2016 MERCEDES-BENZ C300 Complaints

NHTSA Safety Complaint – 2016 Mercedes-Benz C300 Vehicle: 2016 Mercedes-Benz C300 | Mileage: 74,662 miles What Happened I’m filing this complaint because my 2016 Mercedes-Benz C300 suffered a sudden, complete engine failure at 74,662 miles, and I believe it’s a safety risk that deserves investigation. I’ve owned this car since 2016 and followed every recommended service interval. All available warranties were purchased and maintained. The car showed absolutely no signs of trouble before this happened. Last week before filing, I was driving normally when the check engine light came on without any prior warning — no oil pressure light, no temperature alert, nothing else. Within minutes, the engine shut off completely. The car rolled to a stop and I noticed oil leaking from the front of the engine. It was towed to an authorized Mercedes-Benz dealership, where they confirmed the engine suffered a catastrophic internal failure and needs to be fully replaced. Why This Is a Safety Concern No advance warning. The check engine light appeared only minutes before the engine died. That’s not enough time to safely exit a highway or busy road. A sudden total engine failure at speed affects steering, braking assist, and reaction time — it could easily cause a serious accident. Engine failure at 74,662 miles is not normal. A complete engine failure on a well-maintained luxury vehicle at under 75,000 miles strongly suggests a manufacturing defect or design flaw, possibly affecting other vehicles of the same model year. Oil leak at engine front. The leak observed at failure likely points to a specific component or seal failure. If this is a design weakness, other 2016 C300 owners may be at risk without knowing it. What I’m Requesting 1.Open an investigation into the 2016 Mercedes-Benz C300 for sudden engine failure and inadequate warning systems. 2.Determine whether other owners have reported similar incidents. 3.Evaluate whether a safety recall is warranted.

I’ve been driving my car since September when it was purchased I just got it from dealership 4/9/26 spent over $1100 and have been working like regular full time schedule, I wake up today 4/27/26 trying to work and car is stalling. Not sure what’s going on with these mechanics and technicians. I pay to dollar to ensure my family safety on the road here I am stuck without support due to my circumstances. Also, my car just idles the shuts off doesn’t turn mall the way on, magically a check engine light flashed then car just immediately stalled and won’t turn back over all the way.

Panoramic sunroof fails to open/ close evenly due to binding issue and plastic track failure. One side binds while the other moves, causing glass to tilt and jam. Risk of dangerous injury including glass shattering, sudden detachment, distraction while driving, and water intrusion affecting airbags/electronics.

My C300 MBZ, 2016 is experiencing the same symptoms as indicated in a recall, but my vehicle is not included in that recall. Camshaft: GENERAL REPAIR A cam is a rotating or sliding piece in a mechanical linkage used especially in transforming rotary motion into linear motion or vice versa. Cams act as a vital component to your automobile's engine. A camshaft is a shaft to which a cam is fastened or of which a cam forms an integral part. Camshafts provide power to the cams which are vital for basic engine operation. The cost of fixing this approximately $10,000 per Mercerdes dealer and estimate from Keyes Mercerdes. The Brief: Mercedes-Benz issued a recall for some model cars tied to a faulty drive shaft.T he problem not only can cause vehicles to lose power but may elevate crash risk, according to the National Traffic Safety Administration. Owners of the affected vehicles can take them to their local dealership to receive free repairs, however per MBZ corporate 2016 C300 not included? Mercedes-Benz is recalling 24,092 cars connected to a drive shaft universal joint that may break, resulting in a sudden loss of drive power.

I am reporting a structural failure of the rear subframe (axle carrier) on my 2016 Mercedes-Benz C300 (W205). The component is exhibiting significant internal-to-external corrosion (perforation), specifically at the suspension mounting points. Safety Impact: The vehicle is currently exhibiting unstable handling and a 'skittish' 'swerving' sensation causing the car to 'fishtail' under braking during normal braking and at highway speeds, indicating a compromise in the structural integrity of the rear axle. This poses an immediate risk of a 'loss of directional control' should the suspension components fully detach from the corroded subframe. The Structural Integrity, Loss of Directional Control, Sudden Suspension Failure, and causes extremely dangerous Safety Hazard for my family and other on the road. The corrosion has compromised the mounting points of the rear suspension, creating a risk that the axle will detach while the vehicle is in motion, leading to a catastrophic loss of control. Context: Mercedes-Benz has acknowledged this defect in previous years (2008-2015) via a 20-year extended warranty and in Service Information S135.00-P-0009A. However, they have failed to include the 2016 W205 in the safety remedy despite identical failure modes and documented safety hazards. Currently, as of April 2026, a 2024/2025 federal court ruling [XXX] v. Mercedes-Benz) allowed a class-action lawsuit to proceed specifically covering 2010–2022 models—including the2016 C300 W205—alleging the exact same manufacturing defect. A thorough inspection of the undercarriage of the vehicle shows severe corrosion to the subframe as well as a cracked hub along the drive-train shaft and differential. I have submitted photos along with this Vehicle Complaint From to document the corrosion of the subframe and other defects associated with the devices and systems that transmit power from the engine or propulsion device to the wheels such as the cracks in hubs, shafts, differentials. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORM

A lot of times when I park even on flat surfaces my parking brake engages and It’s hell being able to leave because I have to turn the car off open the door close door start the again put in drive while my foot is on the brake and pull and push the parking brake button 4 times. Then I’m able to drive. This has been happening more frequently and there is an open recall for the parking brakes calLED ESP RECALL

Spontaneous explosion of sunroof while car is in motion on the expressway 83 and could have caused an accident while my daughter was driving

The contact owns a 2016 Mercedes-Benz C300. The contact stated that while driving approximately 20 MPH and turning the steering wheel to the right or the left, there was an abnormal clicking sound coming from the rear of the vehicle. There was no warning light illuminated. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the rear sub frame of the vehicle had severe corrosion and needed to be replaced. The contact was advised by a service technician that there had been a recall for corrosion failures, but the year and the model were not included. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 130,000.

fuel lines/ clamps defective causing a fuel leak. vehicle could catch on fire and fumes are extremely strong inside the cabin. issue confirmed by Mercedes dealer, mentioned there is an extended warranty up to 120,000 miles. rejected mine because i was at 120,300 miles. had to pay out of pocket. no warning lights or anything just the really strong smell of fuel and fuel range dropping. this is a very common issue thats known and should be a recall.

The contact owns a 2016 Mercedes-Benz C300. The contact stated that whenever the fuel tank was full, there was a fuel-burning odor coming from the engine and entered the vehicle through the A/C vents. In addition, when the vehicle was cold, the odor was entering the vehicle through the A/C vents. No warning lights were illuminated. The vehicle was taken to a collision center specializing in foreign vehicles, where it was diagnosed that the fuel rail and injectors had a fuel leak. The vehicle was not repaired. The contact stated that the failure persisted. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V961000 (FUEL SYSTEM, GASOLINE). However, the VIN was not included. The contact stated that his mother owned the vehicle in the past and gave the vehicle to the contact two years ago. The contact's mother remembered receiving a recall letter; however, the contact's mother was unsure if the vehicle had been repaired in the past. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 60,000.