECALL # 24V868000. After the recall, my 12V battery went dead on Wednesday, [XXX] and had to be towed to dealership. Their only solution was yet another software update and then charge the 12V and said it was ready for pickup on Thursday, December 5. I told them then to also do a wheel alignment and they said during that process, the 12V battery went down again. They then charged it back up and gave it back to me and said it was good. I encouraged them to pursue a better solution but they had no interest. So, it was picked up on Friday, [XXX]. On Saturday [XXX], the 12V battery went dead again and will have to be towed back to the dealership. Over the phone, my service advisor said it would have to be charged and released. If this issue then happens again, then a replacement might be considered. Calls to Hyundai North America headquarters have not yielded any results and they claim they need 3 business days to assign my case while I have no working car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)