2022 HYUNDAI SANTA FE Complaints

Vehicle on initial start up shows no issue. Driving for a short distance or stationary for a short time. Vehicle instrument panel will show a fault of Forward safety system. Errors on Lane keeping assist, High beam assist, and Driver attention warning. Smart camera module will be hot to the touch causing failure of Front view camera and Front Radar Module.

Occasionally the cruise control will go off. Sometimes it will reset itself & other times, the driver has to initiate. I reported to the Hyundai Manuf. last yr. & also had 2 separate dealers take a look & problem has not been resolved.

On June 20 2026 at 2:07pm Central Time there was a check engine light displayed on the dash of my vehicle 2022 Hyundai Santa Fe Calligraphy, while it was parked in the garage of my home and was just powered up. I had then performed the vehicle diagnostics test (pictures attached) that showed that there was an issue with the 'Transmission Control System' with detail that a full system check is recommended and to schedule an appointment with a dealer. I had later proceeded to contact local dealer 'Huffines Hyundai McKinney' for service as I was due for an oil change anyway. As I was driving the vehicle from my home which was about 13 miles away from the dealership, I noticed that the vehicle had great trouble shifting from 1st gear to higher gears, that the speed would be 20mph or lower no matter how much the accelerator was pushed and I had to drive very carefully in traffic due to the low speeds. I was told at the dealership by 3pm that day that there were no active recalls on my vehicle, that the transmission related recall that was showing up on google search for that DCT code wasn't specific enough to my vehicle and to book an appointment for vehicle diagnostics and transmission repair/replacement at full cost to myself. The multi-point inspection report after oil change showed nothing about the check engine light issue or that the issue was even diagnosed by the dealership. From that day until today Aug 29 2026, I've noticed that the vehicle still has trouble shifting from the 1st gear, that the vehicle drives normally when increased time is allowed between power up and start of drive (~2min of engine running idle) and that the check engine light reappears after a trip of quick power up and drive. There was atleast one instance where I had to pullover onto the shoulder to avoid high speed traffic while driving in the right lane.

At approximately 67,000 miles, the vehicle experienced a sudden vibration when accelerate and decelerate. Engine light was on and vehicle had a hard time to maintain speed above 40mph. Cars were honking behind us due to the lack of speed on road. It happen all of a sudden and cause me and my wife panic at first. The car was took to the closest dealer ([XXX] Hyundai [XXX]) and they found the problem was due to an internally leaking fuel injector, requiring a complete out-of-pocket replacement. This is a known, widespread manufacturing defect directly addressed by Hyundai Technical Service Bulletin TSB #25-FL-001H (which supersedes 23-FL-002H-1). The bulletin explicitly states that 2021–2022 Hyundai Santa Fe 2.5L GDI engines suffer from premature internal fuel injector failure caused by internal filter breakage, forcing owners to pay out of pocket for a design flaw acknowledged internally by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The driver-side seat belt buckle on my 2022 Hyundai Santa Fe will not latch. This is a safety-critical failure under FMVSS 209/210. The vehicle has not been in a collision. The dealership and Hyundai Consumer Affairs bot stated that the seat belts are only covered under te 5 yr/60K warranty and refused to treat this as a safety defect. The buckle failure prevents proper restraint and poses a serious safety risk.

Symptoms are those described in Hyundai recall 236 (delayed shifting,hesitation, stalling). Vehicle has had multiple TSP services at Hyundai but symptoms persist intermittently. Software updates do not fix issue. Hyundai dealer has no other remedies.

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle jerked or hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact stated that after two separate warranty repairs of the fuel injector, the failure persisted. In addition, the contact stated that the rear-view camera intermittently displayed a distorted or blank image while the vehicle was in reverse(R). The contact received notification of NHTSA Campaign Number: 24V879000 (Back Over Prevention); and was informed by the dealer that the vehicle was not covered under the recall. The manufacturer was notified of the failure, and the contact was issued a case number. The failure mileage was approximately 30,000.

While accelerating, the 8-speed transmission sporadically hangs in 1st gear and will not change to 2nd. The motor revs to about 4000 rpm and will only travel at about 15 mph. This causes a safety hazard when attempting to enter fast moving traffic. After several attempts, the Dealer has said that they cannot duplicate this issue in their shop and has not made necessary warranty repairs to fix this vehicle. Hyundai assigned a case manager who says that since the diagnostic did not pull any codes and they could not replicate the problem, they would not make any repairs. There is about 5000 miles left on the factory warranty.

The car was shaking alot but the engine light was off. Started it the next dat and the check engine light came on. Went to auto zone to see what the codes were. The 1st and 3rd cylinder are misfiring. The car was just serviced for the 60,000 mile tune up in june 2026. This problem started August 14, 2026. The dealership is stating that the spark coils or cylinders are not under warranty even though it was just serviced

The horn has now stopped working in my vehicle twice. It was replaced 01/27/2023, and is now non-functional again. I believe this to be a safety issue as I have no way to warn other drivers or pedestrians of my presence, if necessary. One example of this, was that a vehicle was proceeding into my lane on the interstate yesterday afternoon and I had to avoid them hitting my vehicle by driving onto the shoulder of the road, as I could not use my horn to let them know they were coming into my lane while I was on the side of them.