2007 MINI COOPER Complaints

THIS VEHICLE HAS TWICE HAD A FAILURE OF THE TIMING CHAIN AS A RESULT OF A FAULTY TENSIONER, RESULTING IN CATASTROPHIC ENGINE FAILURE. THE FIRST INCIDENT OCCURRED FROM A DEAD STOP IN A PARKING LOT SO THERE WAS NO IMMEDIATE SAFETY ISSUE. THE SECOND INCIDENT, OCCURRING 12/03/2012, MANIFESTED AS THE VEHICLE WAS DE-ACCELERATING COMING OFF A HIGHWAY EXIT WITH A TOTAL LOSS OF POWER AT THE BOTTOM OF THE EXIT, IN A REMOTE AREA. MINI COOPER SENT THEIR TECHNICIANS IN 2007 A "SERVICE BULLETIN," SHORT OF A RECALL, WHEN THE TREND WAS DISCOVERED AMONG ITS "R56' MODEL ENGINES IN 2008. I HAD WARNED MINI OF SOUNDS WHICH LATER WERE DETERMINED BY INDEPENDENT EXPERTS TO BE THE TIMING CHAIN'S "DEATH RATTLE" PRIOR TO THE FIRST FAILURE, WHICH THEY ATTRIBUTED TO THE CAR'S "GO-KART LIKE START UP." AFTER 6 MONTHS OF STRUGGLING, MINI AGREED TO 80% OF THE REPAIR COSTS, WITH A NEW TIMING CHAIN UNDER A ONE YEAR WARRANTY. OTHER FAILURES SIDELINED THE VEHICLE FOR MONTHS IN THE INTERVENING TIME, AND DUE TO THE INCREDIBLE COST OF REPAIR THE VEHICLE HAD TO BE GARAGED UNTIL REPAIRED. SO ALTHOUGH OVER A YEAR PASSED BETWEEN TIMING CHAIN FAILURES, ABOUT ONLY ABOUT 39K MILES WERE DRIVEN IN THAT TIME. AS OF NOW, MINI IS ONLY OFFERING 50% CULPABILITY, THIS AFTER STARTING A VOCAL TWITTER CAMPAIGN. I STILL OWE $10K ON A VEHICLE THAT REQUIRES UP TO $5K IN REPAIRS- A REPAIR WHICH WILL ONLY REPLACE A DEFECTIVE PART WITH THE SAME DEFECTIVE PART. *TT

WHILE DRIVING I NOTICED THAT MY RIGHT FOOT WAS GETTING HOT. I MOVED MY HAND DOWN TO THE GAS PEDAL AREA AND FELT A LOT HEAT WHICH I LATER DETERMINED TO BE COMING FROM THE PLASTIC PANEL TO THE RIGHT OF THE GAS PEDAL. IT WAS SO HOT THAT IT WAS DIFFICULT TO TOUCH WITH MY BARE HANDS. *TR

TIMING CHAIN FAILURE CAUSED IMMEDIATE ENGINE FAILURE AT HIGHWAY SPEED. DAMAGED TIMING CHAIN HOUSING CRACKED CAUSING OIL TO SPRAY THE HOT ENGINE. SUBSEQUENT OIL STARTED A SMALL FIRE THAT WAS EXTINGUISHED BY DRIVER. *TR

I HAVE BEEN A MINI COOPER OWNER SINCE 2007 AND LOVED MY MINI. IT WAS A 6 SPEED AUTOMATIC AND EVEN THOUGH IT HAD APPROX. 127K MILES, IT DROVE GREAT AND I HAD NEVER EXPERIENCED ANY PROBLEMS WITH IT IN THE SIX YEARS I OWNED IT. IN JULY 2013, I WAS DRIVING DOWN A HIGHWAY AT 65MPH AND HEARD A VERY FAINT PERCOLATING SOUND COMING FROM INSIDE THE DASH. THE CAR WAS RUNNING FINE AND THERE WERE NO WARNING LIGHTS SO I KEPT DRIVING BECAUSE I WAS IN A DESERTED AREA AT NIGHT. APPROXIMATELY TWO MINUTES LATER, I SAW A FLAME OUTSIDE MY RIGHT PASSENGER SIDE WINDOW. I IMMEDIATELY STOPPED THE CAR AND SAW THERE WERE FLAMES COMING FROM BEHIND THE PASSENGER TIRE OF THE VEHICLE AND FROM UNDER THE HOOD. I CALLED 911 BUT WITHIN MINUTES, THE ENTIRE HOOD AND FRONT SEATS OF THE CAR WERE IN FLAMES. BY THE TIME THE FIRE DEPARTMENT ARRIVED, THE CAR WAS A COMPLETELY ENGULFED BY THE FIRE. NOTHING FROM INSIDE THE VEHICLE COULD BE RECOVERED. OTHER THAN THE FAINT PERCOLATING SOUND AND A SLIGHT ODOR IMMEDIATELY BEFORE I SAW THE FLAMES, THERE WAS NO WARNING. THE FIRE DEPARTMENT RULED THE FIRE AN UNDETERMINED MECHANICAL CAUSE AND SAID IT STARTED ON THE RIGHT PASSENGER SIDE OF THE ENGINE COMPARTMENT. *TR

