2025 HYUNDAI SANTA FE HYBRID Complaints

WHAT FAILED: The 12-volt battery / no-start system. Beginning XXX, my 2025 Santa Fe Hybrid (bought new XXX suffered seven (7) sudden 12V battery failures causing a complete no-start. Each time the vehicle became inoperable with no warning, stranding my family - including two minor children (ages [XXX] and [XXX]) - and requiring roadside assistance and towing. Events: XXX (tow), 1XXX; the vehicle has sat immobilized at the dealer since XXX (~113 days). 5 dealer repair orders are attached to this complaint. SAFETY RISK: A repeated no-start can strand occupants in unsafe locations and prevent the vehicle from starting in an emergency. Once it had to be extracted from inside our garage by AAA after a 3+ hour wait; on XXX the battery died ~2 minutes after a jump-start, before I drove away. CONFIRMED BY SERVICE CENTER: Yes. AAA certified 0% state of charge at each failure; an independent OBD scan showed 4% ('Not Getting Full Done'). Hyundai issued TSBs 26-01-016H (XXX) and 26-01-016H-1 (XXX) identifying the root cause as the Fingerprint Module (FPM) failing to enter SLEEP mode when the ignition is off, draining the 12V battery - the exact defect my vehicle showed, and it applies to my vehicle. An OTA remedy released the week of XXX was never applied. INSPECTED BY MANUFACTURER: Yes - the dealer and a Hyundai field engineer inspected it. The dealer repeatedly blamed my behavior (windows down, unlocked doors, short commutes ~20 mi/day); its own draw test showed no draw, yet the diagnosis was never corrected. A Final Repair Opportunity in Jan 2026 did not fix it; failures recurred XXX and XXX As of this writing (XXX) the vehicle remains at the dealership since XXX without any status on repairs done or pending. WARNING SYMPTOMS: Sudden no-start / no-crank with no prior warning lamp, beginning XXX and recurring repeatedly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car went from 70 miles an hour to 25 miles an hour all of a sudden on the highway and then would not allow to accelerate afterwards. Battery stopped charging and we had to stop it multiple times to get it to continue to drive no faults or issue on the dashboard.

There is a severe and dangerous lag in acceleration when trying to merge into traffic. Praying the accelerator all the way down often result in the car not responding for a second or two before kicking into gear. This is significant when trying to merge onto a highway or onto a cross street with incoming traffic.

The dealer is unable to remedy the defect within a reasonable time. It’s been two months with no fix and my family’s safety is in jeopardy.

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving approximately 70 MPH, the Apple CarPlay system unexpectedly interrupted the operation of the vehicle and initiated a live software update. The navigation system, infotainment system, and other vehicle functions became inoperable. The contact stated that several unknown warning lights were illuminated and continuously cycled on the instrument panel. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted but provided no assistance. The approximate failure mileage was 2,774.

The vehicle has gone into a limp mode unexpectedly while driving on the highway at 60+ mph. The first issue was on May 13, 2026. The car immediately stopped driving and went into limp mode and cannot go over 30 mph. It was taken to a service dealer. They could not replicate the problem, therefore the vehicle was given back as undiagnosed. This next incident occurred and almost caused an accident, and that was on June 3, 2026, again driving on the beltway around Maryland. The car went from 70 mph to 30 mph. The vehicle stayed at 25 to 30 mph the entire time. Could not get it to do anything else. Drove cautiously on the side of the road and got to the dealership after driving 30 minutes at 25 mph.

Sudden loss of power while driving on the interstate (65 MPH) , car would no longer accelerate and slowed down to ~10 MPH. Had to merge onto emergency lane, car struggled to power over 30 MPH. Warning light came up to "Park with engine On to charge battery". Parked car and restarted car and still did not resolve issue. Had to switch the car into "Sport" mode to drive home.

While driving on the freeway at approx 65mph, the car suddenly starting de-celerating and forced me to pull over to emergency shoulder/lane and try to determine the cause. The car is a "Hybrid" and the dashboard stated to put car in Park and Idle the Engine over 2000rpm to charge up the Battery. ( i still don't know which Battery they were speaking of...Engine Battery or Hybrid Battery) I sat there Idling the Engine for 15 minutes and slowly proceeded to get off the freeway and limped the car back to my home. I then called my selling Hyundai Dealer, as the car was still in warranty, and told them of my sudden problem and asking them what could it be??? They said they did not know until they saw the car and tested it with their computer equipment...please have it towed into their shop. So i did and 2 days later they called to say..NO Computer Codes showed any problem. They could not duplicate problem. I said ..."look on the internet...many people have reported sudden lack of power and limp mode activation....all pointing to the High Pressure GDI Fuel Pump Assy failure". Dealer said ..Oh..thanks we will look into that. 5 hours later Dealer called and said I was right, we replaced the Fuel Pump and come pick up the car. 4 months later and 6,000 miles later car is performing normally. I felt compelled to come forward to discuss this part failure as this incident on the freeway could have turned into a tragedy. Thank you

My 2025 Hyundai Santa Fe Hybrid AWD was serviced under warranty on 4/22/2026 for a driveability concern after experiencing a loss of power while driving. The service history shows part HY35326-2M500 was replaced. On or about 5/25/2026, the same issue occurred again while driving at highway speed. The vehicle suddenly lost motive power and dropped from approximately 70 mph to approximately 30 to 40 mph, creating a serious safety risk because the vehicle could not maintain speed with surrounding highway traffic. No warning lamps, dashboard messages, or diagnostic codes appeared during the failure. The vehicle is currently at a Hyundai dealership for inspection and repair for the repeat issue and should be available for inspection upon request. The prior dealer record appears to describe the issue generally as a “driveability concern,” but the current repair diagnosis and full repair notes are still pending. It is unknown whether the dealer has reproduced or confirmed the failure during the current visit. I am reporting this as a sudden loss of motive power at highway speed involving the fuel/propulsion system, engine, and/or powertrain.

"My 2025 Hyundai Santa Fe Hybrid has experienced repeated parasitic battery drain. Dealer diagnostic reports dated 5/12/26 and 5/14/26 document 'Excessive dark current draw condition identified' with dark current spikes well above the normal threshold of 50mA. Vehicle was at Kelly Hyundai of Stroudsburg PA for approximately two weeks. Dealer replaced fingerprint sensor module as best guess repair but could not confirm it was the definitive cause. Battery replacement was denied as battery did not meet Hyundai's replacement threshold despite documented drain. Service technician verbally acknowledged this is a known issue across 2025 Hyundai Santa Fe vehicles. DTCs C173300 Undervoltage Detected were found on both front door handle sensor modules. Concerned about long term battery health and potential for repeated drain leaving vehicle inoperable."