1996 ISUZU TROOPER Complaints

IT IS A STRONG VEHICLE GOOD PERFORMANCE BUT THE FRAME DOES NOT SUPPORT ENOUGH PROBLEMS WITH THE STABILITY OF THE VEHICLE ON THE ROADS OR IN EMERGENCY MANEUVERS ALONG THE WAY. DUE TO CORROSION AND RUPTURE IN THE CHASSIS SPECIFICALLY IN THE CONNECTIONS WITH THE FRONT AND REAR SUSPENSION CONTROL ARMS. (POOR QUALITY STEEL) ANOTHER POINT IS A SMELL OF FUEL AND SPILLAGE, BY THE FUEL TANK. (FIRE RISK) ALL THESE CONDITIONS RESULT IN RISK MANAGEMENT, LOOSE VEHICLE CONTROL AND ROLLOVER POSSIBILITY.

THE FRAME IS RUSTED OUT AND FALLING OFF IN CHUNKS. I DIDN'T GET AN INSPECTION DONE IN JAN 2013 BECAUSE I WAS TOLD THE YEAR BEFORE THAT THE RUST IS GETTING BAD. OTHER THAN THE FRAME, THE VEHICLE IS IN OUTSTANDING CONDITION. IT ISN'T A SAFE VEHICLE. DO I HAVE ANY RECOURSE? *TR

THE ACCELERATOR STICKS. THE LAST TIME THIS HAPPENED, THE ACCELERATOR STUCK ALL THE WAY TO THE FLOOR AND WOULD NOT RELEASE. MY ONLY OPTION WAS TO CUT THE IGNITION. I NOTICED THAT THERE WAS A RECALL FOR 92-95 MODELS, HOWEVER, MINE IS A 96 MODEL. *TR

CONSUMER CALLED COMPLAINING HAVING PROBLEM WITH FUEL RAILS. DEALER INSTALL THE WRONG HOSE. PLEASE PROVIDE FURTHER INFORMATION. TS

WHILE DRIVING AROUND 25 MPH , CONSUMERS VEHICLE BROADSIDED ANOTHER VEHICLE, AND BOTH DRIVER AND PASSENGER AIRBAGS FAILED TO DEPLOY. CONSUMER HAS YET TO CONTACT DEALER. *AK CONSUMER STTED THE VEHICLE WAS A TOTAL LOSS.*SLC

I HAVE HAD AN ONGOING PROBLEM W/ANTIFREEZE SMELL, I HAVE TAKEN IT IN TO SHOP SEVERAL TIMES THE LAST HAVING A HOSE TO THE TRANSMISSION REPLACED WHICH SEEMED TO TEMPORARILY REMOVE PROBLEM FOR ABOUT A YEAR BUT THE SMELL IS COMING BACK. IT TOOK THREE VISITS TO FIND IT THE FIRST TIME.. *AK

2 LEAKING O-RINGS IN THE WATER OUTLET NECK OF THE CORE CAUSED THE ODOR OF ANTIFREEZE TO ENTER THE CAB OF THE VEHICLE AND CAUSED THE DRIVER TO FEEL SICK, RADIATOR LEAKING FROM THE SEAM AT THE TANK NLM

ON SATURDAY, MARCH 3, 2001 AT ABOUT 9 AM I PULLED INTO THE MOBIL GAS STATION IN CASCADES SHOPPING CENTER, STERLING, VA TO REFUEL. MY TANK WAS ON "E". I TURNED OFF THE VEHICLE, POPPED THE GAS CAP DOOR OPEN FROM INSIDE THE VEHICLE, EXITED THE CAR AND WALKED AROUND THE REAR OF THE VEHICLE TO REFUEL. I BEGAN TO TURN THE GAS CAP WITH MY RIGHT HAND. AS I DID SO, I HEARD A "HISSING" SOUND AND THEN FLAMES IMMEDIATELY SHOT OUT OF THE TANK. THE BRIGHT ORANGE FLAMES BURNED STEADILY APROXIMATELY 18 INCHES FROM THE VEHICLE FUEL NECK. PEOPLE AT THE STATION BEGAN TO RUN AWAY FROM THE VEHICLE. I IMMEDIATELY REMOVED MY 18 MONTH OLD DAUGHTER FROM THE VEHICLE AND RAN AWAY WITH HER IN MY ARMS. A BYSTANDER PUT THE FIRE OUT WITH A NEARBY EXTINGUISHER. THE FIRE DEPARTMENT ARRIVED ON THE SCENE AFTER THE FIRE WAS OUT. THEY PRONOUNCED THE FIRE OUT AND MY VEHICLE WAS TOWED TO THE ISUZU DEALERSHIP FOR INSPECTION. I HAVE SEVERAL WITNESSES WHO SAID THEY HAVE NOT SEEN ANYTHING LIKE THIS BEFORE. THIS COULD BE A POSSIBLE STATIC FIRE.*AK

THE RIGHT FRONT TIRE BLEWOUT WHILE PARKED IN A PARKING LOT CAUSING DAMAGE TO THE TURN SIGNAL AND FENDER, SEVERAL DAYS LATER THE LEFT FRONT TIRE BLEWOUT WHILE STILL AT THE DEALER BEING REPAIRED CAUSING ADDITIONAL DAMAGE TO THE VEHICLE, THE CONSUMER REQUEST REIMBURSEMENT (GENERAL GRABBER ST TIRES P245-70R16). NLM

AT 40,000 MILES COOLANT FUMES COMMENCED TO COME INTO VEHICLE WHILE DRIVING. VEHICLE BEEN IN / OUT OF DEALER'S SHOP ON SEVEN OCCASIONS, AND MADE VARIOUS REPAIRS, BUT PROBLEM STILL REOCCURRING. *AK CONSUMER FIRST COMPLAINED OF AN ANTI-FREEZE SMELL IN ENGINE COMPARTMENT AND CAB, AN INDEPENDENT MECHANIC STATED THAT A HEAD GASKET HAD BLOWN, HOWEVER DEALER STATED NOTHING WAS WRONG, CONSUMER WENT TO ANOTHER DEALER WHO REPLACED HEAD GASKET, AFTER REPAIR CONSUMER COULD STILL SMELL ANTIFREEZE, IN OCTOBER DEALER FOUND A HOLE IN THE HEATER HOSE AND REPLACED IT, SMELL WAS STILL PRESENT SO CONSUMER HAD ENGINE STEAM CLEANED WHICH STILL DID NOT GET RID OF ODOR, THE ODORS WERE CAUSING CONSUMER'S FACE TO GET NUMB AND CAUSED HIM TO GET SLEEPY, FINALLY 2 ORINGS WERE FOUND LEAKING IN THE PLASTIC NECK OF THE CORE. TRANSMISSION FLUID LEAK WHEN AT IDLE, DEALER REPLACED 2 HOSE CLAMPS FOR COOLANT LINES. CRUISE CONTROL CUTS OUT AND ENGINE RACES WHEN GOING UPHILL. *SLC