KIA Complaints

The contact owned a 2019 Kia Optima. The contact stated that while her daughter was driving at 60 MPH, she noticed there was smoke emerging from the engine. The driver pulled over safely. but was alerted by a good Samaritan who ran across four lanes of traffic to extinguish the fire with a fire extinguisher to no avail. The fire department was on the scene to eventually extinguish the fire. There were no reported injuries. The vehicle was towed to a towing lot. The local dealer was called, but there was no response. The contact called another local dealer: 4747 S Yale Ave, Tulsa, OK 74135, but there was no answer. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was approximately 133,000. The vehicle was deemed a total loss by the insurance company.

While driving the entire car goes black kind of like you just turned it off. It has only happened at night time. The dash screen completely turns off and the headlights will go off. When it comes back on the dash has several lights on it such as the seatbelt is unbuckled (when I’m buckled), and other warning lights. This has been happening since September 2025. I take it to the dealership and they can’t seem to find anything wrong with it, and told me they “can’t do anything until the part completely fails” it’s creates a severe safety hazard since it only happens at night and the headlights also go off.

The vehicle experienced a sudden loss of drive power and entered a 'fail-safe' mode with check engine light, warning chimes and service vehicle warning message. A diagnostic scan revealed fault codes P1C2D03 (High Pressure Electric Oil Pump Motor Position Sensor), P193B79 (High Pressure Electric Oil Pump Performance), and P086800 (Transmission Fluid Pressure Low). These three specific codes are cited in Kia Recall SC250 (NHTSA 22V760) and associated technical bulletins as evidence of an internal electric oil pump failure requiring full transmission replacement. The safety of occupants was compromised by the sudden loss of motive power on the interstate. I presented these codes to Value Kia 6915 Essington Ave, Philadelphia, PA 19153 and dropped my car off on 4/7/2026. The dealer stated the safety recall was 'closed' and that the vehicle was 'out of warranty' due to its 95,000 miles and second-owner status. They would only agree to perform a diagnostic at my personal cost. The vehicle has been at the dealership for two days without an inspection report being provided to me. I have contacted Kia Corporate Consumer Assistance (Awaiting Response) and am filing this report because the vehicle is exhibiting the exact safety defect and 'triple-threat' fault codes of SC250 but is being denied a free safety remedy by the authorized dealer due to mileage and second ownership. As of 4/9/2026, the vehicle has been at the dealership for 2 days. Despite signing an authorization for a $190 diagnostic fee, the dealership has been completely silent and has not provided a status update or the diagnostic report. I am being left without transportation while the dealer fails to address a documented safety defect.

While driving on a highway at approximately 50 mph, the vehicle suddenly lost acceleration without warning and was unable to exceed approximately 10–15 mph. This created a dangerous situation requiring immediate maneuvering across multiple lanes of traffic to reach safety. At the time of the incident, the check engine light was illuminated. Diagnostic trouble codes P0191, P2177, and P2179 were later identified, indicating fuel pressure irregularities and air/fuel imbalance. The vehicle was inspected by a dealership, which diagnosed a purge valve vacuum leak and faulty high-pressure fuel system components. The repair required replacement of the purge valve and high-pressure fuel system components. The failure involved components within the fuel/propulsion system and engine systems, which are controlled in part by the electronic control module (ECM). This resulted in a sudden and unexpected loss of propulsion while driving at highway speed. Prior to the incident, there were issues with refueling, including difficulty filling the fuel tank when near empty, indicating a potential developing issue within the fuel system. This condition created a significant safety risk due to the sudden and unexpected loss of vehicle speed in active highway traffic, increasing the risk of collision.

The contact owns a 2013 Kia Forte. The contact stated that while driving 45 MPH, the check engine warning light illuminated, and the vehicle went into LIMP Mode. The contact stated the vehicle was unable to exceed 20 MPH. The vehicle was taken to an independent mechanic, and the knock sensor was replaced as a temporary fix. The failure reoccurred 2 days later. The contact received notification of NHTSA Campaign Number: 20V750000 (Engine); however, an unknown dealer attempted to charge the contact to replace the engine, even though the recall notification stated that the engine would be replaced as needed, free of charge. The manufacturer was made aware of the issue but declined the service request. No further information was available. The failure mileage was approximately 115,000.

Mi carro hay veces que prende la luz de la engine, lo lleve a checar y salió en la computadora que era un problema de Power Train system, que era secondary DTCs P1C28 Y P1C28000, lo busque en Google y salía que era un problema muy recurrente en Kias souls y sorentos. Que podría causar incendios

Complaint Summary: Post recall catalytic converter failure on 2016 Kia Soul with 1.6L GDI engine (SC176 recall previously performed). Complaint Details: I own a 2016 Kia Soul equipped with the 1.6 liter Gamma GDI engine (engine code G4FD, emissions family GKMXV01.6DBE). This engine is part of Kia’s SC176 recall for catalytic converter overheating and thermal damage. My dealer performed the SC176 ECU software update in May 2019, but did not replace the catalytic converter at that time because the P0420 code had not yet appeared. In early 2026, my catalytic converter failed with a P0420 “Catalyst Efficiency Below Threshold” code. My mechanic confirmed the converter was internally damaged. This failure is consistent with the known SC176 defect, where converters can be partially damaged before the ECU update and fail later. Kia and the dealer refused to replace the converter under the recall, stating that because the P0420 code did not appear in 2019, the converter is no longer covered. I was forced to pay $2,781.91 out of pocket for a new catalytic converter, exhaust manifold, and oxygen sensors. The diagnostic test was another $120 plus tax. This appears to be a case where the converter was already compromised by the SC176 defect prior to the software update, but the failure occurred later. I am requesting that NHTSA document this issue, as it suggests the recall remedy may not fully address pre existing catalyst damage and may leave owners with significant repair costs. VIN: [XXX] Mileage at failure: ~90,000 miles Engine: 1.6L Gamma GDI (G4FD) Recall: SC176 (ECU update performed, converter not replaced) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Kia Soul. The contact stated that while driving approximately 80 MPH, the vehicle unexpectedly stalled, with the check engine warning light illuminated. The vehicle was restarted; however, the failure reoccurred. The contact stated that while driving uphill, the vehicle failed to accelerate as needed. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and case was opened. The approximate failure mileage was 41,000. The VIN was not available.

The information cluster behind the steering wheel is not turning on. Started all of a sudden. Can’t show speed, none of the advance driving features are working , and not showing gas level.

My [XXX] daughter was a passenger in a vehicle involved in a crash in which the vehicle struck a tree and a fire was present. She was unable to exit the vehicle and did not receive medical attention in time. Public records indicate the vehicle had an open federal safety recall at the time, listed as incomplete. I am submitting this information for awareness and review. I am not making any conclusions regarding causation. However, I believe it is important that incidents involving vehicle fires and open recalls are documented and evaluated to help protect other families. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)