KEYSTONE Complaints

WAS TRAVELING NORTH ON I 95 IN S.C. JUST NORTH OF EXIT 68. I WAS TRAVELING AT 55 MPH WHEN THE RIGHT REAR TRAILER TIRE BLEW DAMAGING THE SKIRTING AND POSSIBLY BENT THE AXLE ON MY MONTANA 5TH WHEEL TRAILER. THE TIRE WAS A GOODYEAR MARATHON ST235X80R16E. THE TIRE WAS MANUFACTURED IN CHINA, AND WASN'T EVEN 3 YEARS OLD. THE TIRES THAT ARE MADE IN CHINA HAVE BEEN NAMED CHINA BOMBS BECAUSE OF ALL THE TIRE FAILURES. HOPEFULLY THINGS CHANGE. *TR

TL* THE CONTACT OWNS A 2015 KEYSTONE MONTANA. WHILE INSPECTING THE VEHICLE, IT WAS DISCOVERED THAT THE CONNECTING RIVETS TO THE QUAD ENTRY STEPS WERE BENT AND CAUSED THE STEPS TO BECOME UNSTABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT WAS UNABLE TO DETERMINE IF THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V10200 (STRUCTURE). THE FAILURE MILEAGE WAS NOT AVAILABLE.

THE TIRES THAT THE KEYSTONE RV COMPANY PUTS ON THEIR FIFTH WHEEL TRAILERS ARE UNSAFE, AT APPROX. 2500 MILES AND 4 YEARS OLD I HAD A BLOW OUT ON I-35 . IT TORE UP MY TRAILER AND I FEEL THEY THEY ARE UNSAFE AND VERY DANGEROUS. *TR

THE ENTRY STEPS INTO MY FIFTH WHEEL TRAILER HAD A FAILURE. THE RIVET IN THE SECOND STEP FROM THE BOTTOM BROKE WHEN STEPPED ON, ALLOWING IT TO COLLAPSE ON ONE SIDE. I HAVE TEMPORARILY REPAIRED THE STEP WITH A BOLT. I ALSO CONTACTED KEYSTONE ON THE DATE OF THIS COMPLAINT ONLY TO BE TOLD MY VIN WAS NOT WITHIN THE RECALL SCOPE EVEN THOUGH THE STEP ASSEMBLY IS MADE BY HICKORY SPRINGS. *TR

MY RV HAS A SET OF FOLDING STEPS FOR ENTRY. THERE ARE 4 STEPS. THE TOP LEFT RIVET IS ALL BUT PULLED OUT. THEY ARE UNSAFE FOR USE, HAVE A LOT OF FLEX WHEN USED AND REQUIRE THE PLACEMENT OF CONCRETE BLOCKS UNDER THEM TO BE USED SAFELY. KEYSTONE HAS A RECALL ON QUAD STEPS. #15-224. MY DATE OF MANUFACTURE FALLS IN THE MIDDLE OF THE DATE RANGE OF THIS DEFECT RECALL. WHEN I CALLED KEYSTONE I AM TOLD THERE IS NO RECALL FOR MY VIN NUMBER. MY STEPS HAVE THE EXACT SAME DEFECT. KEYSTONE REFUSED ANY ASSISTANCE. PICTURES HERE: HTTP://I143.PHOTOBUCKET.COM/ALBUMS/R139/JLB27537/2014%20MONTANA%203150RL/14%20KEYSTONE%20MONTANA%20ENTRY%20STEPS%20001_ZPSM2CUV4QL.JPG HTTP://I143.PHOTOBUCKET.COM/ALBUMS/R139/JLB27537/2014%20MONTANA%203150RL/14%20KEYSTONE%20MONTANA%20ENTRY%20STEPS%20002_ZPSRHKP4F2Z.JPG. *TR

