2010 MERCURY MILAN Complaints

ON APRIL 19, 2013, I HAD ONE INCIDENT WHERE MY CAR LOST POWER WITH NO WARNING. I WAS GOING APPROXIMATELY 40 MPH. I SUDDENLY REALIZED I HAD NO POWER AND NOTICED THAT THE WRENCH LIGHT AND OTHER LIGHTS CAME ON. I WAS ABLE TO STEER THE CAR OFF THE ROAD. I HAD TO TURN IT OFF AND THEN RESTART IT. I TOOK THE CAR TO THE DEALER SERVICE DEPT BUT THEY SAID THEY COULDN'T FIND ANYTHING. IT SEEMED TO RUN ROUGHER FOR THE NEXT MONTH BUT DIDN'T STALL AGAIN UNTIL MAY 16. AT THAT TIME I WAS GOING APPROXIMATELY 30 MPH. ON MAY 17 IT STALLED TWO TIMES WHILE GOING 70 MPH ON THE INTERSTATE. ON MAY 19 IT STALLED ONE TIME WHILE GOING 60 MPH SO I PARKED THE CAR FOR THE WEEKEND. I CALLED THE DEALER AND HAD TO DRIVE OVER AN HOUR TO THE DEALER. IT STALLED THREE TIMES ON THE WAY TO THE DEALER. I DROVE WITH MY FLASHERS ON THE ENTIRE TIME BECAUSE I WAS TERRIFIED THAT I WAS GOING TO BE IN AN ACCIDENT OR WORSE. MY DEALER HAS DETERMINED THAT IT IS THE THROTTLE BODY. MY CAR HAS BEEN STUCK IN THE SHOP SINCE MAY 20 WAITING FOR THE PART THAT IS ON NATIONWIDE INDEFINITE BACK ORDER AND THERE IS NO FIX DATE IN SIGHT. MY CAR IS NOT DRIVABLE AND I AM JUST THANKFUL THAT I HAVEN'T HAD AN ACCIDENT OR BEEN KILLED BECAUSE OF THIS PROBLEM. I HAVE LOST CONFIDENCE IN MY CAR WHICH I WAS SO HAPPY WITH. I ALSO AM PAYING ON A CAR THAT I CAN'T EVEN DRIVE. *TR

THE FIRST TIME THIS HAPPENED I WAS DOING 60 MPH ON THE FREEWAY AN MY CAR LOST POWER AN WOULD NOT ACCELERATE BUT I COULD STILL TURN AN BRAKE BUT THE ENGINE WAS STALLING AN SHAKING AN THE WRENCH LIGHT CAME ONE. I COASTED OFF THE ROAD SHUT THE CAR OFF AN RESTARTED IT AFTER A FEW MINUTES AN THE ENGINE TURNED OVER FOR ABOUT 10 SECONDS BEFORE STARTING UP AN IT DROVE FINE. I TOOK IT IN TO THE DEALERSHIP AN THEY SAID THEY COULDN'T DO ANYTHING BECAUSE THEY COULDN'T GET THE FAULT TO HAPPEN SO I TOOK MY CAR. OVER THE LAST FEW MONTH IT HAS HAPPENED MULTIPLE TIME BUT NOW IT WILL STALL OUT AN THE HAVE THE WRENCH LIGHT COME ONE AGAIN AN WHEN I RESTART MY CAR IT WILL GO ABOUT 50 FEET AN HAPPEN AGAIN ABOUT 7 TIMES IN A ROW. I HAVE TAKEN IT TO THE DEALERSHIP A FEW TIMES AN I KEEP GETTING THE SAME ANSWER. *TR

CAR WILL LOSE POWER AT ANY GIVING TIME OR SPEED ABOVE 40MPH. YOU MUST THEN TRY TO PULL OFF ROAD AND TURN OFF AND RESTART. IT WOULD ONLY DO THIS ONCE A WEEK, BUT NOW IT'S DOING MULTIPLE TIMES A DAY. DEALER WILL NOT ADDRESS IT AS A WARRANTY PROBLEM DUE TO FACT IT HAS OVER 36000 MILES ON IT. TRIED TO ORDER REPLACEMENT THROTTLE BODY THRU THEM BUT IT ON BACK ORDER. *TR

