2007 MINI COOPER S Complaints

The contact owns a 2007 Mini Cooper S. The contact stated that water was entering the vehicle through the sunroof. The contact stated that the water was collecting inside the headliner and would overflow and leak down the driver’s and passenger’s side sun visors and into the electronics of the footwell. Additionally, the front driver’s and passenger’s seats, floorboards, and dashboard would become soaked from moisture. Due to the failure, the vehicle would fail to start or operate as needed. Upon investigation, the contact discovered NHTSA Campaign Number: 23V337000 (Electrical System); however, the VIN was not included in the recall. An independent mechanic was notified about the failure and the contact was advised to park the vehicle outside as the failure could cause the vehicle to catch on fire. The manufacturer was then notified of the failure and the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 140,000.

The contact owns a 2007 Mini Cooper S. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, the sunroof was inoperative. The contact waited for several minutes for the sunroof to return to normal operation. The "Passenger Air Bag Disabled" message was displayed on the instrument panel; however, the passenger’s seat was occupied. The infotainment system was unintentionally turned on while the vehicle was turned off. The check engine and low tire pressure warning light were intermittently illuminated. The failures occurred on several different occasions. The contact stated that there was no local dealer; a dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. Parts distribution disconnect.

The contact owns a 2007 Mini Cooper S. The contact stated that while driving approximately 35-40 MPH, the parking brake engaged, and the vehicle came to a stop. The contact manually pulled the parking brake lever several times until the parking brake released. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who was unable to determine the cause of the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 48,000.

VEHICLE WAS STATIONARY IN MY DRIVEWAY, WAS NOT STARTED AND WAS UNATTENDED, HAD NOT BEEN STARTED IN OVER A WEEK AND KEYS WERE NOT IN THE VEHICLES. THE VEHICLE SPONTANEOUSLY BURST INTO FLAMES WHICH BURNED THE ENGINE BAY AND FRONT END OF THE CAR BEFORE THE FIRE DEPT. ARRIVED AND EXTINGUISHED THE FIRE WITH FOAM. THE CAR HAD BEEN SITTING UNSTARTED FOR OVER A WEEK. I AM UNSURE OF WHAT CAUSED THE FIRE AND BECAUSE OF THE EXTENSIVE DAMAGE TO THE ENGINE BAY I COULD NOT DETERMINE WERE THE FIRE ORIGINATED. PERHAPS A PROFESSIONAL FIRE EXAMINER COULD DETERMINE THAT. I AM BLESSED THAT THIS DID NOT HAPPEN WHILE PARKED IN MY GARAGE BUT WAS SCARY. I JUST WANT THIS INCIDENT ON RECORD SO THAT OTHERS WHICH OWN THIS PARTICULAR TYPE OF VEHICLE CAN BE WARNED ABOUT THE POTENTIAL DANGERS. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAD A COUPLE OF UPDATES DONE PER BMW SUCH AS THE TAILPIPES AND TIMING CHAIN IN THE ENGINE. I WAS NOT AWARE OF ANY ADDITIONAL RECALLS OR UPDATES BUT APPARENTLY THERE HAVE BEEN SOME INCIDENCES OF FIRES SUCH AS MINE WHICH I LEARNED ABOUT AFTER SEARCHING THE INTERNET TO SEE IF SIMILAR ISSUES HAD BEEN DOCUMENTED. I WILL ATTACH A FEW PICTURES FOR YOU TO HELP WITH YOUR ASSESSMENT. THANK YOU FOR YOUR TIME AND CONSIDERATION. I HOPE THIS INFORMATION WILL BE SOME HELP TO OTHERS IN PREVENTING A SIMILAR SITUATION. I THANK GOD NO ONE WAS INJURED OR PROPERTY DAMAGED OTHER THAN MY CAR. THE FIRE DEPARTMENT MADE A REPORT BUT IT DID NOT INCLUDE INVESTIGATING THE CAUSE JUST A RESPONSE TO A FIRE. *TR

PASSENGER SEAT MAT OCCUPANCY SENSOR/PAD HAS GONE BAD AGAIN AFTER THE RECALL.*DT SAFETY RECALL REPORT XXX-XXX 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