TIRE BLOW OUT. I WAS PULLING MY CAMPER AT 60 MPH, JUST N OF THE FLA LINE ON 1-95. THE ROAD TEMPERATURE WAS MODERATE. I CHECKED TIRE PRESSURE BEFORE LEAVING SAVANNAH, 80 PSI. THE TIRE HAD APPROXIMATELY 4500 MILES ON IT, IT WAS NOT WORN AND WAS IN GOOD SHAPE. THE TIRE BURST WITH A LOUD NOISE AND IMMEDIATELY DEFLATED. I HAD TO CHANGE THE TIRE ON THE SHOULDER OF THE ROAD. WE REPLACED THE TIRE IN JAX FLA. THE TECHNICIAN EXAMINED THE TIRE AND SAID HE HAD NO CLUE WHY IT FAILED. I AM TIRED OF TRAILER TIRES BLOWING OUT. I HAVE HAD THREE TIRE FAILURES ON MY BOAT TRAILER/ CAMPER OVER THE LAST 5 YEARS AND IT IS DANGEROUS. IS THERE A SAFE TRAILER TIRE ON THE MARKET? I PLAN TO START REPORTING THESE FROM NOW ON. THE CAMPER MANUFACTURER NOR THE TIRE MANUFACTURER WILL EVEN LISTEN TO COMPLAINTS. I LEFT THE TIRE WITH DISCOUNT TIRE IN JAX. *TR

I HAVE A 2004 KEYSTONE TRAVEL TRAILER. THE REFRIGERATOR HAS A RECALL FROM DOMETIC. THE RECALL IS TO PREVENT FIRES IF THE REFRIGERATOR LEAKS FLAMMABLE COOLANT INTO THE PROPANE FLAME. MY COOLER HAS STARTED TO LEAK AND IS NO LONGER SAFE TO USE. DOMETIC WILL NOT REPLACE THE FAULTY COOLER. THEIR SOLUTION TO THE PROBLEM (LEAKING COOLERS) IS TO INSTALL A SWITCH THAT TURNS THE FRIDGE OFF IN CASE OF A LEAK. IT DOES NOT FIX THE REAL PROBLEM (THE FAULTY COOLER). THEY WILL NOT EVEN ALLOW ME TO HAVE THE KIT PUT ON UNTIL I PURCHASE A NEW COOLER. PLEASE HELP ME RESOLVE THIS ISSUE WITH DOMETIC. I FEEL THAT DOMETIC NEEDS TO REPLACE THE FAULTY PART. THANKS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WITHIN 3 MONTHS OF PURCHASING A NEW KEYSTONE MONTANA 5TH WHEEL THE REAR FIRE EMERGENCY WINDOW LATCH BROKE. IN ORDER TO CONTINUE USING THE 5TH WHEEL THE WINDOW HAD TO BE SECURED SHUT WITH WIRE TIES. THIS EMERGENCY WINDOW IS ONE OF ONLY THREE FIRE EXITS FROM THE TRAILER. IT IS THE ONLY FIRE EXIT IN THE REAR EXTRA LIVING QUARTERS. IT HAS BEEN OVER A YEAR WITH THIS PART ON "BACK ORDER". NOW I AM TOLD THEY NO LONGER PRODUCE THIS PART AND KEYSTONE RV DOES NOT SEEM TO WANT TO FIX IT AT ALL. I HAVE READ ON THE INTERNET THAT THERE ARE HUNDREDS AND HUNDREDS OF THESE FAULTY EMERGENCY WINDOW LATCHES THAT HAVE BROKEN AND ARE NOT BEING FIXED BY KEYSTONE RV. SOMEONE WILL EVENTUALLY DIE IN A FIRE IF THIS ISSUE IS NOT ADDRESSED! *TR

