MAZDA Complaints

We purchased a certified pre-owned Mazda CX-5 from Wellesley Mazda in [XXX] on XXX. As soon as we got home and tried to exit the vehicle, we noticed that the driver's seatbelt was not releasing. Since then, we have noticed that the seat belt has not latched or unlatched properly. Our concern is that a manufacturer-certified vehicle was delivered to a consumer with an intermittently failing primary locking restraint mechanism. There should have been a 160-point inspection done before this car was delivered in order for it to be considered pre-owned. This car is driven by our son who has been put at risk by a faulty restraint device. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Mazda CX-90. The contact stated that while turning the steering wheel to the left, the steering wheel became stuck momentarily and experienced resistance while attempting to return the steering wheel to center. The contact stated that additional force was needed to return the steering wheel to center. The vehicle was taken to the local dealer, who diagnosed the vehicle and determined that the steering rack and pinion were inoperable and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not contacted about the failure. The failure mileage was 36,000.

I was driving my 2026 Mazda CX-30 in a parking lot and was pulling into a parking space at a very low speed. I lightly pressed the accelerator to move the car forward, but the car suddenly surged forward much faster than I intended or expected based on how lightly I had pressed the pedal. The sudden acceleration resulted in a collision and property damage. There were no warning lights, warning messages, or other dashboard alerts before or at the time of the incident. I do not know what specifically caused the car to accelerate this way. I am concerned that there may have been an issue with the accelerator/throttle response, engine controls, transmission, PCM, or another part of the powertrain. The vehicle has not yet been inspected by Mazda or an independent engineer specifically for this issue, so the cause has not been determined. It is currently as a collision center. Before the accident, I had also noticed that the vehicle's acceleration and pickup sometimes did not feel normal, although there were no warning lights or messages indicating a problem. I am reporting this because the car's unexpected acceleration at such a low speed created a serious safety concern. I would like the incident and vehicle to be investigated to determine whether a defect or malfunction contributed to the sudden acceleration. The vehicle is available for inspection.

Reporting Product Defect in Mazda Vehicles I am writing to bring to your attention a recurring design flaw affecting current Mazda vehicles, including models such as CX30, MX30, and potentially the Mazda3 series. Following heavy rain or high humidity conditions, there is a consistent issue with the tire pressure sensor alarming and the smart key being unable to unlock the car doors. I have checked my key fob battery, RF function, car battery - none of these are the root cause. Despite consulting local dealerships and various Mazda forums, no one seems to have a definitive solution to this problem. Therefore, I am reaching out to report the existence of this product defect. This issue appears to be more prevalent during summer in Arizona - after the thunderstorms, this issue came up every time. Even with the heat here, it takes from several hours to 2 days for the affected part to dry out and function again.

The contact owns a 2024 Mazda CX-90. The contact stated that while driving around a long curve, the steering wheel started sticking, requiring the contact to return the steering wheel to center. No warning lights were illuminated. Upon research, the contact associated the failure with NHTSA Campaign Number: 24V022000 (Steering); however, the VIN was not included. The local dealer was contacted and confirmed that there was no recall or warranty coverage associated with the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 60,000.

Driving down the freeway, the car throws an error code, reduces speed from 75 to 40 in seconds, with enough time to pull off the freeway. The car has an error code stating "Hybrid battery malfunction." Now the car will not start. The Dealer could not get it started and now wants to charge me for a diagnostic. But from my understanding, they should cover a new battery under EPA regulations (40 CFR Part 85). Any help would be greatly appreciated.

I purchased the vehicle used. The issue I have been having is the steering feels sticky, heavy, or briefly resistant when turning. It is very prominent when turning the steering wheel to the left, especially going around corners and rotaries, but even bends in the road. When trying to straighten out after the turn, I have to jerk the steering wheel back to the other direction. This becomes a control issue to keep within my lane. Driving straight the issue is present as the steering doesn’t self-center smoothly. The issue happens once the car is "warmed up" - if I started cold in the morning, it is not present, but within a few minutes of driving the steering effort changes unexpectedly. The issue has been ongoing since March 2026.

