2023 HYUNDAI PALISADE Complaints

The contact owns a 2023 Hyundai Palisade. The contact received notification of NHTSA Campaign Number: 25V607000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

Recall was issued 9/11/25. As of 8/1/26 Hyundai still tells me they do not have the parts. Passengers have had difficulty getting seat belts to latch properly.

unknown, been trying since 2024-2025 to get the back seat belt recall done only to be told its on back order not sure when it will be available. In the meantime I have my kids in the back seat , The dealership response was to get an "rental car" until the parts come in.

I was driving and stopped at the tunnel for traffic. My car shut off and wouldn’t turn back on. It seemed to have overheated. After about ten minutes, it started again. I was told it was told the oil pump controller affecting the stop and go on my car. Priority Hyundaii in [XXX] didn’t didn’t have the part to repair it. Now they are refusing to repair it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Following a recall repair on the rear seatbelt assembly of a 2023 Hyundai Palisade, a severe safety design defect was discovered. The replacement buckle installed by the dealer lacks proper flexibility and clearance. Consequently, when the second-row seats are folded down, the seat frame directly crushes and structurally damages the rigid plastic buckle, as the component cannot clear its designated protective slot. This issue presents an extreme safety risk. The second-row seatbelt buckle is now cracked, crushed, and structurally compromised, rendering the restraint system unsafe and unusable for rear-seat passengers, including my young children. In the event of a collision, a structurally damaged buckle could fail to hold, leading to severe injury or ejection. There were no warning lamps or symptoms prior to failure; the damage was only discovered after folding the second-row seats down. The failure is 100% reproducible every time the seat is folded due to the geometry and lack of movement in the installed recall component. The vehicle was brought to an authorized dealership service center, where the damaged component was physically present and inspected. While the dealer confirmed the buckle is physically crushed and left the service order open, both the dealership and manufacturer customer support have refused to correct the installation or replace the damaged safety part under warranty, falsely claiming normal wear and tear. The vehicle is available for immediate inspection upon request. This complaint is being filed because a manufacturer safety recall repair directly caused a vital restraint system to self-destruct during normal vehicle operation (folding seats), and the manufacturer is refusing to remedy the compromised safety equipment.

My seat buckles have been on recall since last year and they still have not fixed them. I have been to the dealership capital Hyundai in Greensboro, NC multiple times to try and get them fixed. They told me in January that it would be fixed in February. I am concerned to drive my car with my kids if they are not latching properly.

I have had 4 appointments for my 2023 Hyundai Palisade to have the recall on the seat belt buckles addressed. Each time, I am told by the dealership that Hyundai hasn't sent the part yet. I was told that Hyundai is only sending 10-15 parts at a time. There are a lot of these vehicles on the road, and at this rate, my car is never going to be fixed. There is also an open warranty for the 3rd row ejection mitigation that there is no fix for yet. I was told not to use the third row, which is not really possible and is part of why I bought a car with 3 rows of seats. I feel uncomfortable driving my car as well as having passengers in the first and second row, as I feel the seat belt might not hold if there was an accident. My safety and the safety of my passengers is potentially being compromised. I feel that we received the seat belt recall 9 months ago and that is plenty of time to address this problem. I am requesting for the NTSB to get involved and require Hyundai to provide a loaner car (of the exact same size and capacity) until my Palisade can be reapired. I was also told at an additional appointment that the rear shocks that leak are also waiting for Hyundai to ship new ones. So, I am currently driving a car that might not have proper working seat belts for the first 2 rows, can potentially eject anyone riding in the 3rd row with leaking shocks.

Two simultaenous problems happened: 1) loud clunking/thudding during low-speed turn. 2) Clunking/knocking/rattling noise from suspensions when going through uneven grounds. This both things happened before 20,000 miles. Had AWD coupling and rear differential unit replaced under warranty regarding problem 1). Had rear shocks replaced under warranty regarding problem 2). Found there has bben TSB issued related to 2), for older models, TSB 25-SS-004H but not for this year of models. Those two exact problems started again at about 40,000 miles. Had vehicle checked at 50,500 miles recently. Regarding problem 1), the dearship found issue with AWD coupling, stating faulty parts, drive shaft seal was 1/8" off and materials are fused. Replaced AWE coupling, and ECU program update. After program update, I do not see the power distribution monitor anymore from my dash. The program update should turned it off for some reason that I do not know. I have no clue that AWD module is working normal as I cannot see the power distribution action anymore. Regarding problem 2), they replaced both rear shocks again. The problem went away for now. This vehicle has been only 50,000 miles and had 4 major issues (2 times of two major identical issues) that alongside with many owners' compaints, and seems highly related to one of Technical Service Bulletin that was previously issued for older models. I would like to request investigation on these services.

The self leveling shocks have gone bad two times now in a matter of 4 months. The first time we had no major issues but the second time it caused the ABS system to kick in while making a left turn. The dealer said it was caused by the car not sensing the correct posture because of the shocks turning on the ABS system and causing us not to be able to brake for about 10-15 feet. If there was a person or vehicle in the way we would have crashed.

The front sunroof on our 2023 Hyundai Palisade shattered without any impact and caused a huge explosive sound. When we went outside the car to see if there was any rock or debris, there was no sign of any rocks or debris which caused the front sunroof of our car to shatter. The glass from the shattered sunroof could have possibly hurt us seated in the front seat or could have injured our one year old and six year old kids seated in the middle row.