I HAVE BEEN DRIVING MINI S 2007 FOR MORE THAN A YEAR WITH NO SERIOUS ISSUES OTHER THAN ONE CHECK ENGINE LIGHT ISSUE, WHICH WAS RESOLVED SIMPLY BY A MECHANIC CHECK AT BMW SERVICE CENTER. ON SUNDAY EVENING MAY 26, 2019, AS I WAS PLANNING TO GO OUT, I OBSERVED THE STEERING ALERT SIGN ON. I TRIED RESTARTING AND SHUTTING OFF ENGINE MULTIPLE TIMES THINKING IT MAY BE AN ELECTRONIC ABERRATION WHICH MAY BE KICKED AWAY BY BRUTE FORCE OF RESTARTING THE IGNITION. AFTER 30-45 MINUTES OF THIS FRUITLESS EXERCISE, I TURNED MY ATTENTION ONLINE WHERE I FOUND NUMEROUS AUTO BLOGS OF STARTING THE CAR WITH JUMPERS BATTERY TO REPLACING POWER STEERING FLUID. SINCE MINI SERVICE WAS CLOSED, I HAD TO SEEK HELP FROM MY INSURANCE COMPANY. THEY SENT A PERSON AFTER TWO HOURS TO USE JUMPERS, BUT THAT DID NOT HELP EITHER. WE WERE ABLE TO CHECK THE POWER STEERING FLUID , AND THAT WAS ALSO FULL TO THE MARK. ON FURTHER RESEARCH ONLINE, I DISCOVERED TO MY UTTER DISAPPOINTMENT THAT MINI COOPERS HAVE BEEN PLAGUED WITH POWER STEERING ISSUES DUE TO INHERENT FLAW OF PLACEMENT AND DESIGN OF POWER STEERING PUMP. IT IS VERY WELL DOCUMENTED ACROSS REPUTED CAR JOURNALS/MAGAZINES THAT THE POWER STEERING PUMP FAILURE WILL DEFINITELY HAPPEN IN MINI COOPERS, AND THE ONLY VARIABLE IS THE TIME. I WAS THOROUGHLY CRESTFALLEN GIVEN I HAD PLACED SO MUCH TRUST IN THE BRAND AND THE QUALITY OF MINI COOPER. THE PURPOSE OF THIS COMPLAINT IS TWO PRONGED- ONE IS OBVIOUSLY TO HIGHLIGHT THE PROBLEM ONCE AGAIN AND MAKING SURE MINI ENGINEERS SOLVE THIS PROBLEM IN THEIR ENGINEERING DESIGN PROCESSES. SECOND- IS TO REQUEST TO HAVE THE POWER STEERING ISSUE FIXED IN MY CAR BY MINI. GIVEN THAT THE ISSUE HAS BASIS IN THE INHERENT FLAW OF THE DESIGN, I BELIEVE MINI COOPER WILL WAIVE OFF THE COST OF SERVICES AND PARTS TO GET THIS ISSUE FIXED. THIS IS NOT USUAL WEAR AND TEAR WHOSE COSTS SHOULD BE BORNE BY THE CUSTOMER.

THE TURBOCHARGER HAD TO BE REPLACED, NEW TURBO GOT HOT AND MELTED THE VALVE COVER. THEN THE TURBOCHARGER CAUGHT FIRE WHILE IN MOTION IN A RURAL NEIGHBORHOOD. ALL WITHIN 6 MONTHS.

TO THE RIGHT OF MY GAS PEDAL IN MY CAR GETS SUPER HOT! IT REACHES OVER 207 FAHRENHEIT DEGREES. IT GETS WORSE WHEN I USE MY AC. WHEN I WEAR MY FLIP FLOPS IT BURNS MY TOES.

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THERE WAS A CATASTROPHIC ENGINE FAILURE WITHOUT WARNING. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BRAMAN MINI OF PALM BEACH (2815 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409, (561) 257-4774). THE DEALER INDICATED THAT THE MANUFACTURER SERVICE CAMPAIGN WAS ONLY TO ADDRESS REPLACING THE TIMING CHAIN AND THAT THE REPLACEMENT OF THE ENGINE ASSEMBLY WAS NOT INCLUDED IN THE MANUFACTURER'S GUIDELINES OF THE SERVICE CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THEY COULD APPROVE THE DEALER REPLACING THE TIMING CHAIN AND THE ENGINE ASSEMBLY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

MY VEHICLE IS CURRENTLY @ BRAMAN BMW WPB (5612423210) FOR A TIMING CHAIN PROBLEM WHICH WAS UNDER RECALL. THE SERVICE ADVISOR CALLED ME AND NOTIFIED ME THAT THE TIMING CHAIN BROKE INSIDE THE ENGINE & COMPLETELY DESTROYED THE MOTOR. TE TIMING CHAIN JOB ALONE ESTIMATE IS $3800, BUT THEYVE NOTIFIED ME THAT THE ENGINE IS UNREPAIRABLE & MUST BE REPLACED! THEY ALSO FAILED TO ACKNOWLEDGE THAT THIS HAPPEN WHILST DRIVING ON AN INTERSTATE, ALMOST CAUSING A HUGE ACCIDENT!! PLEASE HELP!! MINI APPARENTLY CARES MORE ABOUT MONEY THAN LIVES!!