2007 JEEP WRANGLER Complaints

MY COMPLAINT AND WARNING HAS TO DO WITH OUR 2007 JEEP WRANGLER UNLIMITED,SARAHA, 3.8 LITRE. WE HAD A PRE-MATURE ENGINE FAILURE IN OUR JEEP DUE TO IMPROPER ENGINE ASSEMBLY DURING MANUFACTURE OF THE ENGINE. THE ENGINE FAILURE WAS DUE TO THE PRESSURE RELIEF VALVE FOR THE ENGINE OIL BY-PASS VALVE BEING INSTALLED IN THE WRONG ORDER, CAUSING THE ENGINES OIL BEING ONLY PARTIALLY FILTERED. THIS NON-FILTERED OIL CAUSED THE ENGINE TO FAIL DUE TO THE DIRTY OIL PASSING THROUGH THE ENGINE AND CAUSING EXCESSIVE WEAR OF THE ENGINE. OUR ENGINE FAILED AT JUST OVER 43,000 MILES AND THE FAILURE COULD BE SUDDEN AND PUT ANYONE THAT HAS THIS ENGINE CONDITION AT RISK IF THE VEHICLE IS IN MOTION WHILE THE FAILURE OCCURS. I WANT TO BE ON RECORD BECAUSE I DO NOT WANT ANYONE TO BE INJURED OR WORSE LOSE THERE LIFE OVER SOMETHING AS SIMPLE AS WARNING THE PUBLIC OF THIS ISSUE FOUND IN OUR ENGINE, AND ALSO TO BE ON RECORD BECAUSE WHO KNOWS HOW MANY ENGINE WERE ASSEMBLED THIS WAY WHICH IN MY MIND SHOULD BE CONSIDERED POOR CRAFTSMANSHIP. TOTAL DETAILS, COST AND THE FULL EXTENT OF DAMAGED CAN BE EXTENDED TO ANYONE WHO NEEDS OR WANTS THIS INFORMATION, IF REQUESTED IN WRITING OR EMAIL. *TR

WHILE FILLING GAS TANK, OVERFLOWED JUST AFTER AUTOMATIC SHUTOFF DEVICE CLICKED SHUTTING OFF FUEL FLOW. THE TANK WAS JUST BELOW HALF FULL. THE OVERFLOW OUT THE FILLER TUBE OR THE SLOW RATE OF FILL (ODI # 10368063) SEEMS TO BE OCCURRING AT EVERY FILLUP NOW THAT I HAVE PAST 50,000 MILES ON THE SPEEDOMETER. THIS IS HAPPENING AT GAS STATIONS THAT I COMMONLY USE IN MY AREA AND NEVER HAD AN ISSUE. *TR

INTERMITANT SLIPPING OUT OF FIRST GEAR. DANGEROUS TO THE DRIVER AT INTERSECTIONS AND WHEN STARTING FROM A NUETRAL POSITION. *TR

WHEN FILLING GAS TANK TO FULL, FUEL OVERFLOWS AND SPILLS DOWN THE SIDE OF THE VEHICLE. THIS IS A POTENTIALLY DANGEROUS CONDITION. *TR

WHEN FILLING THE GAS TANK USING THE AUTO SHUTOFF ON THE PUMP HANDLE, THE GAS TANK SHOOTS GAS OUT ALL OVER JUST AFTER THE AUTO SHUTOFF CLICKS OFF. IT HAS SPRAYED ON ME AND THE GROUND AND THE VEHICLE. *TR

EVERY TIME I FILL UP GAS IN MY 2007 JEEP WRANGLER, THE TANK OVERFLOWS SPILLING GAS ALL OVER THE JEEP, THE GROUND, AND IF I'M CLOSE BY, ON MY CLOTHES AND SHOES. THIS ONLY HAPPENS IN MY JEEP AND AT ALL GAS STATIONS I FILL UP AT. *TR

EVERY TIME I REFUEL MY 2007 JEEP WRANGLER, FUEL SPILLS. WHEN THE TANK IS "FULL" THE GAS PUMP "KICKS" OFF AND FUEL GUSHES FROM FUEL FILLER... IT DOES NOT MATTER WHERE I GET FUEL OR HOW MUCH FUEL IS IN TANK WHEN I BEGIN FILLING... IT ALWAYS SPILLS... *TR

FUEL SPILL EVERY TIME IT IS FILLED. AS THE PUMP CLICKS OFF IT STARTS VENTING FUEL ON THE PERSON FILLING & ON THE GROUND.

WHILE FILLING FUEL TANK, AT ALMOST FULL OR FULL TANK, PUMP WILL SHUT OFF OR AUTO STOP, AND THEN FUEL WILL START TO SHOOT BACK OUT OF GAS FILLER AS ALMOST UNDER PRESSURE. SOMETIMES IT'S A FEW DROPS, BUT MORE OFTEN IT IS A LOT. IF YOUR NEARBY YOU WILL GET COVERED IN GAS, HAPPENS 4 OUT OF 5 TIMES WHILE FILLING UP NOW. I FEEL THIS COULD BE A SAFETY ISSUE AS MY JEEP AND ANYONE NEAR IT DURING FILL UP CAN END UP COVERED IN GAS

WHEN I REFUEL THE VEHICLE AND THE FUEL PUMP KICKS OFF THE GAS SPILLS BACK OUT OF THE VEHICLE. NOT JUST A LITTLE AMOUNT EITHER. IT LEAVES A GOOD SIZE PUDDLE THAT I HAVE TO GO IN A NOTIFY THE STORE. NOT TO MENTION THAT IT COVERS MY SHOES, HANDS, AND SOME TIMES CLOTHES. THIS SEEMS TO HAPPEN WHEN MY FUEL TANK IS VERY EMPTY. IT HAS HAPPENED SEVERAL TIMES AND AT SEVERAL DIFFERENT GAS STATIONS. *TR