2010 MERCURY MILAN Complaints

I HAVE HAD THE MILAN 2010 INTO FORD 6 TIMES BECAUSE THE ENGINE LOST ALL POWER WITHOUT WARNING:NO LIGHTS;BRAKES;STEERING. I HAVE WITNESSES. IT HAS HAPPENED IN ALL TYPES OF CONDITIONS: STOP AND GO TRAFFIC; MERGING ONTO A FREEWAY. THE LAST TIME BLACK SMOKE CAME FROM UNDER THE HOOD. THE CAR WAS IN THE SHOP FOR 6 WEEKS. A WEEK AFTER IT WAS SO CALLED "REPAIRED" THE PROBLEM OCCURRED AGAIN. I STARTED A "LEMON LAW" COMPLAINT IN MARCH 2012. MY MOTHER BECAME FATALLY ILL AND DIED AND I COULD NOT COMPLETE THE CLAIM. JUNE 15, 2012 I WAS PULLING INTO A PARKING SPACE AND THE ELECTRICAL SYSTEM FAILED. I COULD NOT STOP. I CRASHED INTO A CEMENT WALL. THE CAR WAS A TOTAL LOSS. I GOT WHIPLASH. MY INSURANCE COMPANY WILL NOT PAY THE BALANCE REMAINING ON THE CAR. BBB STOPPED "LEMON LAW" CASE BECAUSE THERE WAS AN ACCIDENT. NO ATTORNEY WILL TAKE THE CASE BECAUSE THERE IS NOT ENOUGH MONEY TO BE GAINED. I AM WITHOUT A CAR; IN DEBT; INJURED; DRIVING A RENTAL CAR AND WORKING 12 HOURS A DAY TO BUY A NEW CAR. PLEASE HELP ME. *TR

AFTER ONLY 24,600 MILES, THE SUN ROOF WORKED ONE DAY AND THE NEXT DAY WHEN THE BUTTON WAS ACTIVATED THE SUNROOF BEGAN TO LOWER THE REAR OF THE WINDOW BUT WOUNLD OPEN NO FURTHER. UPON MULTIPLE TRIES, THE RAISING AND LOWERING OF THE REAR PART OF THE WINDOW IS ALL IT WOULD DO. WHEN TAKEN OT BLLOOMINGTON LINCOLN, (MN) THEY INFORMED ME THAT THE MOTOR AND ENTIRE TRACK SYSTEM WOULD NEED REPLACING. THEY TOOK PICTURES TO SEND TO FORD TO SEE IF THEY WOULD HONOR THE WARRANTY. GEE. THE VEHICLE IS STILL UNDER THE 3 YR, 36000 LIMIT. SHOULD HAVE BEEN A NO BRAINER. *TR

I WAS DRIVING APPROXIMATELY 50 MPH. THE CAR BEGAN TO SLOW DOWN, AND IT JERKED AND HESITATED AND BEGAN TO DECELERATE AS IT CONTINUED THE JERKING AND HESITATION. THE CAR WOULD NOT RESPOND TO THE ACCELERATOR AT ALL. CONTINUED TO JERK AND SLOW DOWN AND THE ENGINE AND TRANSMISSION WERE NOT FUNCTIONING PROPERLY. I PULLED IN TO A GAS STATION AND STOPPED THE CAR. *TR

WHEN I AM DRIVING (I NEVER HAVE ANY ADVANCE NOTICE) SUDDENLY SPEED CHANGES TO NOTHING NO MATTER WHAT YOU DO. THEN THE WRENCH LIGHT COMES ON, I HAVE TO GO TO THE SIDE OF THE ROAD TURN OFF CAR AND RESTART, THEN IT MAY DO THE SAME THING AGAIN OR IT MAY QUIT AND DRIVE NORMALLY. HAS CONTINUED TO HAPPEN THIS WEEK! IT IS VERY DANGEROUS AND FROM THE LOOKS OF THE COMPLAINTS IT SEEMS TO BE A REPEATING PROBLEM WITH THIS CAR. *TR