I am filing this complaint regarding a serious steering safety issue with my 2024 Mazda CX-90, which I purchased on March 24, 2026, with approximately 40,000 miles. The vehicle previously underwent Mazda Safety Recall 6524A involving the steering system and increased steering effort. After purchasing the vehicle, it developed a serious steering problem. At approximately 50–65 mph, the steering wheel can become stuck or extremely difficult to move when I attempt to steer left or right, as if the steering is physically sticking. This creates a serious safety risk because the driver may be unable to make an immediate steering correction at highway speeds. I brought the vehicle to an authorized Mazda dealership and specifically requested that they determine whether the problem was related to the previous 6524A recall. The dealership documented my complaint as the steering wheel getting “STUCK” at 50/65 mph and referenced Recall 6524A and increased steering effort. The dealership inspected the vehicle and marked the steering concern FAILED. Their written recommendation states that the vehicle “needs steering rack.” The estimated repair cost is $2,236.45, with a total estimate of $2,524.19 including fees and taxes. I escalated this issue to Mazda Corporate and requested coverage because the vehicle previously received a safety recall repair involving the same steering system. Mazda Corporate denied coverage, leaving me responsible for the repair. The financial burden is also a serious concern. I currently cannot afford the approximately $2,500 repair, meaning I am unable to have this documented safety defect corrected. This puts my family in the difficult position of potentially needing to operate a vehicle with a known steering issue and also raises concern that other owners could face the same situation if they cannot afford the repair. I am requesting that NHTSA investigate whether Recall 6524A adequately addressed the underlying defect or whether this represents

I am filing this complaint regarding a serious steering safety issue with my 2024 Mazda CX-90, which I purchased on March 24, 2026, with approximately 40,000 miles. The vehicle previously underwent Mazda Safety Recall 6524A involving the steering system and increased steering effort. After purchasing the vehicle, it developed a serious steering problem. At approximately 50–65 mph, the steering wheel can become stuck or extremely difficult to move when I attempt to steer left or right, as if the steering is physically sticking. This creates a serious safety risk because the driver may be unable to make an immediate steering correction at highway speeds. I brought the vehicle to an authorized Mazda dealership and specifically requested that they determine whether the problem was related to the previous 6524A recall. The dealership documented my complaint as the steering wheel getting “STUCK” at 50/65 mph and referenced Recall 6524A and increased steering effort. The dealership inspected the vehicle and marked the steering concern FAILED. Their written recommendation states that the vehicle “needs steering rack.” The estimated repair cost is $2,236.45, with a total estimate of $2,524.19 including fees and taxes. I escalated this issue to Mazda Corporate and requested coverage because the vehicle previously received a safety recall repair involving the same steering system. Mazda Corporate denied coverage, leaving me responsible for the repair. The financial burden is also a serious concern. I currently cannot afford the approximately $2,500 repair, meaning I am unable to have this documented safety defect corrected. This puts my family in the difficult position of potentially needing to operate a vehicle with a known steering issue and also raises concern that other owners could face the same situation if they cannot afford the repair. I am requesting that NHTSA investigate whether Recall 6524A adequately addressed the underlying defect or whether this represents

On multiple occasions, the steering wheel became stiff or locked while driving or during start-up, multiple dashboard warning lights illuminated, and the vehicle could not be shifted from Park to Drive. This occurred repeatedly since the vehicle was purchased. The dealer inspected the vehicle multiple times; on the first attempts they could not duplicate the issue. On a later visit, the vehicle displayed a lost communication fault with the electric power steering (EPS) system, and the dealer replaced the steering gear/rack assembly and EPS motor per the manufacturer’s technical hotline instructions. Despite this part replacement, the same steering/warning light condition recurred weeks later. At that point the dealer confirmed the defect but stated there is currently no authorized repair or parts replacement available, and that engineering is developing a permanent corrective action. The vehicle remains in my possession and is available for inspection. This defect creates a serious safety risk because the vehicle cannot be steered or shifted normally when the condition occurs, including while driving. No crash or injury has occurred to date.”