WHILE SITTING STILL THE REAR EMERGENCY WINDOW LATCH BROKE. CAUSING THE WINDOW TO OPEN. ALLOWING WIND, RAIN, DIRT, DUST TO ENTER THE RV. I CONTACTED KEYSTONE RV AND ASKED FOR ASSISTANCE. THEY REPLIED THEY PROVIDED NO RETAIL CUSTOMERS PARTS ASSISTANCE. I THEN CONTACTED RON HOOVER RV, DONNA, TX. THE PARTS MANAGER HAS TRIED FOR OVER 10 MONTHS TO OBTAIN A REPLACEMENT LATCH. I AM TOLD THE PART I NEED IS NO LONGER AVAILABLE ON A RV THAT IS ABOUT A YEAR OLD. I HAVE HAD TO SECURE THE WINDOW WITH PLASTIC TYE STRAPS AND A LARGE WOODED PENCIL. HTTP://I143.PHOTOBUCKET.COM/ALBUMS/R139/JLB27537/MONTANA%20WINDOW%20LATCH/EMERGENCYWINDOWFIX001_ZPS8ACAAA1B.JPG HTTP://I143.PHOTOBUCKET.COM/ALBUMS/R139/JLB27537/MONTANA%20WINDOW%20LATCH/MONTANA%20REAR%20WINDOW%20LATCH%20002_ZPSMKB9M6LU.JPG. *TR

THE FRESH WATER TANK SUPPORT BRACKETS AND SECURING 3/8 SELF-DRILLING ? TO 1? TAP SCREWS FAILED. ALL (5) BRACKETS FAILED. ONLY (2) TAP SCREWS ON ONE END OF THE (2) OUTBOARD BRACKETS REMAINED INSTALLED. THOSE SCREWS WERE BACKED OFF A TIGHTENED POSITION BY APPROXIMATELY 1/8? TO 1/4? POSITION. THREE (3) SUPPORT CHANNEL BRACKETS ARE BENT IN THE MIDDLE TO A PERMANENT POSITION BY A 2 1/2" TO 3? DROP IN THE CENTER. THE (2) SUPPORT BRACKETS AT BOTH ENDS OF THE TANK SUPPORT SYSTEM DIPPED MARGINALLY.THE BOTTOM OF THE FRESH WATER TANK IS PERMANENTLY DISTORTED ON THE BOTTOM BY APPROXIMATELY A 3? DIP. THE BRACKETS ARE MADE OF 1/16 THICK STEEL CHANNEL SPANNING A DISTANCE OF 60 5/8.? THE BRACKETS & MOUNTING SCREWS ARE NOT SUBSTANTIAL ENOUGH TO SUPPORT A LOAD MAX OF 830 LBS. OR LESS IN EITHER A STATIONARY OR ON THE ROAD CONDITION AS ILLUSTRATED BY THE FAILURE. THERE ARE NO WARNINGS IN THE KEYSTONE OWNER?S MANUAL THAT ADVISE THE OWNER THAT THE RV SHOULD NOT BE PLACED IN MOTION WITH A PARTIALLY FULL OR FULL TANK OF FRESH WATER. ON OCCASION, WHEN TRAVELING, THE FRESH WATER TANK HAS BEEN PARTIALLY FILLED TO BETWEEN THE 1/3 AND 2/3 WATER LEVEL AS NOTED ON THE WATER TANK MONITOR PANEL. HOWEVER, THE MOST CONCERNING SITUATION WOULD BE A CATASTROPHIC FRESH WATER TANK SUPPORT SYSTEM FAILURE WITH THE RV IN MOTION, A TANK OF WATER BREACHING THE UNDERCARRIAGE COVER, (SEE OTHER COMPLAINT FILED 7/29/13), THAT COULD RESULT IN COLLATERAL DAMAGE TO ANOTHER VEHICLE OR PERSON. KEYSTONE CLAIMS THAT THE SUPPORT SYSTEM FAILED DUE TO OVER FILLING THE WATER TANK. IF KEYSTONE BELIEVES IT IS POSSIBLE TO OVER FILL THE FRESH WATER TANK, KEYSTONE SHOULD HAVE DESIGNED A TANK THAT WOULD PREVENT THE POSSIBILITY OF OVER FILLING THE FRESH WATER TANK, I.E. PRESSURE RELIEF PLUG ON THE TANK OR AN OVERFLOW DRAIN LINE, ETC. I AM THE FIRST AND CURRENT OWNER/OPERATOR OF THIS RECREATIONAL VEHICLE (RV). PICTURES AVAILABLE. *TR