DRIVING DOWN THE HIGHWAY AT 65 MPH AND I FELT A SLIGHT JERK IN THE VEHICLE (SIMILAR TO SHIFTING) AND THE YELLOW WRENCH DASHBOARD LIGHT CAME ON, WHEN I PRESSED THE GAS PEDAL, NOTHING HAPPENED. THE CAR WAS STILL RUNNING BUT THE ACCELERATOR DID NOTHING. I PULLED THE CAR OVER, PUT IT IN PARK, TURNED IT OFF, THEN BACK ON AND IT WAS FINE. AFTER DRIVING FOR ANOTHER HOUR, THE SAME THING HAPPENED. THIS IS DANGEROUS!! NOT HAVING AN ACCELERATOR ON A 70 MPH HIGHWAY IS NOT SAFE! AFTER RESEARCHING ON THE INTERNET THE SAME PROBLEM HAS HAPPENED TO MANY MILAN OWNERS. IT'S IN THE SHOP RIGHT NOW AND THEY CAN'T FIGURE OUT WHAT'S WRONG. *JB

WHEN DRIVING, THE CAR FEELS LIKE IT SHIFTS GEARS, THE WRENCH LIGHT COMES ON AND ENGINE POWER IS LOST. AFTER PULLING OVER, TURNING OFF THE ENGINE AND RESTARTING, THE CAR DRIVES NORMALLY. THIS HAPPENED MULTIPLE TIMES IN ONE DAY. DEALER REPROGRAMMED PCM AND IT WAS FINE FOR TWO MONTHS. SAME THING HAPPENED ON JUNE 21, 2012. THIS IS POTENTIALLY LIFE THREATENING PROBLEM BECAUSE IT HAS HAPPENED AT HIGHWAY SPEEDS IN RUSH HOUR CONDITIONS. MANY CONSUMER REPORTS OF SAME SYMPTOMS CAN BE EASILY FOUND ON INTERNET BY SEARCHING FOR "ELECTRONIC THROTTLE CONTROL." WHEN I TOOK CAR TO DEALER AFTER MOST RECENT OCCURRENCE, THEY SAID THEIR WERE NO CODES SHOWING SO THERE WAS NOTHING TO FIX. FORD NEEDS TO INVESTIGATE WHY THIS IS HAPPENING AND RECALL/FIX THIS PROBLEM BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED BECAUSE OF THIS PROBLEM!

I WAS FIRST IN LINE AT A RED LIGHT ON A 2-LANE HIGHWAY. WHEN THE LIGHT TURNED GREEN, I ACCELERATED AND HALFWAY THROUGH THE INTERSECTION THE CAR "LURCHED" AND LOST POWER. THE CAR DIDN'T DIE BUT THERE WAS NO RESPONSE IN THE GAS PEDAL AND A WRENCH SYMBOL APPEARED IN THE DASH. I MADE IT THROUGH THE INTERSECTION AND TO THE SHOULDER AT IDLE SPEED (WITH A LINE OF CARS BEHIND ME). I PUT THE CAR IN PARK AND TURNED IT OFF FOR A MINUTE. IT RESTARTED OK, THE WRENCH WAS GONE AND THE CAR RAN FINE. I CONSIDERED IT A FLUKE UNTIL A WEEK LATER WHEN THE SAME THING HAPPENED, EXCEPT THAT I WAS TRAVELING AT 70 MPH IN THE INSIDE LANE OF THE SAME HIGHWAY. LUCKILY THERE WAS ROOM TO CHANGE LANES WHILE DECELERATING AND I PULLED TO THE SHOULDER. AGAIN, IT RESTARTED FINE AFTER I TURNED IT OFF, AND THE WRENCH WAS GONE. I TOOK THE CAR FOR SERVICE AT A FORD DEALER BECAUSE LOSING POWER IN TRAFFIC IS A VERY DANGEROUS SITUATION AND WHO KNOWS WHEN AND WHERE IT MIGHT HAPPEN AGAIN. THE TECH FOUND A PROBLEM WITH THE THROTTLE BODY AND REPLACED IT AT A COST OF ABOUT $350 PARTS/LABOR. OF COURSE, WE ARE JUST OUTSIDE OF THE WARRANTY PERIOD AT 41,000 MILES. *JS