ENGINE BAY STARTED SMOKING. PULLED THE CAR OVER AND NOTICE THE TURBO OIL LINE WAS LEAKING HOT OIL EVERYWHERE. COULD OF RESULTED IN A ENGINE BAY FIRE. *TR

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THE BRAKE WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE BRAKES HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO THEN STATED THAT THE ANTI-SKID SYSTEM HAD FAILED AND AS A RESULT, THE DSC MODULE WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 34,000 AND THE CURRENT MILEAGE WAS 41,000.

THE AIR BAG LIGHT IS ON AND THE PASSENGER AIR BAG IS OFF LIGHT IS ALSO ON EVEN IF THERE IS A PASSENGER SEATING. BASED ON THE NUMBER OF COMPLAINTS HERE FOR THE SAME ISSUE, IT LOOKS LIKE THIS IS A DEFECTIVE PART. THIS IS A MAJOR SAFETY ISSUE WHERE THE AIRBAG MIGHT OR MIGHT NOT DEPLOY IN CASE OF AN ACCIDENT. THE DEALER WANTS $1,200 TO GET THIS FIXED. *TR

I TOOK MY CAR INTO MY LOCAL SHOP AND HAD OIL CHANGE,NEW BATTERY,TIRES ROTATED AND ALIGNMENT .THEY COULD A NOISE FROM THE ENGINE AND THEY CHECKED IT OUT. CALL ME TO INFORM ME THAT I HAD TO TAKE TO THE MINI COOPER DEALERSHIP BECAUSE THE TIMING CHAIN NEEDED TO BE REPLACE. I CALLED MINI COOPER AND SPOKE TO [XXX] AT THE HOUSTON DEALERSHIP MOMENTUM MINI. SHE INFORMED ME THAT THE COST WOULD BE ANYWHERE FROM 4000 TO 10,000 DOLLARS. I EXPLAINED TO HER I HAD THE CAR FOR 1 YEAR AND HAVE ANY DRIVEN 6000 MILES IN A YEAR. AFTER DOING RESEARCH I NOTICED THAT OTHER PEOPLE WHERE HAVING THE SAME ISSUES WITH THERE MINI. I PURCHASED THIS CAR WITH 39,126 MILES ON IT AND MY DAILY DRIVE TO WORK IS A QUARTER MILE IF THAT. PLEASE HELP !!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHILE IN IDLE AND ANY RPM, A RATTLE/GROWLING SOUND COULD BE HEARD COMING FROM UNDER THE TIMING CHAIN HOUSING OF THE ENGINE. WHEN SHIFTING IT WAS HARDER TO PLACE INTO GEAR WITHOUT GRINDING AND VERY EASY TO MISS A GEAR WHEN SHIFTING. MASTER MECHANIC DIAGNOSED THIS HAS A FAILING/FAILED TIMING CHAIN. A NEW TIMING CHAIN WAS INSTALLED, COSTING ME $1,400. ONE WEEK AFTER BEING FIXED THE SAME SOUND IS ARISING FROM THE TIME CHAIN HOUSING AND NEED TO BE TAKEN BACK IN FOR A NEW CHAIN YET AGAIN. THIS IS NOT THE FIRST TIME THE TIMING CHAIN HAS BEEN REPLACED ON THIS MINI COOPER, IT IS JUST THE 1ST WHILE I HAVE BEEN THE OWNER OF THE CAR AND SEEMS TO BE AN ONGOING ISSUE WITH IT. *TR

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT COOLANT WAS LEAKING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE TRANSMISSION MOUNT WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE COOLANT HOUSING AND THE TRANSMISSION MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 70,000.