2022 HYUNDAI IONIQ 5 Complaints

While driving, on a busy street in Holyoke MA, a STOP waning appeared on the drivers display indicating an electrical/power problem. I pulled over to side of road and called a tow truck. Car was taken to dealer where they ran diagnostics on the vehicle. Diagnostics showed failed ICCU and bad cell in 12v battery. Replaced ICCU and high voltage fuse.

THE car dash board flashed a message: STOP IMMEDIATELY. CHECK THE ELECTRICAL SYSTEM. I drove 1 mile home, called the dealer, was told to have the car towed to dealer. When the tow truck arrived the car battery was totally dead. The dealer said it was an ICCU problem, and that they had seen it before. Could take weeks, or months, to get a new part!

Car displayed a message "12V battery voltage low. Stop safely" and the 12V baatery does not charge in the vehicle. This is a known issue with this car and is currently being investigated for a vehicle recall.

I received a 'check electric vehicle system' notice on my car.I believe this is related to the 12V/ICCU issue occurring in the I5's.

Was driving the vehicle in a local road and felt sudden drop in vehicle speed. Had to press hard the acceleration pedal to avoid any collision from behind. The vehicle could not gain enough speed in a ~45~60mile speed zone and driven ~2miles slowly to work place. The vehicle had to be towed to a local delearship as they suggested. The warning message was 'Stop vehicle and check Power supply' immediately after and changed to 'Check EV System' when started ~1hr later at the time of towing. The local dealership diagnosed it to be needing a new ICCU board, integrated charge control unit, which is in back order for ~2weeks (vehicle is still at dealership). In hindsight (after hearing recent news on ICCU failure of Ioniq5), the vehicle had a related issue in Feb 2023. At that time, the vehicle electrical system got blacked-out in my garage (it didn't respond to any button pressing with completely dark dashboard screen). It was towed to a local dealership since jump jump start could not fix it. They replaced a 12V battery for which local dealership could not give me convencing reason for the dead 12V battery .

Vehicle constantly disconnects from level 2 chargers, when charging interface overheats beyond threshold. This is an ongoing issue, and I have had this symptom on multiple chargers so it is specific to the vehicle. It is a common and known issue with the internal charging control unit (ICCU), yet Hyundai has refused to issue a recall to replace the faulty components. They have issued a TSB which throttles charging speed to minimum when the error occurs, but this is an unacceptable solution due to charging time constraints for many customers. I purchased the car with the understanding that I could charge at 48 amps, not 16, which is where I have to set it to keep from disconnecting constantly. The overheating components could also cause a fire hazard in certain situations.

Level 2 garage charging of car overheats and switches off mid-charge, even with the kWh from the wall charger throttled to Hyundai's minimum setting (60%). What was a minor/occasional problem is now a constant problem in hotter summer temperature, and there is no way to charge the car fully.

I was driving and could go no faster than 30 mph. I was very close to a dealership (a few blocks) and was able to make it there before the entire car turned off. An electrical error displayed on the dashboard before it shut down.

Hyundai has admitted that the integrated vehicle charger port overheats when charged at 48A. My vehicle was often stopping charge after only an hour or a few percent, leaving me without enough charge in the morning. Hyundai has offered a software "fix" for the problem which downrates the charging speed when overheating is detected, but this is only a bandaid solution and slows the car's charging speed by half, which was not what was promised when the car was sold.

Vehicle charging stops because the port gets overheat while charging on A/C. https://www.reddit.com/r/Ioniq5/comments/14g1922/charging_issues/?utm_source=share&utm_medium=ios_app&utm_name=ioscss&utm_content=1&utm_term=1 I have this exact same issue. It doesn't happens when you charge on 32amps EVSE. But 40or 48amps is the problem.