2004 MINI COOPER S Complaints

WAS DRIVING CAR ON 18 JULY 2020 AND POWER STEERING QUIT WORKING AND MADE STEERING DIFFICULT, ALSO COOLANT FAN,LOW SPEED AND HIGH SPEED STOPPED WORKING SAME TIME AS POWER STEERING QUIT. THE ASC LIGHT CAME ON AND IT WILL NOT TURN OFF. NO BLOWN FUSES IN ENGINE COMPARTMENT OR BY DRIVERS KICK PANEL. I WAS DRIVING THE CAR ON A STATE ROAD WHEN THIS OCCURRED.

TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT ATTEMPTING TO MAKE A TURN, THERE WAS AN ABNORMAL GRINDING SOUND COMING FROM THE STEERING COLUMN. THE CONTACT ALSO STATED THAT THERE WAS A POWER STEERING FLUID LEAK PRESENT. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO MINI OF STEVENS CREEK LOCATED AT (4201 STEVENS CREEK BLVD, SANTA CLARA, CA 95051), AND DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.

THE POWER STEERING IS VERY STIFF TO DRIVE AND CANNOT DRIVE MY COOPER BECAUSE I CAN NO LONGER STEER THE VEHICLE.

WHEN YOU TURN WHEEL LEFT OR RIGHT IT MAKES A NOISE AND IT'S VERY HARD TO TURN. SO I THINK IT'S THE STEERING: ELECTRIC POWER ASSIST SYSTEM. RECALL ID # 240625.

ALL MODELS FROM 2005 ONWARD HAVE BEEN RECALLED, YET EARLIER MODELS HAVE THE SAME PROBLEMS WITH NON FUNCTIONING AIRBAGS. THE AIRBAG WARNING LIGHT IS ON CONTINUALLY, AND THERE ARE KNOWN PROBLEMS WITH WIRING, PRESSURE MATS AND CONNECTORS IN THESE VEHICLES. BMW IS INTENTIONALLY IGNORING THESE ISSUE. MY OWN PERSONAL VEHICLE HAS THIS PROBLEM AND AS A GOVERNMENT MANDATED SAFETY DEVICE I BELIEVE THAT EARLIER MODELS OF MINI COOPERS SHOULD BE INCLUDED IN THE RECALL!

AIRBAG LIGHT COMES ON AND STAYS ILLUMINATED. WE ARE UNSURE IF THE SYSTEM IS WORKING PROPERLY. WE HAVE NOT RUN DIAGNOSTIC CODES ON THE SYSTEM.

THE VEHICLE WAS HARD TO STEER AND SMOKE WAS COMING FROM THE ENGINE. TOOK THE CAR HOME, DID NOT SEE FLAMES, PARKED CAR IN THE DRIVEWAY SWITCHED CARS AND LEFT. RECEIVED A CALL FROM THE FIRE DEPARTMENT THAT MY MINI WAS ON FIRE AND I NEEDED TO RETURN TO MY HOUSE.

THE POWER STEERING IN MY 2004 MINI COOPER S FAILED LAST MONTH, PROMPTING ME TO RESEARCH WAYS TO FIX THE VEHICLE ONLINE. I FOUND THAT MINI USA HAD ISSUED A RECALL ON MY CAR, BUT WAS INFORMED BY THE DEALERSHIP AND THEN MINI THAT MY VIN NUMBER DID NOT FALL AMONG THOSE VEHICLES RECALLED. I'M WONDERING WHETHER MINI APPROPRIATELY LIMITED THEIR RECALL CONSIDERING MY VEHICLE HAS THE SAME PROBLEM THAT PROMPTED THE RECALL, AND FALLS WITHIN THE SAME MODEL AND YEAR RANGE. I THINK THE DEPARTMENT SHOULD INVESTIGATE WHETHER TO EXPANDING THE RECALL.

THE AIRBAG LIGHT IS ON FOR THE PASSENGER SIDE PRESSURE MAT BUT THE DEALERSHIP INDICATES THERE IS NO OPEN RECALL ON THIS PARTICULAR CAR EVEN THOUGH MANY CARS WITH SIMILAR PROBLEM WERE RECALLED. SCAN TOOL INDICATES PASSENGER SIDE PRESSURE MAT. THE DEALERSHIP INDICATED THIS MODEL WAS OUTSIDE OF THE RECALLED VINS. WE DON'T KNOW WHETHER THE AIRBAG WOULD WORK OR NOT IF IT WERE NEEDED.

TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT STATED THAT THERE WAS A PROGRESSING CONDITION IN WHICH THE STEERING WHEEL MADE AN ABNORMAL NOISE AND WAS DIFFICULT TO TURN LEFT OR RIGHT. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.