2025 HYUNDAI SANTA FE HYBRID Complaints

I purchased a new 2025MY Hyundai Santafe Hybrid. Since the day of my purchase there has been a constant error message that is displayed on dash saying "Driver attention warning system failure". this light stays on constantly and disables cruise control and adapative cruise system. This affects the usability of the vehicles. WHen asked Hyundai they say, drivers arent expected to wear sunglass if this system has to work properly, they even say constant blinking will cause system to fail and disable cruise control. This is a serious concern. How can people drive a car without blinking and how can a new car have disabled cruise control all the time.

Hyundai's Forward Attention Warning is so aggressively annoying it makes me want to drive off a cliff to shut it up. Driving with an arm in the 12 o'clock position? "BEEP! Keep your eyes on the road!" Polarized sunglasses? "BEEP! I can't see your eyes!" Oh, there's a setting! Let's turn it off..."BEEEEEP! WHERE ARE YOUR EYES!". I just purchased and cannot use Cruise control I need to wear glasses It has a hard time seeing my eyes I cannot turn off I have tried many positions on steering wheel to no avail.

Purchased new 2025 Hybrid AWD Santa Fe with 47 miles on 8/3/25 at 6pm. By 6:30am on 8/4/25 I noticed an occasional knocking when coming to a stop, reversing, turning and at times driving forward. The knocking became more frequent and noticeable as the day went on with more driving and not once did a service message or warning light display. At 1pm on 8/4/25 with an added 100 miles, I drove it to Hyundai Service Department to have them diagnose the issue which they immediately heard. After 8 days, I was told it was a control arm issue which them lead to a complete suspension rebuild on the driver side. I could have lost total control of the vehicle due to the bad control arm. They claimed the passenger side was fine and I picked up my car on 8/12/25 4pm. By 6:30am on 8/13/25 the knocking was back and car is pulling to the right. Car is back in the service shop to further investigate the knocking. I believe Hyundai is trying to cover up this issue as the service report they initially gave me had no mention of the control arm or suspension rebuild. I refused to sign and asked for another service report stating what the issue was and how it was repaired.

Check emergency, stopping function alert. Check hybrid system stop safely. Both alerts came on the dash the steering wheel vibrated 11 other alerts popped up in the car steered me to the side of the road. It would not start again and This has happened four times in the 7 months I’ve had the car Hyundai cannot figure out what the issue is. In fact they tell me there is no issue because it’s not happening to them while it’s been there for almost a month.

Occasionally, the vehicle acts like I am not looking at the road and I’m not sure if it is because of my hair, glasses, hat, or my lazy eye. On three different occasions in nearly 8000 miles it will randomly hard break on the interstate. Initially, I had thought this was something I was doing. When I was finally able to speak with the service staff, they confirmed that this is a common issue with people wearing glasses or any other items the vehicle does not register as normal. At this point, I am afraid to drive a vehicle once I learned that this is a safety setting I cannot control. I have been told by Hyundai that the vehicle is operating as it should however it is extremely concerning that this could cause an accident on the interstate and someone could get killed.

I’m reporting a recurring safety issue with the Pirelli Scorpion All Season MS tires (255/45 R20) factory-installed on my 2025 Hyundai Santa Fe Hybrid Calligraphy. At just over 7,500 miles, I began experiencing significant vibration at highway speeds. The dealership diagnosed the issue as defective tires — two were replaced, but the issue returned within 24 hours. I stopped driving the vehicle due to safety concerns. This problem appears to be common: I’ve found numerous reports of Scorpion MS tires showing early failure, poor balance, bulging, and premature/uneven wear — all within low mileage. They stated that it was still an inherent issue with the tires and I would need new ones. Thus I requested to have a different set tires given the issues with these. These issues compromise the vehicle’s stability and may present a serious hazard in wet or winter conditions. I’m concerned these tires are not structurally reliable and should not be standard on family SUVs like the Santa Fe. Hyundai and Pirelli should investigate this tire line for potential safety defects or recall. I understand that it is the Scorpion MS, AS Plus 3 and the Verde with these similar issues. Unfortuneately for some reason your site won't let me post my photo, but I was able to file it under the same VIN under my report for the Santa Fe.

I’m reporting a recurring safety issue with the Pirelli Scorpion All Season MS tires (255/45 R20) factory-installed on my 2025 Hyundai Santa Fe Hybrid Calligraphy. At just over 7,500 miles, I began experiencing significant vibration at highway speeds. The dealership diagnosed the issue as defective tires — two were replaced, but the issue returned within 24 hours. I stopped driving the vehicle due to safety concerns. This problem appears to be common: I’ve found numerous reports of Scorpion MS tires showing early failure, poor balance, bulging, uneven and premature wear — all within low mileage. These issues compromise the vehicle’s stability and may present a serious hazard in wet or winter conditions. I’m concerned these tires are not structurally reliable and should not be standard on family SUVs like the Santa Fe. Hyundai and Pirelli should investigate this tire line for potential safety defects or recall. It also appears that the it's the MS, verde and AS Plus 3 from pirelli that have these issues. You can find additional complaints regarding these with a google search. They will be on reddit and facebook.

Stopped for gas, vehicle started but would not go into gear, engine lights indicated 'Check hybrid system', warning lights shown. 1/2 hr on the phone with dealership to assist. No problem detected when returning to home dealer. Second episode occurred, vehicle at dealer for the past 4 weeks. Episode repeated at dealership yet "no abnormalities are detected with diagnostics ".

I've been having a few issues with my 2025 Calligraphy Hybrid I bought in November related to the main screen, sometimes when I start the vehicle it doesn't properly initialize and it will show me some of the icons and nothing else. No HUD, no speedometer, no remaining fuel, no hybrid information. It's a huge safety issue, it seems to happen every couple of weeks. I thought it was the digital key not working properly so I disabled that but still having issues. I have to let the car sit for a few hours or overnight and then when i turn it on then it's back to normal. I realized that when the main screen is off, it doesn't capture the mileage so the mileage is off by close to 300 miles right now. Huge issue, I've had it happen on my way home from work (25 miles) at least 4 times, and once on a road trip (150 miles). Also when this happens because I can't see the speedometer, I have to use Waze on the infotainment screen (which works without issue) to see my actual speed because the built-in navigation only shows me increments of 10 mph on the screen (this is just stupid).

The cruise control system cuts of with message on screen stating that , system camera can’t see my face and the system de-activates. This is especially dangerous at highway speeds. The vehicle behind me doesn’t see a brake light as my vehicle suddenly looses speed. This is from Hyundais Driver Attention Warning (DAW) function. This function cannot be de-activated by myself or my dealership which is Webb Hyundai of Merrillville Indiana.