2022 HYUNDAI IONIQ 5 Complaints

Hyundai's connected car service (bluelink) suffered an outage that resulted in driver profiles on many Hyundai vehicles being deleted/reset. No notice was provided and the profiles were not recovered. As a result, the vehicles did not funtion as expected. Driver assist settings were set to default (steering, braking, and acceleration functions included). Hyundai provided instructions on how to set up a new profile in response rather than restoring the customer data to their personally owned hardware (car).

The Hyundai Ioniq 5 advertises quick charging via level 2 (240v) supporting nearly 10 amps. Hyundai has acknowledged by issuing a TSB this year that the charging port overheats at high amperage and causes charging to cease before the battery reaches the intended state of charge. The TSB addresses the issue by slowing the rate of charge substantially when the port overheats. As a result, owners are unable to "refuel (charge)" the vehicle at the advertised rates. In addition to the overheating charge port posing a potential hazard, the result is that an uninformed owner may not have necessary charge to reach their destination.

I have installed a hard wired 240V/48 amp EVSE for charging my vehicle at home. When charging at any current above 32 amps, the charger on the car is apparently overheating and causing charging to stop for approximately 3 minutes and restart charging then stopping again after another 30 seconds or so. Hyundai has issued a "fix" for this which simply throttles the maximum potential amperage delivered, resulting in delayed charging of the main vehicle battery. There are no warnings in the vehicle when this occurs, I just get a notification in the Hyundai app that charging was stopped. My only current workaround is to drop the amperage to 32 amps, which is 33% slower charging than I anticipated when installing the EVSE. Had I known of this issue, I could have opted for a less expensive and easier install method, but Hyundai issues no such warning when you purchase the vehicle.

Ioniq 5 continuously fails to complete charging when on level-2 EVSE. Charging port and plug feel extremely warm to the touch, even in cool ambient weather. Multiple UL-listed charge cables yield similar results, while working perfectly well with other EVs.

My partner was driving my car on Tuesday, May 23, 2023 and received a "Check Electrical Vehicle System" warning. Within 30 minutes of receiving that warning, the maximum speed on the car was throttled to 20 mph and shortly after that, the car stopped working entirely. Thankfully, my partner was on a residential street when all this occurred and was able to move to safety; however, had any of this happened in a highway driving scenario, the results could have been catastrophic. My car was towed to a dealership that same evening and it has been with the service department since then. The two parts on backorder they are waiting on on the ICCU Assembly and a High Voltage Fuse. Upon searching for other Hyundai IONIQ 5 owners with similar issues, various internet forums are filled with reports of similar things happening. At this point, I have been told this part is on backorder for potentially up to 6-9 months and after repeated calls with the dealership and the corporate office, Hyundai has not acknowledged the extent of this issue, the potential safety concerns, nor offered any relief for being without my, basically brand new, car for the remainder of this year.

Driving the car about at 45mph then I heard a pop sound from the rear of the car. Car displayed warning "Check Electrical Vehicle System." I pull over, shut it off, then restarted it. The "check Electrical Vehicle System" light stills on then an emergency message displayed 'Stop Vehicle and Check Power Supply.' When I tried to drive to a safe place I noticed the car would not drive faster than 25mph. If this would have happened in a highway this could have been a safety issue. Dealership confirmed that the Integrated Charge Circuit Unit (ICCU) needs to be replaced.

On Apr 18, 2023, My vehicle had a complete electrical system failure while driving on the local street. When the failure occurred, a warning message along with loud audible beeps was displayed suddenly indicating the vehicle was experiencing an Electrical System failure, and we must be pulled over immediately without delay due to safety concerns. The system completely failed shortly after, and the vehicle became unresponsive and inoperable. This post a major safety risk to those inside the vehicle, other vehicles, and pedestrians nearby if the vehicle became inoperable in the middle of traffic. The vehicle was towed to the dealership (Stevens Creek Hyundai, Santa Clara, California) the following day for inspection. The inspection report indicated a failure in the ICCU fuse unit and the 12V battery. This issue falls into the power train defect and repair will be covered under the manufacturer's warranty. The vehicle has been with the dealership for 6 weeks to date (Jun 20) without a repair ETA. The vehicle was purchased brand new in Mar 2022. It was only 13 months new, with 8090 miles at the time of incident. The work order is attached.

I was driving about 30 mph on a secondary road when the vehicle suddenly lost power and speed and a large batter warning light came on on the dash. I restarted the vehicle, and the same thing happened again. We had the car taken to Peder Hyndai in Poway, CA. 858-486-6560. They said that there was a fault with the "battery control module", and that they would have to order parts. They said they had "at least two" other ionic 5s with the same problem. We've been driving a loaner for 1 mo, and still the part hasn't arrived. This was the third trip that day, and there were no problems with the earlier trips. This had never happened before. The car did not make any unusual sound that sticks in my mind during the episode.

The vehicle completely lost power and there was 207 miles left to the charge. The message displayed on the driver's screen read "12V battery voltage low. Stop safely" I had no other choice than to stop since the car suddenly had zero power. The car was towed to Hyundai dealership on 2/15/23 and I have yet to have the vehicle repaired. Hyundai keeps informing me that the part is on order and delayed. I have been waiting a long time for a defective vehicle.

Car literally DIED while driving. Went from normal speed to 12mph to 6mph to dead. ICCU failure.