KIA Complaints

My vehicle’s white exterior paint and clear coat are delaminating and peeling off in pieces while driving. Loose paint pieces fly off the vehicle, creating a potential road hazard for other drivers. The defect affects the hood, the front, and the area above the windshield. The vehicle is available for inspection upon request. The paint delamination has been visually confirmed and is worsening over time. I have contacted Kia customer service multiple times by phone and email requesting repair or resolution. Kia has not responded or offered any remedy. The defect has not been inspected by the dealer as Kia declined to address it. No warning lamps or messages are applicable to this defect. The peeling first became noticeable approximately June 1st, 2026 and has progressively worsened since.

The contact owns a 2018 Kia Soul. The contact stated that while driving at 45 MPH, the vehicle stalled and jerked while accelerating and experienced severe jerking while decelerating. The failure had occurred on several occasions. On June 18, 2024, the vehicle failed to accelerate or shift properly. On January 15, 2025, the vehicle shuddered violently and nearly stalled. On April 14, 2026, the vehicle was jerking, and the transmission shifted gears improperly. The vehicle was taken to a dealer, and observed that the vehicle was consuming oil excessively. The dealer replaced the spark plugs and performed an induction cleaning and transmission valve service. The dealer was unable to duplicate the failure after a 36-mile test drive, after the service. From May 27 to May 29, 2026, the vehicle failed to start and was towed to the dealer again, where a new short-block engine assembly was installed. On June 2, 2026, a technician discovered that there was no oil in the engine, resulting in a critical crankshaft failure code. Despite the short block replacement and oil correction, the powertrain failures persisted, and the vehicle failed to exceed 50 MPH. The vehicle violently stalled and jerked while accelerating and decelerating, creating a safety hazard. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 92,573.

The contact owns a 2018 Kia Optima. The contact stated that while driving at an undisclosed speed, there was an abnormal odor and a knocking sound coming from the engine. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the issue. The vehicle was not repaired. The issue persisted. The contact stated that the vehicle was later returned to the dealer to be repaired under a service campaign involving the engine control unit (ECU). Shortly after the vehicle was repaired, the ECU failure message was displayed. The vehicle subsequently became inoperable. The vehicle was not repaired. The manufacturer was notified of the issue. The approximate failure mileage was 1,500.

My car is a 2019 KIA Niro Hybrid. It's only 7 years old, and my husband and I have been the only owners. It only has 61,000 miles on it, and it is serviced regularly and has to pass a state emissions test each year. As I was driving the other day, the dashboard lit up with critical alerts saying "check regenerative battery" and the braking system went completely soft; I could not stop the car using the brakes. It was terrifying. I had to pull off the road and use the emergency brake to stop the car. This was an awful incident that could have resulted in deaths or serious injuries. Again this is for a car that is well-maintained and well under 100,000 miles.

The contact owns a 2016 Kia Soul. The contact stated that while his wife was driving 35 MPH, the brakes became inoperable. The contact’s husband, who is an independent mechanic, inspected the vehicle and became aware that the brake fluid lines were rusted and ruptured underneath the middle of the vehicle. The contact stated that brake fluid was added but the brake pedal was mushy while depressed. The brake warning light was illuminated after the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 40,000.

The contact owns a 2025 Kia Telluride. The contact stated that while driving at an undisclosed speed, there was a loud sound coming from the sunroof glass before the glass shattered. There was no impact on the sunroof glass to cause the failure. Small glass fragments fell into the second and third row seats. The vehicle was taken to the dealer; however, the vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 22,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle is a 2016 Kia Soul 1.6L GDI with approximately 83,000 miles. The vehicle experienced engine performance issues, loss of power, and stalling. A Kia dealership diagnosed a failed/melted catalytic converter and reported metal shavings in the engine oil. The vehicle has not been repaired and is available for inspection upon request. How was your safety or the safety of others put at risk? The vehicle stalls and loses power, creating a safety hazard while driving in traffic. A sudden loss of power increases the risk of being struck by another vehicle and makes it difficult to safely maintain speed, merge, or cross intersections. Because the vehicle is unreliable and may stall unexpectedly, I do not consider it safe to operate. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The condition was confirmed by an authorized Kia dealership. The dealership diagnosed a clogged/melted catalytic converter and reported metal shavings in the engine oil. The dealership advised that the catalytic converter must be replaced before they would perform further engine diagnosis. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle was inspected by an authorized Kia dealership. Kia Customer Care was notified of the issue and reviewed the claim but declined assistance. To my knowledge, the vehicle has not been inspected by a Kia field engineer, police agency, or insurance investigator. Were there any warning lamps, messages, or other symptoms prior to the failure, and when did they first appear? Yes. The vehicle experienced drivability issues, loss of power, and check engine light illumination. Diagnostic trouble codes reported included P0420, P2191, and P2196. The symptoms progressively worsened and eventually resulted in severe performance issues and stalling.

While driving my 2015 Kia Optima, the engine failed completely without warning. The vehicle lost power while in motion approximately 300 miles away from my home. All warning lights illuminated and the car shut down during driving conditions, creating a serious safety hazard. The vehicle was towed to a Kia dealership where it was inspected. I was informed the engine has failed and may be related to the known 2.4L engine defect and prior recall campaign involving this engine type. This vehicle has a history of multiple recalls, including engine-related recalls issued in 2018 for the same engine family. The failure occurred suddenly and without prior adequate warning, and the vehicle is now inoperable. I purchased the vehicle in May 2023, and at the time of failure it had approximately 133,000 miles. The engine began knocking loudly prior to failure, then stalled and shut off completely while driving. This incident placed me and others at risk because the vehicle lost propulsion while in traffic. I believe this may be related to a known manufacturing defect in Kia 2.4L engines that has been the subject of recall and/or investigation. I am requesting that this complaint be documented as a safety-related engine failure potentially associated with the existing recall and that it be reviewed for further investigation and manufacturer accountability

The contact owns a 2016 Kia Optima. The contact stated that while driving 10 MPH, the front driver’s and passenger’s side windows lowered unintendedly. Neither the dealer nor an independent was contacted. The vehicle was not taken to the dealer or an independent mechanic to be diagnosed. The rear driver’s and passenger’s side windows were replaced, and the vehicle was repaired. The manufacturer was notified of the failure but offered no assistance since the VIN was not under recall. The failure mileage was 107,000.

The contact owns a 2016 Kia Sorento. The contact stated that after the vehicle was parked and turned off for approximately an hour, the vehicle was restarted and there was a knocking sound coming from the engine compartment. The contact continued driving and the knocking sound increasing in volume and frequency. There were no warning lights illuminated. The vehicle was taken to a certified mechanic and was diagnosed with engine failure. The contact was informed that the engine needed to be repaired. The mechanic referred the contact to the dealer for assistance. The vehicle was taken to the dealer and the contact was informed that since the vehicle was not repaired under NHTSA Campaign Number: 22V703000 (Trailer Hitches); the dealer was unable to repair the engine ffailure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.