2022 HYUNDAI IONIQ 5 Complaints

When my car is plugged in to charge it keeps stopping the charge. Example: Starts at 24% and stops at 28% I restart charge and it stops at 47%. Each time the charging port on the car is hot. This has happened multiple times. I now have to set reminders on my phone to check that my car is still charging so I can get to work in the morning. I am at the dealer now and they say there is nothing they can do because they have not been notified that it is an issue Thank you for your attention to this matter

While driving at highway speeds, there was a loud pop and the display showed "reduce power mode". We had to improvise a stopping place despite being far from home. There was no warning or issues beforehand. This incident was risky because of the loss of power while on a high speed thoroughfare and limited stopping options. The vehicle required a jump to move onto tow truck to take to dealership, where it has remained for two weeks without an estimate for repair. The symptoms.seem consistent with ICCU failure.

Issues with home charging at 40 amps port heats up and stops charging. When I purchased this car they stated it was possible charging at that rate.

Check electric charge error displayed, alarm sounding, loss of power to the vehicle while driving (limp mode).

While driving on the highway on 8/12 at around 4pm, with another passenger, doing approximately 65 MPH I received a "Check Electric Vehicle System" warning on my dashboard. The car showed no prior warnings, no other lights were on. MyHyundai app was also showing no diagnostic issues with the car. The car battery was showing a 77% charge at the time. I swerved on to the shoulder, putting myself in danger as this is a really busy highway. I checked the car and could not find anything wrong. Hyundai had not contacted me regarding any recalls. I decided to keep driving to see if I could make it home to diagnose the issue. I made it another 20 minutes and as I was about to exit the highway at around 60MPH the car completely slowed down to 20MPH suddenly, and I was forced to swerve onto the shoulder once again. The car would not accelerate past 20 MPH. Fearing an accident, I called a tow truck and had the car towed back to my house. There were no warnings lights/signs prior to this event. The car completely slowed down from 60-65MPH to 20MPH in the middle of the highway and I was forced to make an emergency stop putting myself and my passenger at risk. The car was brought to the dealership on 8/14 which is the first time I was alerted that there had been a recall on my car and that the ICCU would need replacement. At no point did Hyundai ever contact me via email, text, call, or mail alerting me there was a recall prior to this scary experience. This is gross negligence on the part of Hyundai, as my vehicle could have been rear ended and caused a major accident on the highway.

Vehicle suddenly had no power on the highway. Error messages said to check the power supply. Prior to this there were error messages to stop the vehicle and check the power supply. Car would not drive more than 20mph. Car then died on the highway without any power when attempting to drive to the dealer. Problem was reproduced and confirmed by the dealer to be a faulty ICCU.

The car will only charge at half of the advertised Level 2 AC charging rate. It advertises it can charge at 48 amps; however, we cannot charge above 24 amps. If we charge above that rate the charging will stop. The issue appears to be well documented in online forums where if the charging port reaches about 100 Degrees C it will fault. There is a TSB they are installing but it just makes it automatically derate to ~24 amps which other than providing 15 minutes of higher power it doesn't at all solve the situation. Hyundai has recently stated that they are aware of the issue and they expect people to live with it and re-adjust their expectations; but it is fair to expect the car to perform as advertised. I also don't think any caveats about charging speed for weather or state of charge would be specific to level 3 charging; I am not aware of another EV in existence that doesn't provide its advertised AC charging level. It pretty clearly appears to be defective hardware. We also have friends who bought their car a month later (July 2023) and they are having the same issue; albeit they can still charge at 32amps. To answer the questions directly. - Charge Port - The cars cannot charge in time advertised making people drive without buffers and could run out of power on trips because they can only charge at half the rate advertised and couldn't charge overnight. - We are getting the TSB that will automatically reduce the charging rate this week. we had to wait over a month for an appointment. - It has not been inspected yet but all they are going to do per the TSB is if we say we have the problem they do the software update. - There are no customer facing error codes. The issue first started in March the first day it was over 70 degrees. We did not have an issue last summer or over the winter. The longest we can charge since then at 40 amps is about 15 minutes. We have never even charged the car at 48 amps which is what it is supposed to be able to do.

When in motion, the “EV Start Stop”button is still allowed to turn off the vehicle if accidentally pressed. This happened to me while on the highway and moving about 15-20 MPH. The vehicle suddenly lose power and wouldn’t accelerate. I could not move the vehicle, without hitting the EV Start Stop button several times.

Hyundai San Jose dealership, Customer Service, told me, The fuse surrounding the Lithium battery is broken. This causes the whole car break down, and it is very dangerous to drive. My car has been in this Hyundai dealership over 5 months now, Hyundai cannot send the parts to San Jose Hyundai and I cannot drive the car. Also the 12V small lead acid battery in the front, broken down a few times. Cannot start the car. The whole car shuts down.

Charge port on vehicle overheats when charging on AC charger and stops charging. Anything above 32 amps. The car is supposed to handle 48 amps.