MY VEHICLE WAS TOWED AT MY EXPENSE TO A SHOP. THE VERDICT WAS A 'THROTTLE BODY' ISSUE. THIS VEHICLE WENT INTO THE 'LIMP HOME' MODE WITH NO WARNING. I WOULD CHALLENGE THE PRESIDENT OF FORD TO ATTEMPT TO LIMP THIS VEHICLE JUST 5 MILES ON ANY BUSY ROAD IN THE NATION IN THIS MODE. APPARENTLY, JUDGING BY MY RESEARCH, IT IS AN ONGOING PROBLEM AND WIDESPREAD. AS OF RIGHT NOW THE VEHICLE IS UNUSABLE, SINCE THE PARTS ARE ON 'INDEFINITE BACK-ORDER' AWAITING SOME SORT OF RELEASE OF PARTS. THE VEHICLE IS STUCK AT A DEALERSHIP, NO FIX DATE IN SIGHT UNTIL THE PART (OR SUBSTITUTE PART) BECOMES AVAILABLE. THIS LEAVE ME WITH NO TRANSPORTATION (I'M DISABLED CURRENTLY) AND NO RECOURSE. EVEN IF I FIND A CURRENTLY AVAILABLE REPLACEMENT PART, WITHOUT WHATEVER FIX IS NEEDED, MY FAITH IN THE VEHICLE IS GONE. FAITH IN ALL FORD VEHICLES I MIGHT ADD. THE RIDE HOME WAS DANGEROUS AT THE CRAWL SPEED IT WILL DO, ESPECIALLY WITH THE LURCHING AT TIMES. *TR

WHILE DRIVING MY 2010 MILAN AT THE SPEED OF 55 MPH, THE CAR SHOOK SLIGHTLY AND THE WRENCH LIGHT APPEARED. THE CAR BEGAN TO LOSE POWER - I WAS ABLE TO STEER WITH NO PROBLEM. I COULD NOT ACCELERATE. I SHUT THE CAR OFF - AND STARTED IT AGAIN. THE FIRST TIME IT STARTED WITH NO PROBLEM. WITHIN DRIVING 4 MORE MILES, THE SAME THING HAPPENED AGAIN. THIS TIME I WAS DRIVING 25 MPH. IT HAPPENED SEVEN MORE TIMES BEFORE THE CHECK ENGINE LIGHT CAME ON. EACH TIME WHEN I TRIED TO START MY CAR, IT KEPT TURNING OVER BEFORE IT WOULD START. I WAITED FOR AN HOUR ON THE SIDE OF THE ROAD WAITING FOR THE TOW TRUCK. WHEN THE TOW ARRIVED, THE CAR STARTED JUST FINE - THE CHECK ENGINE LIGHT WAS STILL ON. THIS IS EXTREMELY DANGEROUS! I WAS DRIVING IN RUSH HOUR TRAFFIC AND WAS ALMOST REAR ENDED ON THE HIGHWAY. AGAIN WHEN IT OCCURRED IN TOWN, THERE WAS NO WHERE FOR ME TO COAST OFF TO THE SIDE OF THE ROAD, I HAD TO STOP IN TRAFFIC TO RESTART ME CAR. *TR

I HAVE A 2010 MERCURY MILAN WITH 40,000 MILES ON IT. RECENTLY SOMEONE POINTED OUT TO ME THAT THE DRIVER-SIDE BRAKE LIGHT IS CONTINUOUSLY ACTIVATED. CONSEQUENTLY WHEN BRAKING, DRIVERS BEHIND ME ARE ONLY NOTIFIED BY THE RIGHT AND CENTER BRAKE LIGHTS. IT SEEMS TO ONLY HAPPEN WHEN THE HEADLIGHTS ARE ON. MY RESEARCH SHOWS THIS TO BE A COMMON ISSUE WITH THE 2010 MERCURY MILAN WITH SOME HAVING BOTH BRAKE LIGHTS MALFUNCTIONING. DIAGNOSIS SAYS IT IS A FAULTY LED BRAKE LIGHT ASSEMBLY, WHICH WOULD IMPLY A BAD CIRCUIT BOARD. THIS IS A SERIOUS SAFETY HAZARD AND SHOULD BE RECALLED. I CONTACTED FORD ABOUT IT AND THEY DIRECTED ME TO A DEALER SAYING THEY, (FORD) WOULD PROBABLY PAY FOR THE REPAIR. AFTER I CONTACTED THE DEALER, FORD CHANGED THEIR MIND AND SAID THAT SINCE I DIDN'T BUY THE CAR NEW, THEY DIDN'T CONSIDER ME A "LOYAL'" FORD CUSTOMER AND WILL NOT COVER ANY OF THE COST. IT SEEMS FORD IS ONLY CONCERNED ABOUT THE SAFETY OF THEIR "LOYAL" CUSTOMERS. *TR

I WAS DRIVING GOING ABOUT 20MPH AND THE VEHICLE WOULD STALL. ONCE I STOPPED AGAIN AND TRIED TO ACCELERATE THE WRENCH TOOL SYMBOL APPEARED ON THE DASH AND THE CAR SHUT DOWN. WHILE RIDING BEFORE THE CAR SHUT OFF THE ENGINE WAS IDLING VERY ROUGHLY. THIS IS THE SECOND TIME I HAVE HAD THE PROBLEM IN THE LAST 7 MONTHS AND SUPPOSEDLY ITS A PROBLEM WITH THE THROTTLE. THIS IS A VERY BIG TO A LOT OF PEOPLE INCLUDING MYSELF I SEE IF FORD SEE THERE'S A CONTINUOUS PROBLEM PLEASE FIX IT BECAUSE THIS IS RIDICULOUS. *TR

DRIVING ABOUT 40-50MPH IN TRAFFIC, THE CAR SUDDENLY JERKED, FELT LIKE A HARD GEAR-SHIFT. THE GREEN WRENCH LIGHT & ORANGE ENGINE LIGHT CAME ON AND THE THROTTLE WAS UNRESPONSIVE. THE CAR STILL HAD POWER BUT NO ACCELERATION, ENGINE SPUTTERED, HAD TO PULL OFF THE ROAD WHILE COASTING, CAR WAS IDLING VERY ROUGH SO WAS SHUTDOWN. I WAS ABLE TO RESTART IT BUT THE PROBLEM RECURRED FOUR TIMES THE NEXT TWO DAYS. STOPPED AT ADVANCE AUTO PARTS SINCE IT WAS EARLY EVENING, THEY PULLED DTC P2111 "THROTTLE ACTUATOR CONTROL SYSTEM STUCK OPEN" FROM CAR'S COMPUTER AND HE SAYS THE THROTTLE VALUE IS STICKING. SCHEDULED SERVICE AT WORLD FORD DEALERSHIP WHERE CAR WAS PURCHASED JUST FOUR MONTHS PRIOR. I WAS TOLD THE THROTTLE BODY NEEDED REPLACING "THIS IS VERY COMMON, WE REPLACE THEM ALL THE TIME" HE SAID. I PURCHASED A POWERTRAIN EXTENDED WARRANTY WITH THE CAR THAT STATES IT COVERS THE "THROTTLE VALVE" AMONG ITS COVERED PARTS BUT THE SERVICE MAN FIRST SAYS THAT'S DIFFERENT THAN THE "THROTTLE BODY" (MY UNDERSTANDING IS THE THROTTLE VALVE IS THE PLATE INSIDE THE THROTTLE BODY THAT OPENS/CLOSES CONTROLLING AIRFLOW TO THE MANIFOLD, IT THAT IS "STUCK OPEN", IT SHOULD BE COVERED). HE THEN SAYS HE DOESN'T EVEN KNOW WHAT A "THROTTLE VALUE" IS AND SAYS IT WILL COST APPROX $350 TO REPAIR. THEY OBVIOUSLY KNOW THIS IS A PROBLEM AND ARE TAKING ADVANTAGE OF THEIR CUSTOMERS REPLACING THE FAULTY PARTS. *TR

THE CAR WAS TRAVELING AT 30 MPH WHEN ALL OF A SUDDEN, WITHOUT ANY WARNING WHATSOEVER, THE ENGINE SHUT DOWN. I HAD IT TOWED AND WAS TOLD THAT THE THROTTLE BODY NEEDED TO BE REPLACED. COST WAS $387.01. I DON'T FEEL THAT THIS SHOULD HAPPEN AT 16,423 MILES. (IT HAD JUST PASSED WARRANTY PERIOD.) HAD I BEEN TRAVELING ON AN INTERSTATE THIS WOULD HAVE BEEN A MAJOR SAFETY PROBLEM. *TR

I WAS DRIVING AT 50 MPH AND PULL OUT TO PASS ANOTHER CARD ACCELERATING TO 55 MPH. THE CAR LURCHED AND STARTED TO LOSE POWER. I THOUGHT IT WAS TEMPORARY BUT IT CONTINUED TO DECREASE TO 40, 30, 20 AND 10 MPH WHICH I PULL OVER TO THE SIDE OF THE ROAD TO PREVENT A HAZARD ON THE HIGHWAY. I CALLED AAA FOR A TOW WHICH ARRIVED ABOUT AN HOUR LATER. THE NEXT MORNING I DECIDED TO TRY AND START THE CAR. THE WRENCH LIGHT WAS OFF AND IT STARTED BUT I DID NOT DRIVE IT. THE NEXT DAY WHICH IS MONDAY I DECIDED I WAS GOING TO CHANCE IT TO TAKE IT TO THE DEALER 30 MILES AWAY. IT ACTUALLY MADE IT THERE AND THE DIAGNOSTIC DONE BY THE DEALER CAME UP WITH NO REPAIR CODES FOR THE VEHICLE, SUBSEQUENTLY, I PICKED IT UP AND DROVE IT HOME AT THE END OF THE DAY. ON TUESDAY, IT STARTED UP AND ONE MILE FROM THE HOUSE, IT CLUNKED OUT AGAIN AND LOST POWER. AGAIN I CALLED AAA TO TOW ME TO THE DEALER. I GUESS BECAUSE IT WAS A RECENT OCCURRENCE, THE CODE SHOWED UP IN THE DIAGNOSTIC SO THEY CLAIM IT IS FIXED BY REPLACING THE THROTTLE BODY ASSEMBLY. IT HAS DRIVEN WELL FOR ONE DAY AND I HOPE IT CONTINUES. IS THIS BASIS FOR A RECALL. PLEASE ADVISE. *TR