2018 LINCOLN MKC Complaints

I am writing regarding my 2018 Lincoln MKC, VIN # [XXX] which is experiencing clear symptoms of coolant intrusion into the cylinders. These include low coolant levels, white exhaust smoke, engine misfires, and a rough-running condition. According to **Technical Service Bulletin 19-2346** (NHTSA ID 10169807, dated December 20, 2019), this issue is a known defect affecting MKC models with the 2.0L EcoBoost engine and recommends replacement of the long-block assembly to correct the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Kirk Brothers ford supposedlly put a new engine in my vehicle. I've had issues with it ever since they supposedly put the engine in. I had another mechanic just look at it on 14AUG25 and he informed me that the engine was shot.

I have a 2018 Lincoln MKC with the well known coolant intrusion complete engine failure. I need a new long block at a cost of 9500 dollars. I had no warning light or check engine light to warn me about this issue prior to taking it to Ford dealer in Buellton to ask why coolant was emptying so fast. I had previously taken it to Lincoln dealer while under warranty and was told no issues. Even though they had a specific service bulletin stating the problems I was having. I feel my safety was at risk because I drive alone into sketchy areas for my job and my car could have just stopped and I would be an elderly woman alone with a broken down car waiting for a tow. It also could have possibly caught on fire I’m told. Lincoln Concierge was no help. Said it was VIN specific and not enough vehicles affected to warrant a recall. Mechanic at Ford says 3 to 4 vehicles a month are being repaired at his shop and they are a rural dealership. I think we are all being fleeced. We spent 40000 plus for a luxury reliable vehicle. We still have car payments. Can’t use as trade in. Can’t afford to buy another car. I can’t do my job. The stress alone may be dangerous for my health. Pending lawsuit won’t begin until June of 2026. This is so wrong

Coolant is leaking into the cylinders and could cause the engine to seize while driving. The issue was identified at a Ford dealership and is a known issue on this engine and has been admitted by Ford/Lincoln as a problem. The only warning was a check engine light which appeared after the problem existed and only fix is to replace the engine. Ford/Lincoln did not make any attempts to notify owners in advance of this issue so it could be checked. There are still many of these engines on the road which could seize at any time and cause tragic results.

The contact owned a 2018 Lincoln MKC. The contact stated while attempting to start the vehicle, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to a dealer where it was diagnosed coolant intrusion into the engine and that the engine needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was traded. The manufacturer was notified of the failure, and informed the contact that the VIN was not under recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 57,000.

Dealer service technician states the a crack in the engine block is allowing coolant to enter the cylinder causing misfiring. This appears to require engine replacement with only 59000 miles on the vehicle. This is a common problem with the 2018 engine and could result in a fire.

I have a 2018 Lincoln MKC with approximately 58,000 miles, always taken care of and maintained, in excellent condition. Almost immediately after my extended warranty ran out the check engine light came on and it started to start and idle rough. Took it to a Lincoln dealer, they replaced coil assembly # 4 and the 4 spark plugs, told me if it continues there might be coolant intrusion to the engine and the engine would need to be replaced. Check engine light came on 2 days later again, back to the dealership where they told me there was coolant intrusion and the engine will need to replaced. $8020.00 estimate, Lincoln/Ford is aware of this defect in this engine, they should recall this engine and replace it.

Check engine light came on at approx 54,000 miles with code of cylinder 2 misfire diagnosed as spark plugs and ignition coils need replaced. All spark plugs and ignition coils replaced May 11. June 23 check engine light on again with cylinder 2 misfire. Was told spark plugs and ignition coils need replaced again. July 9 spark plugs and ignitiion coils replaced. July 10 check engine light came on cylinder 2 misfire. July 11 car was diagnosed as needing engine replacement due to coolant intrusion causing rust in engine

Loosing Coolant resulting in coolant leaking into the engine. White smoke coming from exhaust m. Repair garage states only fix is to replace with revised engine causing over $10,000 in repair costs.

The contact owns a 2018 Lincoln MKC. The contact stated that when the vehicle was cold-started, the vehicle shuddered, shook abnormally, and idled roughly. The contact stated that the check engine warning light was illuminated. The contact stated that the vehicle was still running rough after the engine had reached normal operating temperatures. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that there was coolant intrusion into the cylinders, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.