2011 LINCOLN MKZ Complaints

2011 Lincoln MKZ AWD, 25000 miles. The plastic sheath that covers the transmission shift cable split in two. The split is located on the cable between the engine and firewall. preventing the driver from being able to shift the automatic transmission into Park and then later could no longer shift into any gear position. The metal cable and braid remained intact.

The contact owns a 2011 Lincoln MKZ. The contact's spouse stated that while the vehicle was parked, the contact's spouse started the vehicle and noticed flames coming from the interior seal of the driver's door, located by the rocker panel. The contact's spouse stated that the flames were not severe. The contact’s spouse was able to extinguish the fire. The contact stated that after inspecting the vehicle, the contact noticed moisture leaking into the rocker panel wiring. The vehicle was taken to an independent mechanic for brake and rotor repair. The contact and the mechanic noticed that the whole rear of the vehicle was severely corroded. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

The contact owns a 2011 Lincoln MKZ Hybrid. The contact stated while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. The EPS warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the steering rack. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V340000 (Steering), but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 130,000.

The contact owns a 2011 Lincoln MKZ Hybrid. The contact stated that while driving at 45 MPH, the brake service warning light illuminated. The contact used excessive force on the brake pedal and the brake pedal was depressed to the floorboard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 168,258.

While traveling on interstate at70 mph a red triangle appears on dash engine turns off warning on dash to stop asap. All you have is electrical power which is not much. Car needs to be turned off and restarted. This may occur again in a few minutes or not. Took to dealer they said they replaced an O2 sensor. It still turns off. Back to dealer. They can’t reproduce. Has happened to me at least 8 times on surface streets and highways. Extremely dangerous to loose power on highways. This started about 6 months ago. Still happening. Last incident was today

As I was traveling home from work, I noticed the car jerk slightly and immediately decelerate. The engine temperature gauge light came on the dash and the temperature gauge immediately moved to the “H” position on the dash. Due to the fact that I was in rush hour traffic on the highway, I was worried I wouldn’t have enough speed to get to the median. I turned on my hazards and coasted safely to the side of the road but was nearly ran over by other vehicles not realizing the issue I was having. I was unable to accelerate out of the way and at the mercy of other drivers being courteous and give me space to move. I turned the car off and looked under the hood locating the coolant reservoir. It appeared empty. I was able to get a ride to the nearest auto parts store and buy coolant. When I returned to my car, I emptied coolant into the reservoir and cranked the vehicle. Within a minute the gauge returned to normal temp and carefully got back in flow of traffic but stayed close to the emergency lane. Within a couple hundred yards of driving again, the lights and gauges indicated another overheating issue. At the next stop, I pulled into a gas station. And parked the car to have it towed. My mechanic informed me that the coolant was leaking from the coolant pump into my oil pan. Now the engine is flooded with a mixture of oil and coolant and I will need a new engine. He said this issue has been reported before but wasn’t sure what Ford/Lincoln may be doing about it. I’m lucky I didn’t have an engine fire or some sort of collision while driving along a highway during rush hour traffic.

The contact owns a 2011 Lincoln MKZ. The contact stated that while driving at an undisclosed speed, there was a knocking sound coming from the front of the vehicle. The contact stated on another occasion while driving at an undisclosed speed, the engine overheated. The vehicle was taken to the dealer where it was diagnosed; however, the cause of the failure was not yet determined. The contact was informed that it might have been an axle leak. The contact then took the vehicle to an independent mechanic who in turn advised her to take the vehicle to a dealer. The contact had the vehicle towed to the dealer, where it was diagnosed with water pump failure. The contact was informed that the water pump needed to be replaced. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

I was stopping at a stop sign and was unable to stop immediately, instead I coasted a little bit before stopping. Then the brake warning lights and ABS and traction lights came on. I pulled over to a parking lot and turned the car off and turned it back on: all the lights came back on. I put on my flashers and very carefully and slowly drove my car to Jiffy Lube. They did an $108 oil change and checked the brake pads and brake fluid levels and said everything was fine and I would need to take it to a larger shop. I contacted the Apple Ford dealer near me and had my family follow me as I dropped it off. They said it would be a total of $310 for diagnostic and brake flush. I did the flush and it didn’t work. They said it would cost just shy of $3k to replace the entire hydraulic system. I took the car home because that is too much for a 2011 vehicle. I ended up having to get a new car because I need transportation for me and my two young children. My neighbor took a look at the car (he works on trucks) and the battery wouldn’t work. I bought a new battery for the car at $238.14. The lights are still on. I would like to have this car fixed or be able to trade it in. I am now being recommended to run a computer test on it to reset the codes. I would like to have this fixed as this seems to be a known issue with this car and I could have crashed if I wasn’t already driving slowly.

I was driving home in rush hour traffic at approximately 50 mph. I tried to brake but the pedal went to the floor and I had no brakes at all. Turns out this was a recall issue for the same issue for the previous four years MKZs. Replacing the fluid did not fix the problem and the 2,000 dollars charged for just the module that controls this is disgraceful. That doesn't include the other thousand for a mechanic to install the part. I managed to avoid hitting anyone, but not by much. This is extremely dangerous and should be addressed

The tire is a NEXEN 225/45R18 After driving at highway speed on an out-of-town trip for several hours, got off the highway on the way to the hotel using suburban roads. About a mile later, a noise suddenly started at the driver's side front. The "slapping noise" got worse as the car went faster. I pulled off into a parking lot and found a steel bead from the tire had come loose and was hitting the inside fender well. I also noticed there were cracks in the side wall. I changed the tire using the spare tire and drove to the hotel. The next day, I went to a local tire dealer to buy replacement tires. Since the car is an All Wheel Drive vehicle, I had to replace all four tires. And, it is a good thing I did since when I inspected the old tires, the other front tire (the passenger side) had side wall cracks worse than the driver's side tire that had the bead separation. The two rear tires showed no evident side wall cracks. I kept the two front tires with the failures and one of the rear tires that did not have any evident cracks. There was not enough room in the car to bring all four tires back home. Attached are photographs of the two failed tires. NOTE: I am a former Director of the Office of Defects Investigation [XXX] ) and this is my wife's car. I brought the tires back with me since I believe ODI may want to have the tires in the event it believes a PE is appropriate. The tires are in my garage in Northern Virginia. The email and phone number are mine, not my wife's. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)