1996 MERCURY GRAND MARQUIS Complaints

THE INTAKE MANIFOLD HAS A HAIRLINE CRACK ON THE REAR HEATER HOSE INLET. ANTI-FREEZE IS SEEPING OUT INTO THE #4 SPARK PLUG CAUSING MISFIRING. THIS PLASTIC MANIFOLD WAS PREVIOUSLY REPLACED BEFORE THE RECALL TO REPAIR DEFECTIVE MANIFOLDS. THIS IS THE REPLACEMENT MANIFOLD WITH A SEPARATE ALUMINUM HOT WATER CROSS OVER IN FRONT. *JB

DT*: THE CONTACT STATED WHILE DRIVING 25 MPH ON NORMAL DRIVING CONDITIONS, THE VEHICLE WOULD NOT STOP. THE EMERGENCY BRAKE WAS APPLIED TO STOP THE VEHICLE. THE BRAKE LINE BLEW AND BRAKE FLUID WAS LEAKING DUE TO A HOLE ON THE BRAKE LINE. THE DESIGN OF THE BRAKING SYSTEM WAS ANTI-LOCK. THERE WERE NO WARNING SIGNALS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT SHOP, WHO DETERMINED THAT THE REAR AND FRONT BRAKES WERE DEFECTIVE RESULTING IN THE WHOLE BRAKE LINES BEING REPLACED. THE MANUFACTURER WAS NOTIFIED AND OFFERED REIMBURSEMENT BUT THE CONTACT HAD NOT HEARD FROM THE MANUFACTURER SINCE THEN. UPDATED 01/10/07. *JB

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 25 MPH ON A SUBURBAN STREET, THE BRAKES FAILED TO STOP THE VEHICLE WITHOUT WARNING. ALTHOUGH FIRM, CONSTANT BRAKE PRESSURE WAS APPLIED, THE VEHICLE CONTINUED FORWARD UNTIL THE EMERGENCY PARKING BRAKE WAS ENGAGED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT REPAIR SHOP, WHO DETERMINED THE BRAKE LINES FRACTURED AND BRAKE FLUID WAS LEAKING. THE MANUFACTURER WAS NOTIFIED. UPDATED 11/21/06. *JB

I WAS DRIVING MY 1996 MERCURY GRAND MARQUIS WHEN STEAM STARTED POURING FROM UNDER THE HOOD. I HAD TO HAVE MY CAR TOWED AND LEARNED THAT THE INTAKE-MANIFOLD HAD CRACKED, CAUSING COOLANT TO POUR ALL OVER THE ENGINE. THE GARAGE REPLACED THE UNIT FOR A CHARGE OF $692 AND TOLD ME EVERYTHING WAS THEN FINE. HOWEVER, BEFORE I GOT HOME, MY ENGINE LIGHT CAME ON. I TOOK MY CAR TO THE VERY REPUTABLE AUTOMOBILE REPAIR SHOP THAT I USE AND UPON CHECKING, THEY SAID THE WIRES, POINTS, AND PLUGS NEEDED REPLACING, NO DOUBT CAUSED FROM THE PRIOR INCIDENT. THIS WORK COST ME AN ADDITIONAL $425.

DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND LOWERED TO THE FLOOR. THE CONTACT USED THE PARKING BRAKE TO STOP THE VEHICLE AND DROVE IT TO THE RESIDENCE. THE CONTACT INSPECTED UNDER THE VEHICLE AND NOTICED THE BRAKE LINE HAD RUPTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE BRAKE LINES WERE REPLACED. UPDATED 9/13/2006 - THE BRAKE LINES WERE BADLY RUSTED. THE REAR END HOUSING WAS ALSO BADLY RUSTED. *NM

VEHICLE WOULD NOT SHIFT OUT OF PARK. INSPECTED FUSES AND FOUND BLOWN 15 AMP FUSE. REPLACED AND VEHICLE WORKED PROPERLY. PARKED IN DRIVEWAY. 30 MINUTES LATER, CAR IS ON FIRE. VEHICLE IS TOTALED. *JB

DT*: THE CONTACT STATED THE TEMPERATURE GAUGE BECAME INOPERABLE, AND WHILE ATTEMPTING TO REPAIR A LEAK IN THE INTAKE MANIFOLD WAS NOTICED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE INTAKE MANIFOLD WAS REPLACED. THERE HAVE BEEN NO FURTHER PROBLEMS. *AK

1996 GRAND MARQUIS INTAKE MANIFOLD FAILED, MECHANIC DETERMINED THIS NEEDED TO BE REPLACED. *TS *JB

DT: THE CONTACT STATED VEHICLE CAUGHT ON FIRE. THE VEHICLE WAS TURNED OFF AND PARKED FOR ELEVEN HOURS. THE FIRE DEPARTMENT REPORT CONCLUDED THE FIRE STARTED AROUND THE VEHICLE SPEED CONTROL:CRUISE CONTROL. A POLICE REPORT WAS TAKEN, ALSO, PICTURES WERE AVAILABLE. THE VEHICLE WAS TOTALED. *AK

HORN & CRUISE CONTROL STOPED WORKING , REPAIR SHOP SAID WIRING HARNESS IS BREAKING DOWN AT THE TIGHT BENDS .ALSO SAID THIS IS A COMMON COMPLAINT WITH THIS MODEL AND ITS SISTER MODEL. I HAVE NOT CORRECTED THIS AS OF YET. *JB