2020 JEEP GLADIATOR Complaints

I was under the hood of my vehicle changing air/oil filters and oil yesterday. I noticed several wires had the insulation melted off. I found the ODI Resume Investigation: PE24024 for underhood vehicle fires regarding Jeep and thought this might be exactly what is being investigated. I took pictures. If this site doesn't allow uploading pictures I can be contacted for them.

The contact owns a 2020 Jeep Gladiator. The contact stated that the instrument cluster was inoperable. The vehicle was taken to the dealer, where it was diagnosed with internal failure of the instrument cluster. The dealer determined that instrument cluster needed to be replaced. The dealer informed the contact the vehicle could not be repaired under NHTSA Campaign Number: 24V652000 (Electrical System); because the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 58,000.

Driving on hwy at 55 miles per hours complete power loss. No engine no electrical. I was able to coast to stop but was not able to activate hazards . I had just had the aux battery for auto start stop replaced by lithia Jeep dealer in corpus Christi

The back up camera freezes and the radio freezes. It won’t turn off until you turn the jeep off and start it up again. The camera will stay frozen with a blue screen I have tons of documented videos but unfortunately this program won’t allow uploads of videos.

When cresting a hill the sun was suddenly shining brightly into the driver's eyes. When deploying the driver's side sun visor, the hinge broke, making the visor flop loosely down, not effectively blocking the sun, and causing driver distraction. When trying to find a repair remedy online, this appears to be a widespread and multi-year problem that the manufacturer is back-logged on the necessary repair parts. The defect is so widely known and spread, that an after market retailer has developed and is selling repair parts to address this manufacturers safety design defect.

Multiple issues occuring starting (documented) at 22,719 miles (09/27/2022) - stop/start and remote start had not been functioning properly - vehicle died. Required towing to dealer. Both batteries were dead. Upon leaving dealer they had not reconnected stop/start. Fast forward to 05/04/2024 and vehicle once again unchargeable to start. Took warrantied battery back to dealer and they wanted us to tow it there to check. We spent 350.91 to replace ourselves due to a lack of confidence with Jeep. Then on 05/20/2024 took it to a 4x4 center and discovered multiple issues with vehicle from manufacturing and dealer work. To start -- 1) the rear differential pinion seal is leaking 2) the power stearing box is aluminum and showed signs of flex and contact 3) dealer installed lift was incomplete leaving the front axle off center (visually observed about a 3" offset).

The factory sunroof on my 2020 Jeep Gladiator Rubicon detached at highway speeds. The springs that hold tension on the clamps that secure the soft top to the frame, unbeknownst to me at the time, lost tension. While travelling down the highway the soft top clamps loosened from a small bump and the wind caught the soft top itself. I immediately reacted, reached up, and tried to bring the soft top back down as I was frantically slowing down on the highway and merging right. The soft top ripped from my hand cutting it open and smashed into the rear of the vehicle. When the soft top smashed into the rear of the vehicle several hinges broke, luckily one was still holding the soft top from completely falling off. This obviously poses a very large safety risk as the soft top could have flown into another vehicle disabling it or much worse; causing injury or death. The problem has been reported by others through online forums and the consensus is that the springs inside the clamps weaken over time leading to this issue. The soft top was not inspected by the dealer or anyone else, they did not care to investigate. The dealer only replaced the soft top after more than a month of waiting for parts to arrive. I have informed Jeep Cares and Jeep Customer Care over the phone; however, they did not seem interested in actually fixing the issue. Jeep instead directed me the dealership only to have the soft top replaced. I am now following up with NHTSA regarding this issue as the other avenues have yielded no results. It should be noted that in my forum post I ended up paying more than the $500 deductible, there was constant confusion between the dealership and insurance, the invoice is attached. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on the interstate, driver and passenger sun visors has fallen out of the sun visor mount blocking/impairing road visibility. It is extremely dangerous when this happens at highway speeds as an individual may lose control on their vehicle.

The contact owns a 2020 Jeep Gladiator Overland. The contact stated while driving at various speeds, they would smell a burning odor coming from the clutch. The local dealer was contacted but the vehicle was not diagnosed or repaired. The contact stated the vehicle caught on fire after being driven for a while. The contact exited the vehicle and the fire department extinguished the flames. No injuries were sustained. A fire report and police report were filed however no information was not available. The contact stated the vehicle was towed to another dealer where it was diagnosed that the clutch needed to be replaced. The contact received notification of NHTSA Campaign Number: 23V116000 (Power Train) however when the vehicle was taken to a dealer, the contact was informed that the recall remedy was not available as of yet and did not perform an interim fix. The manufacturer was not notified of the failure. The failure mileage was approximately 12,000. VIN tool confirms parts not available.

Manual Transmission started slipping/malfunctioning related to overheating. Jeep dealership stated it was driver issue, and nothing else was wrong with manual trasmission. Dealer charged me $3500 to repair/replace transmission @ 35000 miles. Dealer refusedto cover repairs and repeatedly stated there was no issues with factory manual transmissions. Filed claim under Manufacturers website and nothing has been done. note: manual transmission was replaced with OEM manual transmission, and no recall work was performed. Replacement transmission is now showing signs of slippage due ti overheating.