TL* THE CONTACT OWNS A 2010 MERCURY MILAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A RECURRING FAILURE IN WHICH IT WOULD JERK WHILE SHIFTING GEARS AND EXPERIENCE TROUBLE ACCELERATING. THE TRANSMISSION LIGHT WAS ALSO ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.

2.CAR (HYBRID) LOSES POWER. THIS IS THE ONLY OCCURRENCE. THE CAR WAS STARTED AND DRIVEN DOWN HILL TO AN INTERSECTION. WHEN TURNING RIGHT THE CAR SUDDENLY AND WITHOUT ANY WARNING LOST POWER. SEVERAL ATTEMPTS TO ACCELERATE FAILED AND THE CAR CAME TO A STOP. I LOOKED AT THE DASH AND THE HEV SCREEN. I SAW THAT THE BATTERY WAS FULLY CHARGED (MAXIMUM LIMIT), WRENCH WARNING LAMP WAS ON AND THE HEV SCREEN SHOWED ONLY THE ELECTRIC MOTOR WAS ON (HI LIGHTED). I TURNED THE IGNITION KEY OFF THEN ON, AND THE CAR RETURNED TO NORMAL OPERATION. AT THIS POINT THE HEV SCREEN SHOWED THE ENGINE, MOTOR AND BATTERY HI LIGHTED. SHOULD THIS HAPPEN WHILE ENTERING A FREEWAY, A SERIOUS ACCIDENT COULD HAVE OCCURRED. *JS

NO INCIDENT TO REPORT. . .YET. THIS COMPLAINT IS RE SAFETY RECALL NOTICE 11S23 (NHTSA CAMPAIGN ID NUMBER 11V574000.) AS NOTED IN THE "REMEDY" SECTION, FORD NOTIFIED ME OF THE RECALL; ON FEBRUARY 6TH, THE DEALER (BRANDON FORD IN FLORIDA) INSPECTED THE VEHICLE AND DETERMINED THAT REPLACEMENT WAS NECESSARY. BRANDON FORD DID NOT HAVE THE NECESSARY PARTS IN STOCK; I WAS TOLD THEY WOULD CALL WHEN THEY ARRIVED. ON MARCH 15TH, STILL WITH A DEFECTIVE VEHICLE, I CONTACTED BRANDON FORD AGAIN AND EXPLAINED THAT I HAD TO DRIVE THE VEHICLE BACK TO MICHIGAN ON APRIL 13TH. TODAY (3/16), I WAS TOLD THAT THEY STILL DO NOT HAVE THE PARTS AND DON'T KNOW WHEN THEY'LL GET THEM. [XXX] AT BRANDON FORD TOLD ME THAT I (NOT THEM, NOT FORD) COULD TRY OTHER DEALERS OR CALL THE FORD CUSTOMER SERVICE # (I GUESS I HAVE TO.) TWO MONTHS SHOULD BE MORE THAN ENOUGH TIME TO FIX THEIR PROBLEM. SO ALTHOUGH A "REMEDY" HAS BEEN OUTLINED IN THE NHTSA DATABASE, THERE APPEARS TO BE NO CONCERN BY FORD TO ACTUALLY IMPLEMENT AND NO FOLLOW-UP BY NHTSA TO VERIFY THAT FORD FIXES THE PROBLEM. I'M AFRAID TO DRIVE THE CAR FROM FLORIDA TO MICHIGAN. IT NEEDS TO BE FIXED (WITHOUT ME HAVING TO CALL ALL OVER FLORIDA LOOKING FOR A PART TO REPLACE THEIR DEFECTIVE PART) OR THEY NEED TO GIVE ME A LOANER CAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR