2004 MINI COOPER Complaints

I WAS ATTEMPTING TO MERGE ON TO A MAJOR HIGHWAY WHEN MY POWER STEERING FAILED, CAUSING MY VEHICLE TO BE TEMPORARILY OUT OF MY CONTROL. DUE TO THE LOSS OF STEERING, I WAS UNABLE TO SAFELY MANEUVER THE CAR INTO TRAFFIC AND WAS FORCED TO USE BOTH MY PARKING BRAKE AND MY REGULAR FOOT BRAKE TO STOP THE VEHICLE BEFORE I COLLIDED WITH A TRAFFIC LIGHT. THE VEHICLE STOPPED APPROXIMATELY 5-10 FEET FROM A TRAFFIC LIGHT POLE AND PLACED ME IN THE CENTER OF THE INTERSECTION WHERE OTHER MOTORISTS WERE ATTEMPTING TO GAIN ACCESS TO THE ON RAMP. AFTER SEVERAL SECONDS, THE POWERSTEERING REENGAGED AND I WAS ABLE TO CONTINUE, WITHOUT INCIDENT. I AM LUCKY TO BE ALIVE, AND THANKFUL THAT IT WAS NOT MY DEATH THE PROMPTED SOME CONCRETE ACTION BY BOTH YOUR AGENCY AND BMW. THIS IS THE THIRD TIME MY POWER STEERING UNIT HAS FAILED. THE FIRST TWO TIMES WERE LESS THAN ONE SECOND EACH AND OCCURRED WHEN THE CAR WAS STATIONARY MAKING IT DIFFICULT TO DIAGNOSE. SOME HOW CANADA HAS FORCED BMW TO ISSUE AT THE VERY LEAST AN EXTENDED WARRANTY ON THIS SPECIFIC PART, HOW IS IT THAT THE US IS SO FAR BEHIND? *TR

STEERING SUDDENLY BECAME VERY DIFFICULT AND STAYED THAT WAY. IT WAS FINE THE NEXT DAY, BUT AS THE CAR WAS BEING DRIVEN A WHILE THE PROBLEM CAME BACK. *TR

POWER STEERING PUMP FAILED WHILE DRIVING ON HIGHWAY WITHOUT NOTICE. NEVER GOT A WARNING LIGHT BEFORE DURING OR AFTER FAILURE. NARROWLY AVOIDED AN ACCIDENT SINCE I WAS NOT PREPARED FOR STEERING TO BE SO DIFFICULT TO TURN THE WHEEL. I WAS ABLE TO PULL OVER INTO A PARKING LOT WHERE I TURNED THE CAR OFF, LET IT SIT FOR A WHILE AND THEN TURNED IT BACK ON AND THE STEERING WAS OK AGAIN. SINCE THE STEERING IS BACK AND NO WARNING LIGHTS, I ASSUME EVERYTHING IS GOING TO WORK OK FROM NOW ON. *TR

I EXPERIENCED A FAILURE WHERE THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND WOULD NOT RETURN TO CENTER AFTER TURNING. FORTUNATELY THIS OCCURRED FIRST AT A VERY LOW SPEED. I DROVE STRAIGHT TO THE DEALER WHICH HAD REPLACED THE ELECTRIC POWER STEERING PUMP 1,300 MILES EARLIER. THIS FAILURE WAS DETERMINED BY THE DEALER TO BE BINDING OF THE LOWER STEERING SHAFT AND IT WAS REPLACED. *TR

POWER STEERING FAILED AFTER 3 HOUR TRIP - WHILE PARKING. STEERING HAS RETURNED AND QUIT MULTIPLE TIMES SINCE - AND NOW HAS QUIT WORKING IT SEEMS FOR GOOD. CAR IS HARD TO STEER, ESPECIALLY AT LOW SPEED, BUT I AM STILL ABLE TO DRIVE IT. *TR

DRIVING ON FREEWAY, STEERING SUDDENLY BECAME VERY DIFFICULT. LATER WENT BACK TO NORMAL. A MONTH LATER THE POWER STEERING PUMP CONTINUES TO RUN AFTER VEHICLE SWITCHED OFF, DRAINING BATTERY DEAD. *TR

POWER STEERING IS LOSS IS RANDOM, ONCE STEERING IS LOST AFTER TURNING OFF AND CAR COOLS IT WORKS AGAIN. LEADING ME TO BELIEVE THAT THE CAUSE OF THE PROBLEM IS IN THE UNIT'S DESIGN. HESITANT TO SPEND UPWARDS OF $800 (IN PARTS) TO REPLACE WHEN IT MAY NOT SOLVE THE PROBLEM. MANUFACTURER SHOULD INVESTIGATE AND ISSUE RECALL DUE TO TREMENDOUS COMPLAINTS ON SIMILAR FAILURES AND NOT SOLUTION IS AVAILABLE. *TR

THE POWER STEERING STOPPED OPERATING AS WE WERE MAKING A 90 DEGREE TURN AT AN INTERSECTION. WE WERE ABLE TO PULL OVER AND TURN OFF THE ENGINE. WE CHECKED THE POWER STEERING FLUID LEVEL, AND FOUND IT WAS IN THE PROPER RANGE. AFTER A SHORT WAIT WE RESTARTED THE CAN AND THE POWER STEERING SEEMED TO BE OPERATING. *TR

THE VEHICLE HAD BEEN ACTING STRANGE FOR THE LAST COUPLE OF MONTHS, THE STEERING WOULD BECOME HEAVY AT TIMES, AND ON THE OTHER OCCASIONS WOULD WORK JUST FINE. A TRIP TO THE DEALERSHIP REVEALED THAT THE POWER STEERING PUMP HAD FAILED. THIS SEEMS LIKE A KNOWN ISSUE WITH MOST OF THE 2004 MINI COOPERS, A DEFECTIVE PART WAS PUT INTO THE CAR WHILE MANUFACTING. MINI IS NOT TAKING ANY RESPONSIBILITY OF IT, AND THE DEALERSHIP IS ASKING FOR $1200 TO REPLACE IT. DUE TO THE POWER PUMP FAILURE, THE TEMPARATURE RISES AND MAY HAVE CAUSED DAMAGE TO A FEW HOSES AROUND THAT AREA. *TT

TL* THE CONTACT OWNS A 2004 MINI COOPER CV. THE CONTACT WAS DRIVING 40 MPH WHEN THE POWER STEERING FAILED, WITHOUT WARNING, WHILE MAKING A TURN. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 50,000.